Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Summary of Contents for EBO VW 1350 HB
- Page 1 USER MANUAL VW 1350 HB – The Manual Operated VMS-Trailer...
-
Page 2: Foreword
Contact Information: Due the fact that the products of EBO van Weel B.V. are constantly Address EBO van Weel B.V. being improved, EBO van Weel B.V. reserves the right to make changes Achterdijk 49 to specifications without notice. -
Page 3: Revision Log
REVISION LOG Type of expenditure Version Number Date Initial release V1.0 06-01-2016 Revision V1.1 24-10-2017 User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 4: Table Of Contents
Machine commissioning procedure ..........14 Operation characteristics and limitations of the machine ..14 Physical machine controls ............. 14 Apply an animation ..............16 Charging ................17 Maintenance (owner) ..............18 User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 5: Safety Signals
1 SAFETY SIGNALS Danger Sign (Beware!) Voltage Supply User Instructions Explosion Hazard Corrosive Substances Pinch Hazard Extendible Support on Shoe User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 6: General Specifications
4 x (standard semi-traction) Chart 1 Battery capacity 230 Ah (standard) Battery charger 230 Volt / 40 Amp. Solar panels 2 x (standard) Maximum power solar panel 200 Watt per piece User Manual VW 1350 HB – The Manual Operated VMS-Trailer... - Page 7 2.2.2 LOCATION OF THE SERIAL NUMBER This machine has various lubrication points which are mounted on Each EBO van Weel B.V. machine has its own identification sticker. This rotating parts. These important points should be lubricated every six sticker is mounted on the front of the chassis. Also the serial number is months.
- Page 8 It is important to check the battery water level. When the water is below level, please complement this with distilled or demineralized water. Please note: when other batteries are installed, please check with EBO van Weel B.V. to perform good maintenance. This is very important because the batteries are connected with a programmable battery charger.
-
Page 9: Safety Measures
3.2.1 TRAINING OF THE USER Please make sure that the user has been given a thorough explanation by an authorised person. If not, please contact EBO van Weel B.V. for a training and instructions. User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 10: Installation And Inspection Of The Machine
3.3.1 BEFORE USING THE MACHINE Winter: Remove ice and snow before operation in winter. Check the hinges Before using the EBO van Weel B.V. machine, please check the holding the upper panel and the adjustment drive for proper movability. following points: We recommend cleaning by hand using commercial automobile care 1. - Page 11 Extendible support legs The extendible support legs are manually operated and can be moved with a caravan pendulum “up and down”. The caravan pendulum can be stored in one of the compartments. User Manual VW 1350 HB – The Manual Operated VMS-Trailer...
- Page 12 LED modules Weel SBC communication error Contact EBO van Critical other print Weel Contact EBO van SBC temperature too high Critical Weel Received incorrect Contact EBO van Critical parameters Weel User Manual VW 1350 HB – The Manual Operated VMS-Trailer...
-
Page 13: Towing, Lifting, Transporting
Allow a sufficient length of the lifting straps. fitted on the towing vehicle‘s tow ball. If the coupling is not properly performed, the trailer might detach itself from the towing vehicle User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 14: Machine Commissioning Procedure
1. Disconnect the machine from the towing vehicle and use the nose wheel of the machine. Please use the handbrake of the machine. 2. Please use the extendible stamps. Figure 7 User Manual VW 1350 HB – The Manual Operated VMS-Trailer... - Page 15 Do not forget to lock the compartment doors to prevent vandalism. Figuur 9 4. Turn the main switch to ‘’ON’’ in the main box in the front compartment (Figure 2), the display is now in stand-by mode. User Manual VW 1350 HB – The Manual Operated VMS-Trailer...
-
Page 16: Apply An Animation
2. Each animation has its own number in Traffic Fleet. By pushing the numbers +1 until +10, it’s possible to choose the requested User Manual VW 1350 HB – The Manual Operated VMS-Trailer... -
Page 17: Charging
4. When the charger indicator LED doesn’t light up, the following work anymore, please check if the switch-plug is working. If the charger points may be affective: is still broken, please contact EBO van Weel B.V. for more information. ▪ One or more batteries are defect; ▪ Fuse is melted;... -
Page 18: Maintenance (Owner)
Conversions or changes to the machine are only allowed following written approval by the manufacturer. To preserve functionality and safety, only original components from EBO van Weel B.V. must be used when the need for spare parts arises. A use of other parts will annul liability for the related consequences. -
Page 19: Faults
6.2 EBO VAN WEEL SUPPORT If you are unable to solve the problems with help of the service manual, please contact EBO van Weel support. This may be desirable to solve the complex problems of the machine. This could be done on location if possible.
Need help?
Do you have a question about the VW 1350 HB and is the answer not in the manual?
Questions and answers