teel 4RH36 Operating Instructions & Parts Manual

Operating Instructions & Parts Manual
Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described.
Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or
property damage! Retain instructions for future reference.
®
Teel Self-priming
Pool/Spa Pump
Description
Teel all bronze, self priming pool/spa pumps, Model Numbers 4RH36, 4RH37,
4RH38, 4RH39, and 4RH40, with 5" integral trap, are for use with residential and
commercial swimming pools and spas. Maximum suction lift 10'. Models 4RH37,
4RH39, 4RH40 (3/4, 1, 1 ⁄ , HP) are equipped with 115/230V capacitor start dual
1
2
voltage motors. Models 4RH38 and 4RH36 (2, and 2
single voltage, capacitor start/capacitor run motors. These models deliver up to 100'
of head with capacities to 110 GPM. Motor coupled to impeller via adjustable stub
shaft.
Unpacking and Inspection
Handle with care. Check items received
against packing list to be sure that all
equipment has been received. Inspect
for shipping damage. If found, file
claim with carrier immediately.
Specifications
Motor
Model HP Volts/Hz/Ph
4RH37 3/4 115/230/60/1
4RH39 1 115/230/60/1
4RH40 1 1 ⁄ 115/230/60/1
2
4RH38 2 230/60/1
4RH36 2 1 ⁄ 230/60/1
2
Performance Chart
Model
Number HP
4RH37 3/4
4RH39 1
4RH40 1 1 ⁄
2
4RH38 2
4RH36 2 ⁄
1
2
*Operating pump at or below this flow rate is not recommended and can cause motor to overheat.
Form 5S4185
1 ⁄ HP) are equipped with 230V,
2
IMPORTANT
SAFETY
INSTRUCTIONS
Always follow basic safety
precautions with this equipment,
including the following:
permit children to use this product
unless they are closely supervised at all
times.
NPT
Suc. Dis.
Inlet Out H
1 ⁄ " 1 ⁄ " 11
1 1
2 2
1 1 ⁄ 1 1 ⁄ 11
2 2
1 1 ⁄ 1 1 ⁄ 11
2 2
1 ⁄ 1 ⁄ 11
1 1
2 2
1 1 ⁄ 1 1 ⁄ 11
2 2
Gallons Per Minute at Total Feet of Head
20' 30' 40'
64 54 43
66 58 49
80 71 62
* 88 78
* 103 92
Printed in U.S.A.
09319
0501/091/VCPVP
4RH36, 4RH37, 4RH38, 4RH39, and 4RH40
To reduce the risk
of injury, do not
Dimensions
W L Wt
⁄ " 9 ⁄ " 21 ⁄ " 46 lbs.
3 3 7
8 4 1 6
3 ⁄ 9 3 ⁄ 21 13 ⁄ 51
8 4 1 6
3 ⁄ 9 3 ⁄ 22 15 ⁄ 57
8 4 1 6
⁄ 9 ⁄ 22 ⁄ 57
3 3 9
8 4 1 6
3 ⁄ 9 3 ⁄ 23 1 ⁄ 67
8 4 2
50' 60'
31 18
40 29
52 42
69 58
81 70
This pump is for
use with
permanently installed pools and may
also be used with hot tubs and spas if so
marked. Do not use with storable pools.
A permanently installed pool is
constructed in or on the ground or in a
building such that it cannot be readily
disassembled for storage. A storable
pool is constructed so that it may be
readily disassembled for storage and
reassembled to its original integrity.
SAVE THESE
INSTRUCTIONS
READ AND
FOLLOW SAFETY
INSTRUCTIONS!
This is the safety alert symbol.
When you see this symbol on your
system or in this manual, look for one of
the following signal words and be alert
to the potential for personal injury.
Warns about
hazards that will
cause death, serious personal injury, or
major property damage if ignored.
Warns about
hazards that can
cause death, serious personal
injury, or major property damage if
ignored.
70' 80'
– –
16 –
30 12
47 33
56 40
E
N
G
L
I
S
H
E
S
P
A
Ñ
O
L
F
R
A
N
Ç
A
I
90'
S
–
–
–
–
17
®