Summary of Contents for Arrow eSTOP Auto
- Page 1 Operations & Service Manual eSTOP™ Auto Operation & Service Manual Version: 1.1 NZ Dated: 20-04-20 Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 1...
- Page 2 Manufactured by: ARROW EMERGENCY SYSTEMS (ArrowES) 17 Bailey Court Brendale, Queensland 4500 PH: (07) 3881 3302 FAX: (07) 3881 3324 Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 2...
-
Page 3: Table Of Contents
Troubleshooting .............................. 25 Repairs & Servicing ............................26 Safe Transportation of the eSTOP™ ......................... 26 Material Life ..............................26 Warranty ................................26 Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 3... -
Page 4: Estop™ System Components Diagram
Battery secure latch (both sides) Battery pack holder Locking screw Centre column Adjustable locking column Locking pin Figure 1 Legs Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 4... - Page 5 8. 2 battery charger and power socket 9. Carry case User and Service & Operation Manuals 11. 2 target boards (Applicable model only) Carry Case Antenna Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 5...
-
Page 6: Safety Considerations
Any modifications made to the eSTOP™ (unless by or approved by ArrowES) could compromise the function of the eSTOP™ and therefore the safe application of the units and voids the warranty of the eSTOP™. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au... -
Page 7: Estop™ System Specifications
1710 mm x 480mm x 370mm Base width, fully extended: 1600 mm diameter Lantern height: 770 mm Lantern width: 270 mm Lantern depth: 170 mm Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 7... -
Page 8: Labels
Hand Remote Control mimics traffic lantern states in real time • Wind load up to 100km/hr when used as per manufacturer’s guidance Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 8... -
Page 9: Unit Assembly/On-Site Setup
IMPORTANT: ensure eSTOP™ is stable and is weighted down with sandbags prior to operation. One sand bag per tripod leg is required. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 9... -
Page 10: Target Board Assembly
Operations & Service Manual Target Board Assembly Target only applies to applicable systems with Target board brackets. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 10... -
Page 11: Operational Procedures
The lanterns must be in line of sight of the HRC at all time. The HRC is the master, all Lanterns communicates directly to the HRC only. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au... -
Page 12: Hand Remote Controller X - Hrc X
Long press- A Long press of the buttons (more than 5s), applies to the Power Button for powering of and powering off. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 12... -
Page 13: Operational Steps
After 10 seconds the system with the paired lanterns is in Manual Mode. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 13... - Page 14 HRC, pressing “Power” and “Wake” button at the same time forces the HRC to soft reset then powers off. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au...
-
Page 15: Pairing The Estop™ Handheld Remote Controller (Hrc X) To Lantern Units
Pairing the eSTOP™ Handheld Remote Controller (HRC X) to lantern units The eSTOP™ HRC can be paired to any eSTOP Auto lantern units. Once a lantern unit is paired to a HRC it is stored in memory, they will be automatically synced when powered up and ready for operation. - Page 16 3. Once a button is paired to a lantern, the Status on the Home screen will go from blank status information to some information: Note to allow upto 60 seconds for the paired lanterns to establish communication. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 16...
-
Page 17: Estop Auto
Green state. Note the lantern does not changes to Green state after the Countdown ends unless there is a command from the HRC to go Green. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au... -
Page 18: Gui Screens
If the HRC is in critical low battery, a “Low Battery Charge Device” warning message is shown in orange color. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 18... -
Page 19: User Manual - Estop Dvr Camera System
A Green light under SD status indicates the DVR is recording. Stop recording Recording can be stopped by switching off the power or switching the recording off Enable SW as Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 19... - Page 20 While the LCD is plugged in, a USB mouse can also be plugged in to the USB port shown in figure 1. This allows Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au...
- Page 21 The files can be backed up using the BackupFile or BackupByTime buttons on the bottom menu bar. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 21...
- Page 22 Right click on the line to set starting and end point of the clip. Then right click in between the 2 points to back up the clip as AVI format. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au...
-
Page 23: Batteries - Care, Safe Handling And Charging
Once powered on the battery status is shown on the top of the screen. The battery status is shown in percentage. (Note: the battery status screen is only active when the HRC is switched off) Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 23... - Page 24 These lithium batteries should be recycled. Look for companies who will buy them or your local battery recycling centre for disposal options. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 24...
-
Page 25: Maintenance Of The Estop
Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 25... -
Page 26: Repairs & Servicing
Dulux X15 orange is used, this meets with requirements of AS2700. Warranty The eSTOP™ is supplied with a limited ex factory warranty for 12 months. Arrow Emergency Systems | 17 Bailey Court Brendale Q 4500 | P: (07) 3881 3302 | www.arrowes.com.au Page | 26...
Need help?
Do you have a question about the eSTOP Auto and is the answer not in the manual?
Questions and answers