Advertisement
Quick Links
TC2000 (CE)
English
Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • (847)741-3300 • FAX (847)741-4406
Conveyor Oven
Model TC2000
OWNER'S OPERATING AND
INSTALLATION MANUAL
© 1999 Toastmaster, A Middleby Company.
is a registered trademark of Toastmaster, A Middleby Company. All rights reserved.
WARNING: IN CASE OF FIRE
Disconnect the oven from its power source
IMMEDIATELY. This allows the unit to cool,
making it easier to put out the fire.
WARNING
FOR YOUR SAFETY DO NOT STORE OR
USE GASOLINE OR OTHER FLAMMABLE
VAPORS OR LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER APPLIANCE
WARNING
IMPROPER INSTALLATION, ADJUST-
MENT, ALTERATION, SERVICE OR MAIN-
TENANCE CAN CAUSE PROPERTY DAM-
AGE, INJURY OR DEATH. READ THE IN-
STALLATION AND OPERATING INSTRUC-
TIONS THOROUGHLY BEFORE INSTALL-
ING OR SERVICING THIS EQUIPMENT.
WARNING
DISCONNECT THE OVEN FROM ITS ELEC-
TRICAL POWER SUPPLY BEFORE CLEAN-
ING OR SERVICING.
All manuals and user guides at all-guides.com
CAUTION
Using any parts other than genuine Toastmaster
factory parts relieves the manufacturer of all
liability.
IMPORTANT
Contact your authorized service agent to perform
maintenance and repairs. A service agency
directory is supplied with your oven.
IMPORTANT
Toastmaster (manufacturer) reserves the right to
change specifications and product design with-
out notice. Such revisions do not entitle the buyer
to corresponding changes, improvements, addi-
tions or replacements for previously purchased
equipment.
RETAIN THIS MANUAL FOR FUTURE
REFERENCE
This manual provides detailed information for the
installation and operation of your oven. It also
contains information to assist the operator in
diagnosing problems in the event of a malfunc-
tion. This manual is an important tool for the
operator and should be kept readily available.
P/N 42513
Price $5.00
Rev. B • V1 • 11/99
Advertisement
Related Manuals for Toastmaster TC2000
Summary of Contents for Toastmaster TC2000
- Page 1 TC2000 (CE) P/N 42513 English Price $5.00 Rev. B • V1 • 11/99 Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • (847)741-3300 • FAX (847)741-4406 Conveyor Oven Model TC2000 OWNER'S OPERATING AND INSTALLATION MANUAL © 1999 Toastmaster, A Middleby Company.
-
Page 2: Description And Specifications
All manuals and user guides at all-guides.com DESCRIPTION AND SPECIFICATIONS Figure 2 Component Location The major components of the oven are shown in Figure 1 below. Figure 1 8. Fan 7. Adjustable draft curtain (2) 6. Conveyor Installing the Conveyor End Trays - see Figure 3. Conveyor speed Press one of the conveyor end trays down over the end plate... -
Page 3: Operation
All manuals and user guides at all-guides.com Before proceeding with the electrical connection, check that the III. OPERATION electrical supply matches the oven’s requirements. Refer to the Location and Function of Controls serial plate (Figure 4) and to the electrical specifications shown on the wiring diagrams at the back of this Manual. - Page 4 All manuals and user guides at all-guides.com Draft Curtain Adjustment Daily Cleaning The draft curtains may need to be repositioned to provide adequate WARNING clearance for some food products. The curtains should be positioned WHEN CLEANING THE OVEN: to prevent drafts into the oven, and heat loss into the environment. •...
- Page 5 All manuals and user guides at all-guides.com Wiring Diagram - Model TC2000, 230V, 1-Phase TERMINAL BLOCK CONTACTOR TSTAT N.O. TSTAT N.C. FILTER POT 1 TEMP 100KΩ CTRL UPPER HEATING ELEMENT POWER ON/OFF (I/O) SWITCH CONVEYOR SPEED CONTROLLER POT 2 TEMP MOTOR 100KΩ...
- Page 6 MOTOR UPPER TEMP CONTROL 100KΩ UPPER HEATING ELEMENT LOWER TEMP CONTROL LOWER HEATING ELEMENT A Middleby Company Toastmaster • 1400 Toastmaster Drive • Elgin, IL 60120 • USA • (847)741-3300 • FAX (847)741-4406 Middleby Corp 24-Hour Service Hotline 1-800-238-8444 www.middleby.com...