Table of Contents
Advertisement
73268pr-0920 HDepot.qrk
6/29/01
Problem
Vehicle was running but
suddenly stopped
Short run time (less than
1 - 3 hours per charge)
10:56 AM
Page 22
Problems and Solutions Guide
Possible Cause
Loose wire or loose connectors
Tripped thermal fuse
Undercharged battery
Overcharged battery
Battery is old and will not
accept full charge
Tripped thermal fuse
22
Solution
Check all wires and connectors. Make sure the battery
connector is tightly plugged into the motor harness
connector, and that there are no loose wires around
the motor.
The built-in thermal fuse may "trip" and shut down operation
of the vehicle if the vehicle is overloaded or the driving con-
ditions too severe. The fuse will automatically reset itself
after approximately 25 seconds allowing the vehicle to
resume normal operation. To avoid repeated automatic shut
downs, do not overload the vehicle by exceeding the 65 lb.
maximum weight capacity or by towing anything behind the
vehicle. Do not drive up hills or run into fixed objects, which
can cause the wheels to stop spinning while power is still being
supplied to the motors. If the thermal fuse continually trips,
contact your local Power Wheels
®
authorized service center.
Charge the battery. A new battery should have been
charged for at least 18 hours before using the vehicle for
the first time. After first-time use, recharge the battery for
at least 14 hours after each use. Never charge the
battery longer than 30 hours.
Check all wires and connectors. Make sure the battery
connector is tightly plugged into the charger connector,
and that the charger is plugged into the wall.
Make sure power flow to the wall outlet is "ON".
Do not charge the battery longer than 30 hours. If you
suspect that your battery is damaged as a result of
overcharging, contact your local Power Wheels
service center. They can test your battery for you.
Even with proper care, a rechargeable battery does not
last forever. Average battery life is 1 to 3 years depending
on vehicle use and use conditions. Do not substitute parts.
The built-in thermal fuse may "trip" and shut down operation
of the vehicle if the vehicle is overloaded or the driving con-
ditions too severe. The fuse will automatically reset itself
after approximately 25 seconds allowing the vehicle to
resume normal operation. To avoid repeated automatic shut
downs, do not overload the vehicle by exceeding the 65 lb.
maximum weight capacity or by towing anything behind the
vehicle. Do not drive up hills or run into fixed objects, which
can cause the wheels to stop spinning while power is still being
supplied to the motors. If the thermal fuse continually trips,
contact your local Power Wheels
®
authorized service center.
®
authorized
Advertisement
Table of Contents
