Relcross Door Controls 9130 Series Installation Instructions Manual
Low energy swing operator
Hide thumbs
Also See for 9130 Series:
- Installation instructions manual (16 pages) ,
- Installation instructions manual (16 pages)
Subscribe to Our Youtube Channel
Related Manuals for Relcross Door Controls 9130 Series
Summary of Contents for Relcross Door Controls 9130 Series
- Page 1 9130/9140 Series Low Energy Swing Operator UK Installation Instructions rev 11/21 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600...
-
Page 2: Table Of Contents
CONTENTS GENERAL PRE-INSTALLATION & PRODUCT CHECK OPERATOR INSTALLATION WIRING ARM & COVER INSTALLATION OPERATOR ADJUSTMENT FUNCTION TABLES & WIRING DIAGRAMS RELEASE FOR SERVICE 1/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 3: General
(size 3). Door opening and closing cycles, including opening speed, back check speed, hold open time delay, closing speed, and latch position are all adjustable. CAUTION Always disconnect mains power to the operator prior to servicing or cleaning 2/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 4: Pre-Installation & Product Check
2.9 When Pre-Install & Product Check is complete go to: 3 OPERATOR INSTALLATION. Clearances for Pull System Clearances for Push System 3/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 5: Operator Installation
NOTE: For push units with a reveal greater than 152mm you will need to purchase an extended arm Header Frame & Door Preparation: Pull System HIGH VOLTAGE CONDUIT Ø22 4/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 6: Wiring
Do not connect any remote activating device to the door unless it is located within line of sight of the door. When the wiring is complete go to 5 ARM & COVER INSTALLATION. 5/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 7: Arm & Cover Installation
Turn off the power operator switch - the door closes. Remove the jumper from the control box T27, T28. When arm installation is complete go to 6 OPERATOR ADJUSTMENT 6/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... -
Page 8: Operator Adjustment
(P5) where the speed is decreased automatically by the control box allowing the door to close smoothly until fully closed. 6.2.6 If the door does not open at all during learning cycle: Check the door for binding. 7/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600... - Page 9 The door should stop and then slowly drive to the fully opening position The point at which the safety device becomes inactive can be adjusted via P8 from closed position up to back check position 8/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600...
- Page 10 P7 from open position up to a few degrees of closed position NOTE Adjust operator in accordance with EN16005 be it for power assisted low energy power operated doors 9/15 Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600...
-
Page 11: Function Tables & Wiring Diagrams
Then go to 8 RELEASE FOR SERVIVE. 7.1 CONTROL BOX: POTENTIOMETERS & SWITCHES 7.4OTE POWER BOOST ADJ CONT 5 SECS POWER BOOST ACT PUSH & GO MONITORED SAFETY Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 10/15... - Page 12 Fire Alarm Door Open on fire alarm and remain electrically unlocked (if locking present) Key Switch Off BESPOKE SOLUTION - ALLEGION T22, T23 Two Way 9, A-F NOT IN USE Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 11/15...
- Page 13 Activation closed - used for high wind situations Enables power boost to operate Power Boost continuously or for 5 seconds only Continuous 5 Seconds Adjustment after the door closes Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 12/15...
- Page 14 7.4 WIRING DIAGRAM INCLUDING TERMINALS Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 13/15...
- Page 15 7.5 TERMINALS (CLOSE UP) Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 14/15...
-
Page 16: Release For Service
Instruct the owner or people in charge who and where to call for service and maintenance when required. IMPORT IMPORTANT Make sure to install all safety, traffic control and instruction decals on the door as required Relcross Door Controls | E: sales@relcross.co.uk | T: 44(0)1380 729600 15/15...
Need help?
Do you have a question about the 9130 Series and is the answer not in the manual?
Questions and answers