Summary of Contents for Home power HPS6000HE/H
- Page 1 TRI-FUEL PORTABLE GENERATORS OWNERS MANUAL MODELS HPS6000HE/H HPS9000VE/D HPS12000HE/E HPS6000HE HPS9000VE HPS12000HE INSTALLATION, OPERATION, and MAINTENANCE INSTRUCTIONS...
-
Page 2: Table Of Contents
COPY YOUR MODEL AND SERIAL Engine Care NUMBER HERE Generator Care No other HOME POWER generator has the same serial Cleaning number as yours. It is important that you record the Troubleshooting - Things To Check BEFORE number and other vital information here. If you should... -
Page 3: Guide To Product Safety
3. DEADLY EXHAUST GAS - Exhaust fumes from any GUIDE TO PRODUCT SAFETY gasoline engine contain carbon monoxide, an invisible, odorless and deadly gas that must be mixed with fresh air. This engine generator set has been designed and manufactured to allow safe, reliable performance. Poor a. -
Page 4: Specifications
SPECIFICATIONS MODEL HPS12000HE Generator MODEL CSAHPS6000HE Surge Watts* 12000 Generator Continuous Watts* 10800 Surge Watts* 6000 Volts 120/240 Continuous Watts* 5500 AMPs @ 240 Volts 45.0 Volts 120/240 AMPs @ 120 Volts 90.0 AMPs @ 240 Volts 22.9 * Derate 10% for LP and 20% for NG AMPs @ 120 Volts 45.8 * Derate 10% for LP and 20% for NG... -
Page 5: Unit Capabilities
The figures given above are for an average load such as a UNIT CAPABILITIES blower or fan. If the electric motor is connected to a hard Generator Connections - The diagram below represents a starting load such as an air compressor, it will require more typical 5500 watt generator. -
Page 6: Unit Preparation
When installing or replacing batteries, use the proper group/ UNIT PREPARATION size starting battery. The battery should be a Maintenance Before your engine generator was shipped from our factory Free lead acid design. Deep cycle batteries will not work it was fully checked for performance. The generator was for this application. -
Page 7: Battery Charging
DANGER – Explosive Fire Risk GASOLINE FUEL Never smoke when near batteries When using gasoline always use a good grade of unleaded Do not cause a flame or spark in the battery area fuel. Leaded gasoline may be used if unleaded is not Always discharge static electricity from your body available. -
Page 8: Installing The Fuel Line
engine is in direct relation to the correctness of the fuel INSTALLING THE FUEL LINE system. Shown below is a block diagram of a typical L.P. DANGER: PERSONAL INJURY or N.G. installation. Units that are intended to be run unattended MUST have an electric fuel solenoid installed. -
Page 9: Tank Sizing
Natural Gas FROM LP/NG TO GASOLINE 1. With the engine running turn off the LP/NG fuel UNIT OFF LINE PSI 7-11 in 7-11 in supply. 4-6 oz 4-6 oz 2. Run the engine until it runs out of fuel. STARTING LINE PSI 7-11 in 7-11 in 3. -
Page 10: Starting Hints
Electric Starting - If the engine is cold and stiff or if the c. While the engine is warm, drain the oil and battery is not fully charged, starting can be made easier by refill with fresh oil. slowly hand cranking the engine through the compression d. -
Page 11: Connecting The Loads
These generators come equipped with a 4 wire 120/240 volt Output voltage should be checked periodically to ensure receptacle designed to power both 120 and 240 volt loads. continued proper operation of the generating plant and There are 2 hots, a neutral, and a ground wire connection in appliances. -
Page 12: Operator Care And Maintenance
Do not use petroleum solvents, such as kerosene, to CAUTION: EQUIPMENT DAMAGE attempt to clean the cartridge. They may cause deterioration of the cartridge. DO NOT OIL Failure to properly limit and balance the load applied to the CARTRIDGE, DO NOT USE PRESSURIZED AIR TO generator will cause the generator to produce low voltage CLEAN OR DRY CARTRIDGE. -
Page 13: Cleaning
_______________________________________________ CLEANING Voltage too low *Engine speed is too low. Remove dirt and debris with a cloth or brush. DO NOT use *Generator overloaded. high pressure spray to clean either the engine or the *Defective diode. generator. This high pressure spray could contaminate the *Defective stator. - Page 14 DATE ITEM WORK PERFORMED Page 12 60707-123 1315-00...
-
Page 15: Warranty
12 MONTH LIMITED WARRANTY WINCO, Incorporated warrants to the original purchaser for 12 months* or 1000 hours which ever occurs first, that goods manufactured or supplied by it will be free from defects in workmanship and material, provided such goods are installed, operated and maintained in accordance with WINCO written instructions. *NOTE: Units used for rental, demonstrations, commercial or prime power applications such as construction or utility, are warranted for 90 days. - Page 16 225 S. Cordova Ave. LeCenter, Mn 56057 60707-123 1315-00...
Need help?
Do you have a question about the HPS6000HE/H and is the answer not in the manual?
Questions and answers