Periodic Service Schedules - Club Car 2007 Precedent Owner's Manual

Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent
further damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car distributor/dealer to perform all repairs and semiannual and annual periodic service.
ý
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle
until repairs are made. Failure to make necessary repairs could result in fire, property
damage, severe personal injury, or death.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing
even simple repairs or service should have knowledge and experience in electrical and
mechanical repair. The appropriate instructions must be used when performing maintenance,
service, or accessory installation.
Electric vehicles:
• Hot! Do not attempt to service hot motor. Attempting to do so could cause severe burns.
• To avoid unintentionally starting the vehicle, disconnect the batteries as shown (Figure 1,
Page 11).
• After disconnecting the batteries, wait 90 seconds for the controller capacitors to discharge.
Gasoline vehicles:
• Moving parts: Do not attempt to service gasoline vehicle while the engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning
could result in severe burns.
• Turn the fuel shut-off valve to the closed (OFF) position (Figure 20, Page 29).
• To avoid unintentionally starting the vehicle, before servicing always disconnect the battery,
negative (–) cable first (Figure 2, Page 11) and disconnect the spark plug wire from the spark
plug.
• Frame ground – Do not allow tools or other metal objects to contact frame when
disconnecting batteries or other electrical wiring. Never allow a positive wire to touch the
vehicle frame, engine, or other metal component.

PERIODIC SERVICE SCHEDULES

ý
WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and
service manual.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive
maintenance procedure should be performed more often than recommended in the periodic ser-
vice and lubrication schedules.
2007 Precedent Golf Car Owner's Manual
Periodic Service Schedules
Page 31