Do you have a question about the Daytripper and is the answer not in the manual?
Questions and answers
Subscribe to Our Youtube Channel
Summary of Contents for Schwinn Daytripper
Page 1
Read these instructions carefully before use and keep them for future reference. Your safety may be affected if you do not follow these instructions. The Schwinn Bicycle Trailer must be assembled by an adult who has read and understands the instructions in this manual.
Page 2
Thank You For purchasing the Schwinn Cargo Trailer. If you have any questions or comments our customer service hours are: 8:00 AM - 5:00 PM Monday through Friday CST. You may also reach us through the following: Web: www.pacific-cycle.com Email: customerservice@pacific-cycle.com Mail: P.
• Dispose of all plastic bags and wrapping material immediately. other obstacles. • Make sure tow bar safety strap is properly secured, for additional safety Schwinn Cargo Trailer • model 13-SC320...
• Do not leave trailer outside after use. Inclement weather and harsh elements may stress the fabric on the trailer • Never leave your cargo unattended • Do not transport flammable, explosive, poisonous, or other hazardous material in your trailer Schwinn Cargo Trailer • model 13-SC320...
Elastic bands (2) for cord attachment canopy buckles Reflector Flag pole elastic band Canopy Rear canopy buckle (2) Front canopy buckle (2) Flagpole sleeve Bicycle coupler Safety strap Tow bar Wheels (2) Tow bar locking pin Schwinn Cargo Trailer • model 13-SC320...
Remove the locking pin from the tow bar bracket. Figure 3.1 Locking ❷ Rotate the tow bar out and away from the trailer. The tow bar should rest on the front of the frame. Figure 3.1 Tow bar bracket Figure 3.1 Schwinn Cargo Trailer • model 13-SC320...
❶ Remove the caps from the ends of the wheels axles. ❷ Insert the axle of the wheel completely into the hole located on the side of the wheel bracket. Figure 3.3 Figure 3.2 Figure 3.3 Schwinn Cargo Trailer • model 13-SC320...
Page 9
❹ Repeat steps 2 and 3 for the remaining wheel. Figure 3.5 slide the end of the safety loop over the end of the locking pin. Check that the locking pin is securely in place. Figure 3.4 Figure 3.4 Figure 3.5 Schwinn Cargo Trailer • model 13-SC320...
• Ensure that all locking devices are engaged before use. ❶ Holding the end of the tow bar, lift the tow bar and rotate the bar up and around until the trailer is right side up. Figure 3.6 Figure 3.6 Figure 3.7 Schwinn Cargo Trailer • model 13-SC320...
Page 11
❸ Lift the left side wall up into a vertical position. Figure 3.8 ❹ Rotate the back crossbar until it locks into the back crossbar latch. Figure 3.9 Release button Crossbar latch Figure 3.8 Figure 3.9 Schwinn Cargo Trailer • model 13-SC320...
Page 12
❻ Pull the canopy over the back end of the trailer. Figure 3.11 latch. Figure 3.10 ❼ Secure the canopy by fastening the buckles on the sides of the trailer. Figure 3.11 Release button Crossbar latch Figure 3.10 Figure 3.11 Schwinn Cargo Trailer • model 13-SC320...
❶ Insert the top half of the pole into the opening of the bottom half of the pole. ❷ Insert the flag pole through the elastic loop on the back of the trailer and into the flag pole sleeve. Figure 3.13 Elastic loop Figure 3.12 Figure 3.13 Schwinn Cargo Trailer • model 13-SC320...
❸ Place the tab washer on the axle. Fit the tab into the slot on the bicycle frame dropout. Note: If your bicycle frame doesn’t have a slot in the drop out, rotate the tab to fit into the axle slot. Figure 4.3 Slot washer Figure 4.3 Schwinn Cargo Trailer • model 13-SC320...
Page 15
❹ Remove the locking pin from the coupler and slide the coupler ❻ Place the hub nut and washer back onto the axle and tighten. off the end of the tow bar. Figure 4.5 Incorrect coupler placement Coupler Washer Hub nut Figure 4.4 Figure 4.5 Schwinn Cargo Trailer • model 13-SC320...
Page 16
Figure 4.6 Inner Skewer Spring Outer Quick spring release lever Quick release lever and spring Figure 4.6 Figure 4.7 Schwinn Cargo Trailer • model 13-SC320...
Page 17
❻ Rotate the quick release lever up and tighten. When properly tightened, the quick release lever should leave an imprint in your hand. The pressure should be firm but not excessive. Quick release lever and spring Slot washer Figure 4.9 Figure 4.8 Schwinn Cargo Trailer • model 13-SC320...
Page 18
This reduces stress on the tow bar. Figure 4.10 from the wheel to prevent possible friction against the wheel and spokes of the bicycle. ❽ Insert the locking pin into the hole on the top of the coupler. Figure 4.10 Figure 4.11 Schwinn Cargo Trailer • model 13-SC320...
Tow bar ring ❶ Wrap the tow bar safety strap around the bicycle frame. Figure 4.12 Bicycle frame Safety strap Safety strap Figure 4.12 Figure 4.13 Schwinn Cargo Trailer • model 13-SC320...
This can create a hazard by interfering with the bicycle, ground, or other obstacles such as curbs, signs, cars, etc.) • Storing the trailer inside after use. Inclement weather and harsh elements may stress the fabric on the trailer Figure 5.1 Schwinn Cargo Trailer • model 13-SC320...
Page 21
Figure 5.3 trailer. Note: The top canopy is not weather proof. Figure 5.2 Figure 5.2 Figure 5.3 Schwinn Cargo Trailer • model 13-SC320...
• Always fold or unfold the trailer slowly and with caution. • Keep children clear when folding or unfolding the trailer. ❶ Remove the flag pole and separate the flag pole sections. Figure 6.1 Figure 6.1 Figure 6.2 Schwinn Cargo Trailer • model 13-SC320...
Page 23
❸ Fold the left and right side walls down. Figure 6.3 ❹ Remove the locking pins from the wheels. Pull the wheels out of the wheel brackets. Figure 6.4 Figure 6.3 Figure 6.4 Schwinn Cargo Trailer • model 13-SC320...
Page 24
❻ Rotate the tow bar back into the frame. Insert the locking pin through the tow bar and frame. Secure the safety loop over the end of the locking pin. Figure 6.6 Figure 6.5 Figure 6.6 Schwinn Cargo Trailer • model 13-SC320...
• 1pc Tab Washer be shipped, postpaid, to Pacific Cycle, Inc. • 1pc Locking Pin Please direct any accessory (small parts) and warranty inquiries to Pacific Cycle Customer Service at 1-800-242-6110. Schwinn Cargo Trailer • model 13-SC320...
Need help?
Do you have a question about the Daytripper and is the answer not in the manual?
Questions and answers