Related Manuals for FOAM-iT FI-30N
Summary of Contents for FOAM-iT FI-30N
- Page 1 USER MANUAL MODEL NUMBER: FI-30N FI-30NK FI-30NV FI-30N-ST FI-30NK-ST FI-30NV-ST AND RELATED UNITS 30 Gallon Air Operated Portable Foam Equipment English (Original Instructions)
-
Page 2: Specifications
P56V: Polypropylene body with Viton diaphragm • Only use clean and dry air. Air must be filtered and free P56K: Polypropylene body with Kalrez diaphragm of moisture or pump life will be diminished. If needed, install an air dryer before unit. • Do not use air lubricator before the unit. Acceptable Products: Alkaline cleaners, Caustic cleaners, Sanitizers, and Acids * D-Limonene may only be used with Kalrez pump * Chlorine may only be used with Viton or Kalrez pump DO NOT USE: All hydrocarbons PROTECT THE ENVIRONMENT Please dispose of packaging materials, old machine components, and hazardous fluids in an environmentally safe way according to local waste disposal regulations. Always remember to recycle. *Specifications and parts are subject to change without notice. Model No.: FI-30N, FI-30NK, FI-30NV, FI-30N-ST, FI-30NK-ST, FI-30NV-ST Page 2 of 6 | 10212015... -
Page 3: After Use Instructions
• Drain compressor tank on a regular basis to ensure proper to use a pipe thread sealant when reinstalling operation of pump. the stainless adaptor back into the tee fitting Troubleshooting Instructions: (SST12HB38). If the mixing mesh has a lot of foreign particles in it, make sure the strainer • Check to ensure the discharge hose is uncoiled properly, (STR38-IL) is still in place. and that there are no kinks that could obstruct fluid flow. • Check for plugged strainer (STR38-IL). Replace strainer if • Check air regulator bowl (ABR25) for debris such as necessary. Strainer must be used. water, oil, or rust particles. Clean by unthreading the air regulator bowl from the air regulator (R25). • If needle valve (NV14Y) valve is open too far, the pump (P56/P56K/P56V) will cycle improperly due to lack of air pressure. If this occurs, reset needle valve as described in Operation Instruction #4. • Make sure proper foaming chemical and concentration is being used. Model No.: FI-30N, FI-30NK, FI-30NV, FI-30N-ST, FI-30NK-ST, FI-30NV-ST Page 3 of 6 | 10212015... - Page 4 ITEM NUMBER: PWA34-ST ITEM NUMBER: SSWA38-HA30 ZERO TIP FOAM WAND ASSEMBLY 30 ft (9 m) HOSE ASSEMBLY ITEM NUMBER: SSWA38 ITEM NUMBER: H34-30 HBSS1234 HV60 SN1212 PW10 ST80200 H34B-H (Available per ft.) ANTI-KINK SPRING ASSEMBLY ITEM NUMBER: AKSS34 HBSS1234 AKSS34 HBSS1234 HV60 HHSB1238 W387 SSC34 Model No.: FI-30N, FI-30NK, FI-30NV, FI-30N-ST, FI-30NK-ST, FI-30NV-ST Page 4 of 6 | 10212015...
-
Page 5: Optional Components
HBSSEL1814 HBSS1438 SSC38 HHPB3414 SST12HB38 SSC38 HBSSEL1438 EC14-2 SSC38 CV38 PVCV34FM Plate - Back View OPTIONAL COMPONENTS NV14Y SSA14 WATER SEPARATOR 30 ft (9 m) AIR HOSE ASSEMBLY AP25 ITEM NUMBER: WS-20CFM ITEM NUMBER: AH30 FWP12 HBSS1234 Model No.: FI-30N, FI-30NK, FI-30NV, FI-30N-ST, FI-30NK-ST, FI-30NV-ST Page 5 of 6 | 10212015... - Page 6 TANK-30N ROTO MOLDED 30 GALLON UNIT W/ HANDLE H38B-H 3/8 INCH BLUE HOSE - Available per ft. TANK-30N-HNDL REPLACEMENT HANDLE FOR TANK-30N HBBF1438 BRASS 1/4in FPT X 3/8in HOSE BARB TW916 1/2 INT TOOTH L/W 410SS HBSS1234 STAINLESS HOSE BARB 1/2 X 3/4 NONMARKING WHEEL FOR PORTABLE UNITS HBSS1438 STAINLESS HOSE BARB 1/4 MPT X 3/8 BARB W387 S.S. 304 SPRAY WAND 3/8in MPT X 7in LONG - THREAD ON ONE END HBSSEL1438 STAINLESS HOSE BARB ELBOW 1/4 INCH NPT X 3/8 HOSE BARB HBSSEL1814 304 STAINLESS ELBOW 1/8 INCH NPT X 1/4 INCH HOSE BARB HHPB3414 HEX HEAD POLY REDUCER BUSHING 3/4 X 1/4 Model No.: FI-30N, FI-30NK, FI-30NV, FI-30N-ST, FI-30NK-ST, FI-30NV-ST Page 6 of 6 | 10212015...