Summary of Contents for Reliance 310
- Page 1 UNCRATING/INSTALLATION INSTRUCTIONS ® RELIANCE Utensil Washer (12/98) P-122990-599 Rev. 2...
- Page 2 LIMITATIONS OF LIABILITY AND INDEMNITY IN NO CASE, WHETHER AS A RESULT OF A BREACH OF CONTRACT, BREACH OF WAR- RANTY OR TORT (INCLUDING STERIS'S OR CUSTOMER'S WILLFUL ACTS OR NEGLIGENCE OR STRICT LIABILITY) SHALL STERIS OR CUSTOMER BE LIABLE TO THE OTHER FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES INCURRED BY THE OTHER, INCLUDING, BUT NOT LIMITED TO, LOSS OF REVENUE, PROFITS OR GOODWILL.
- Page 3 STERIS does not intend, recommend nor represent in any way that this equipment be used for the terminal disinfection or sterilization of any regulated medical device. Reliance Washers are intended only to perform an initial step in the reprocessing of soiled, reusable...
-
Page 4: Table Of Contents
TABLE OF CONTENTS SECTION SECTION TITLE TITLE PAGE PAGE SECTION SECTION SECTION TITLE TITLE TITLE PAGE PAGE PAGE 1 1 1 1 1 SUMMARY OF WARNINGS AND CAUTIONS SUMMARY OF WARNINGS AND CAUTIONS SUMMARY OF WARNINGS AND CAUTIONS ........ -
Page 5: Summary Of Warnings And Cautions
SUMMARY OF WARNINGS AND CAUTIONS The following is a summary of the safety precautions which must be observed when uncrating, installing and checking this equipment. WARNINGS indicate the potential for danger to personnel and CAUTIONS indicate the potential for damage to equipment. These precautions are repeated, where applicable, throughout the instructions. -
Page 6: Uncrating Instructions
UNCRATING INSTRUCTIONS 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 NOTE: This equipment weighs approximately 275 lbs (120 kg). -
Page 7: Prepare Washer For Installation
4. Remove lag screws and washers, on front left side of unit, securing washer base to skid (see Figure 3). WARNING — LACERATION WARNING — LACERATION WARNING — LACERATION WARNING — LACERATION WARNING — LACERATION HAZARD: HAZARD: HAZARD: When removing lag When removing lag When removing lag When removing lag... -
Page 8: Installation Instructions
INSTALLATION INSTRUCTIONS 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 1. -
Page 9: Connect Utilities
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 1. -
Page 10: Operational Test
OPERATIONAL TEST 1. Locate drain valve in washer service compartment (see Figure WARNING — ELECTRIC SHOCK WARNING — ELECTRIC SHOCK WARNING — ELECTRIC SHOCK WARNING — ELECTRIC SHOCK WARNING — ELECTRIC SHOCK 5). Manually operate valve lever to ensure proper operation. AND/OR BURN HAZARD: AND/OR BURN HAZARD: AND/OR BURN HAZARD:... - Page 11 7. Reattach wash arm to bottom of chamber. Close door and press START. Cycle will resume at the beginning of interrupted phase. CAUTION: Once three-phase CAUTION: Once three-phase CAUTION: Once three-phase CAUTION: Once three-phase CAUTION: Once three-phase 8. Check pump rotation. Pump should turn in direction indicated power is connected, check pump power is connected, check pump power is connected, check pump...