Table of Contents
Advertisement
Quick Links
IMPORTANT: READ AND SAVE THESE INSTRUCTIONS
Read all instructions carefully before attempting to assemble, install, operate or service the product described. Failure to comply with
instructions could result in personal injury and/or property damage.
Using this product for any other purpose than it was intended, or not within the operating specifications in this manual will void the warranty
and may cause damage to the fan or serious injury to personnel.
WARNING - TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK
• Do not expose fan to water or rain.
• The power source must conform to the electrical requirements of the fan. Consult your local electrician before wiring and
follow all national, state, and local electrical codes
GENERAL SAFETY
•
This fan is intended for general use only. Do not use near hazardous or explosive materials or vapors.
•
Never insert fingers or any other objects into the fan when in operation.
•
Carefully read all safety messages in this manual and on your equipment safety decals. Follow recommended precautions and safe
operating practices.
•
Disconnect all power and unplug the unit before you inspect, clean or perform maintenance on the components of the unit.
•
Never reach into the unit when it is running; you could become entrapped by the V-belt or injured by the rotating fan blades.
•
The metal frame edges are sharp; don't run your hand along them. Be careful and wear gloves when you reach under the frame to inspect
the PVC pipes and mesh socks.
•
A GFCI (Ground Fault Circuit Interrupter) is recommended for use with this product.
•
If pads and grates are removed for servicing, they must be replaced prior to operating the unit.
WARNING!
cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov.
©2020 Schaefer®. All Rights Reserved.
Portable Evaporative Cooler with
NPBI Technology Operators Manual
WC-1HPNPBI-OSC
WCG-1HPNPBI-OSC
This product can expose you to chemicals, including lead, which is known to the State of California to
M-WC1HPNPBI
WCG-1HPNPBI
WC-1HPNPBI
SERIES
Portable Evaporative Cooler Operators Manual
SCOA-600
Advertisement
Table of Contents
Related Manuals for Schaefer M-WC1HPNPBI
Summary of Contents for Schaefer M-WC1HPNPBI
- Page 1 This product can expose you to chemicals, including lead, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual...
-
Page 2: Table Of Contents
Leaking from the bottom ................................9 OPTIONS AND ACCESSORIES ............................. 10-11 Oscillating spout ..................................10 Water conditioner and cleaner ..............................11 Air filters ...................................... 11 Aluminum grates ..................................11 WARRANTY ....................................11 ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 3: Safety Information
Evaporation Media chemically treated cellulose paper Optional Water Supply standard 3/4" hose connection (garden hose size) • Actual WayCool may vary slightly from unit shown here. Actual WayCool may vary slightly from unit shown here. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 4: Description
The cooling effect also stops if the pads dry. Water gauge Water gauge Pads and grates must be in place before operating unit. Manual Fill ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 5: Cooling Pad Assembly
Do not remove or handle the cooling pads when they are wet, as they damage easily. Run the blower without the pump until pads are dry. With normal care, the pads should last at least two seasons. Abuse or mishandling will reduce their effectiveness and shorten their life. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 6: Blower And Ductwork
Avoid using ceiling fans as they disrupt the airflow from the WayCool. Use as many exhaust fans as possible to create a natural draft through the building. This will enhance the performance of the WayCool. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 7: Unpacking And Initial Setup
With proper use and regular cleaning, the cooling pads will last about two seasons. If you handle them wet and are abusive, however, they will be easily damaged. Refer to page 15 for recommended conditioning and cleaning chemicals. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 8: Normal Startup
The unit should be cleaned thoroughly before storing. NPBI TECHNOLOGY WARNING: Disconnect the waycool from power before performing service to the NPBI device or any part on Schaefer Defender WayCool. -
Page 9: Troubleshooting
Check for cracks in the reservoir. If a crack is found, repair it by using a WayCool Repair Kit or replace the entire bottom. Order replacement parts from your dealer. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 10: Options And Accessories
This is done by removing the two female disconnects that are attached to the back of the oscillator switch. Do not attempt to stop spout from oscillating! ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... -
Page 11: Water Conditioner And Cleaner
Parts that need replacement due to normal wear and tear. Superficial or cosmetic rust or corrosion. Any product whose name plate has been removed. A full warranty statement may be printed or downloaded from www.schaeferventilation.com. ©2020 Schaefer®. All Rights Reserved. Portable Evaporative Cooler Operators Manual... - Page 12 Product specifications subject to change. www.schaeferventilation.com • 800-779-3267 All information, illustrations and specifications provided here are based on the latest product information available at the time of printing. Product specifications subject to change. ©2020 Schaefer All rights reserved. ®...
Need help?
Do you have a question about the M-WC1HPNPBI and is the answer not in the manual?
Questions and answers