Snorkel 000003 Series Repair Parts Manual

page of 310

/ 310
Contents
Table of Contents
Bookmarks

Table of Contents

Quick Links

660SJ OSCILLATING AXLE

PARTS MANUAL S/N 000003

THROUGH 000017

660SJ-11-000003 - 660SJ-11-000017

Table of Contents

Need help?

Do you have a question about the 000003 Series and is the answer not in the manual?

Questions and answers

Summary of Contents for Snorkel 000003 Series

Page 1 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 660SJ-11-000003 - 660SJ-11-000017...
Page 2 REPAIR PARTS MANUAL Part Number 1432068 February 2017 Serial numbers 000003 through 000017...
Page 3 QUADRANT ASSEMBLY 2-29 PLATFORM MOUNT ASSEMBLY 2-30 PLATFORM, JIB TO BOOM ASSEMBLY 2-31 PLATFORM ROUND TUBE ASSEMBLY COMPONENTS 2-32 SNORKEL GUARD ASSEMBLY 2-33 CARRIER TRACK INSTALL 2-34 HOSE CARRIER TUBE GUIDE ASSEMBLY 2-35 CARRIER TRACK PRE ASSEMBLY 2-36 COWLING INSTALL KUBOTA...
Page 4 DOOR RIGHT HAND FRONT ASSEMBLY 2-42 DECALS KIT 2-43 HYDRAULICS HYDRAULIC HOSE DIAGRAM 660SJ OSC AXLE LOCK CYLINDER HENGLI AXLE LOCK CYL TRACTION MANIFOLD ASSEMBLY MANIFOLD TRACTION OMNI POWER WHEEL ASSEMBLY HYDRAULIC MOTOR REAR ASSEMBLY DRIVE MOTOR HYD 38cc CYLINDER, STEER HYDRATECH SWING DRIVE GEARBOX 3-10 7 PORT ROTARY MANIFOLD ASSEMBLY...
Page 5: Table Of Contents
CABLE HARNESS KIT KUBOTA 4-12 HARNESS, LOWER CONTROL TO PRESSURE SWITCH 4-13 LOWER CABLE ASSEMBLY 4-14 SELECTOR VALVE HARNESS 4-15 FOOT SWITCH HARNESS 4-16 BEACON LIGHT HARNESS 4-17 LOWER CONTROL TO LIMIT SWITCH HARNESS 4-18 LOWER CONTROL BOX TO AMBER LIGHT HARNESS 4-19 ELEVATION SWITCH TO DT06-4S HARNESS 4-20...
Page 6 The aerial platform is not electrically insulated. Death or serious injury will result from contact with, or inadequate clearance from, an energized conductor. Do not go closer than the Minimum Safe Approach Distance as defined by ANSI standards. Regard all conductors as energized. Allow for electrical wire sag and aerial platform sway.
Page 7 While Snorkel has attempted in every way to confirm that Underwriters Laboratories Inc. all information in this manual is correct, improvements are being constantly made to the machine that may not Additional Information be reflected in this manual.
Page 8 Component Identification Tip Boom Battery Main Boom Engine Battery Disconnect Intermediate Boom Upper Controls Platform Identification Placard On Inside Front of Platform Serial Number • Model Number Pivoting Front Axle Chassis Tie-Down Lugs Steer Wheels Side of Chassis Rear Front Right Side Hydraulic Fluid Tank Hydraulic Fluid Filter...
Page 9 Service and Parts Information Ordering Parts Manuals When placing an order for service or repair parts, Manuals are available from Snorkel to support any of please have the following machine information readily the machines that we produce. available. The specific manuals for 660SJ aerial platforms are as...
Page 11 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CHASSIS ASSEMBLY OSC REPAIR PARTS CHASSIS ASSEMBLY OSC Tue Mar 23 01:25:44 UTC 2021...
Page 12 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CHASSIS ASSEMBLY OSC CHASSIS ASSEMBLY OSC Tue Mar 23 01:25:45 UTC 2021...
Page 13 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CHASSIS ASSEMBLY OSC アイテム部品番号名前数量 1431735 D CHASSIS ASSEMBLY Shown SEE CHART JIB BOOM ASSEMBLY SEE CHART JIB BOOM ASSEMBLY SEE CHART JIB BOOM ASSEMBLY SEE CHART JIB BOOM ASSEMBLY 1432114 OSCILLATING AXLE WELDMENT 1431685 MOUNT, TRACTION MANIFOLD 1431687 CS 3/16 GR50 106717-001 WHEEL & TIRE ASSEMBLY RH foam FILLED ‒ ansi OPTION/CE STANDARD 106718-001 WHEEL & TIRE ASSEMBLY LH FOAM FILLED ‒ ansi OPTION/CE STANDARD 1432102 ASSEMBLY, HYDRAULIC MOTOR...
Page 14 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CHASSIS ASSEMBLY OSC アイテム部品番号名前数量 011239-010 WASHER, FLAT ASTM A325 5/8" 20 511581-000 HYDRAULIC MOTOR ASSEMBLY FOR REAR 0260070 O-Ring 0260099 O-Ring 5563116 Bolt, HDD 116324-000 Wheel Gearbox 511621-000 ASSEMBLY, TRACTIION MANIFOLD 5563544 WSHR, FLAT M12 YL ZN GR 10.9 4 1431686 WEIGHT, SIDE CAST 1430627 WEIGHT, INSIDE, LG 1431079 WEIGHT, CHASSIS NOSE 5563510...
Page 15 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CHASSIS ASSEMBLY OSC アイテム部品番号名前数量 1430920 3IN PIN SECUREMENT TAB 1430921 CSB-50 48IB32 1431819 SPACER, OSC AXLE 1430923 OSC AXLE PIN BUSHING RETAINER 510684-050 HHCS M20 X 2.5 X 50 GR 8.8 DIN 931 6047163 660 SJ OSC AXLE LOCK CYL 1431010 OSC LOCK CYL PIN RETAINER 1431009 OSC LOCK CYL PIN - TAPERED 1432020 ASSEMBLY, HYDRAULIC MOTOR TO KNUCKLE RH 5563504 HHCS, M10X1.5 X50 YL ZN GR10.9 CHASSIS ASSEMBLY OSC Tue Mar 23 01:25:45 UTC 2021...
Page 16 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY REPAIR PARTS OMNI POWER WHEEL ASSEMBLY Tue Mar 23 01:25:45 UTC 2021...
Page 17 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY アイテム部品番号名前数量 116324-000 Wheel Gearbox 8010399 HOUSING VB07 H1 8010401 CAP LOCKOUT VB07 8010400 CAP END VB07 8010412 SEAL OIL; 0637-60008 8010412 SEAL OIL; 0637-60008 056066-014 NUT NYLOCK DIN985 M14 8.0 ZINC PLTD 058490-006 HEXSETSCREW 8010406 SPINDLE VB07 8010409 BEARING CONE 32928 8010408 BEARING CUP 32928 056058-012 BLT HEXBOLT 6MM X 12MM DIN931 GR8.8 ZP...
Page 18 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY アイテム部品番号名前数量 8010419 ROLL PIN HD; 4MM X19 8010405 GEAR SUN VB07 25T LS 8010429 SNAP RING; GB#40 8010403 INPUT SHAFT VB07 13T 8010422 CARRIER ASSY; VB07 PRI 10.15 8010428 BRAKE ASSY; VB07 8010440 BRAKE ROTOR; VB07 8010436 PLATE SPRING RETAINING VB07 8010430 SNAP RING; GB#105; INTERNAL 8010441 HYDRAULIC PISTON; VB07 8010438 BACKUP RING; VB07 8010437 BACKUP RING; VB07 8010415 SEAL O-RING -154...
Page 19 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR TO KNUCKLE RIGHT HAND ASSEMBLY REPAIR PARTS HYDRAULIC MOTOR TO KNUCKLE RIGHT HAND ASSEMBLY Tue Mar 23 01:25:46 UTC 2021...
Page 20 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR TO KNUCKLE RIGHT HAND ASSEMBLY アイテム部品番号名前数量 1432020 A HYDRAULIC MOTOR TO Shown KNUCKLE RIGHT HAND ASSEMBLY 1431489 WELDMENT, STEER KNUCKLE 062642-024 BRG 1.25 ID X 1.41 OD X 0.75 L 116324-000 Wheel Gearbox 0260070 O-Ring 0260099 O-Ring 104665-000 DRIVE MOTOR HYD 38cc/9.22cc 1 986179 WSHR 7/16 FLAT 5563116 Bolt, HDD 100434-013...
Page 21 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY REPAIR PARTS HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY Tue Mar 23 01:25:46 UTC 2021...
Page 22 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY アイテム部品番号名前数量 1432102 B HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY 1431489 WELDMENT, STEER KNUCKLE 062642-024 BRG 1.25 ID X 1.41 OD X 0.75 L 116324-000 Wheel Gearbox 116324-011 BRAKE 0260070 O-Ring 0260099 O-Ring 104665-000 DRIVE MOTOR HYD 38cc/9.22cc 1 106964-001 SWIVEL FITTING, 12MB X 12FB 2509809 70 OD X 65 ID X 40MM LONG...
Page 23 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY アイテム部品番号名前数量 100434-013 Hyd Fitting - 90 Elbow ORFS(08) - SAE(08) HYDRAULIC MOTOR TO KNUCKLE LEFT HAND ASSEMBLY Tue Mar 23 01:25:46 UTC 2021...
Page 24 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 STEER LINK ASSEMBLY REPAIR PARTS STEER LINK ASSEMBLY Tue Mar 23 01:25:47 UTC 2021...
Page 25 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 STEER LINK ASSEMBLY アイテム部品番号名前数量 1431299 B STEER LINK ASSEMBLY Shown 1431303 WLDMNT, STEER LINK 062642-024 BRG 1.25 ID X 1.41 OD X 0.75 L STEER LINK ASSEMBLY Tue Mar 23 01:25:47 UTC 2021...
Page 26 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 WHEEL AND TIRE ASSEMBLY REPAIR PARTS WHEEL AND TIRE ASSEMBLY Tue Mar 23 01:25:47 UTC 2021...
Page 27 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 WHEEL AND TIRE ASSEMBLY アイテム部品番号名前数量 106717-001 A WHEEL AND TIRE ASSEMBLY 0260880 TIRE FOAM FILLED RH 0260881 TIRE FOAM FILLED LH 106717-003 decal, danger wheel position -CE ONLY WHEEL AND TIRE ASSEMBLY Tue Mar 23 01:25:47 UTC 2021...
Page 28 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET TO CHASSIS SUB ASSEMBLY REPAIR PARTS TURRET TO CHASSIS SUB ASSEMBLY Tue Mar 23 01:25:48 UTC 2021...
Page 29 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET TO CHASSIS SUB ASSEMBLY TURRET TO CHASSIS SUB ASSEMBLY Tue Mar 23 01:25:49 UTC 2021...
Page 30 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET TO CHASSIS SUB ASSEMBLY アイテム部品番号名前数量 1431167 A TURRET TO CHASSIS SUB- Shown ASSEMBLY 511620-000 7 PORT ROTARY MANIFLD ASSY 5563452 FHCS 3/4-10 x 2.75 GR9 12PT 5563777 WASHER FLAT, .75 1.25OD X .812ID 5563593 BOLT HXHD 1/2-13X2-1/2YLZN 5563625 WASHER, FLAT 1/2" YL ZN GR8 511302-000 65 ID X 75 OD X 50 MM LONG BEARING 2504856 Bearing 2504857 BEARING 2509849 BUSHING 40X50X6 104662-000...
Page 31 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET TO CHASSIS SUB ASSEMBLY アイテム部品番号名前数量 5563543 WSHR, FLAT M10 YL ZN GR 10.9 4 6020058 EMERGENCY PWR UNIT TB/ATB 100434-008 6MB X 6M ORFF 90° FITTING 100434-013 Hyd Fitting - 90 Elbow ORFS(08) - SAE(08) 511325-000 E-PUMP RELAY BRKT 3040506 SOLENOID 12V 150 010149-000 FUSE BLOCK 010148-001 FUSE - BUSS 5563482 BOLT HXHD M6X1X16 YL ZN GR10.9 5563541 WASHER, FLAT, M6, STEEL, C10.9, YELLOW ZINC 5563554...
Page 32 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COUNTERWEIGHT TO TURRET ASSEMBLY REPAIR PARTS COUNTERWEIGHT TO TURRET ASSEMBLY Tue Mar 23 01:25:49 UTC 2021...
Page 33 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COUNTERWEIGHT TO TURRET ASSEMBLY アイテム部品番号名前数量 1432129 A COUNTERWEIGHT TO TURRET Shown ASSEMBLY SEE CHART JIB BOOM ASSEMBLY 1430798 600S & 660SJ COUNTER WEIGHT 1431844 SHIM-.125" THK, 1.25" HOLE Shown 5563533 BOLT, HXHD M24X3X60YLZN GR10.9 5563549 WASHER, FLAT M24 YL ZN GR 10.9 COUNTERWEIGHT TO TURRET ASSEMBLY Tue Mar 23 01:25:49 UTC 2021...
Page 34 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET COMPONENTS ASSEMBLY REPAIR PARTS TURRET COMPONENTS ASSEMBLY Tue Mar 23 01:25:50 UTC 2021...
Page 35 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET COMPONENTS ASSEMBLY TURRET COMPONENTS ASSEMBLY Tue Mar 23 01:25:50 UTC 2021...
Page 36 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET COMPONENTS ASSEMBLY アイテム部品番号名前数量 1432311 B TURRET COMPONENTS ASSEMBLY 1432310 SEE CHART 1431368 TRAY BATTERY 1431843 BRACKET-BATTERY 104848-000 12V BATTERY 800CCA 1431833 Bracket - Pressure Filter 1432076 MAIN MANIFOLD ASSY OSC 5563543 WSHR, FLAT M10 YL ZN GR 10.9 14 058508-025 HHCS M10 X 25MM GR10.9 DIN933 1431374 ENGINE SWING OUT ASSEMBLY 104640-000 UHMW THRUST WASHER 104713-000 TRAY PIN WELDMENT...
Page 37 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TURRET COMPONENTS ASSEMBLY アイテム部品番号名前数量 1430895 CS 1/2 GR50 CW ANGLE BRKT 5563533 BOLT, HXHD M24X3X60YLZN Shown GR10.9 5563549 WASHER, FLAT M24 YL ZN GR 10.9 5563563 NUT, HEX M24X3 YL ZN PLT GR10.9 1430731 HYDRAULIC TANK MODULE ASSEMBLY 5516361 Pull Action Clamp w/Toggle Loc 1432101 ASSY, HP FILTER 5563709 SCRW M24-3.0.x80 10.9 HCSYZ 5563535 BOLT, HX HD M24X3X70 YL ZN Shown GR10.9 TURRET COMPONENTS ASSEMBLY Tue Mar 23 01:25:50 UTC 2021...
Page 38 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK ASSEMBLY REPAIR PARTS HYDRAULIC TANK ASSEMBLY Tue Mar 23 01:25:51 UTC 2021 2-10...
Page 39 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK ASSEMBLY アイテム部品番号名前数量 1430748 B HYDRAULIC TANK ASSEMBLY Shown 1430744 HYDRAULIC TANK 6019326 RETURN FILTER MP 100432-029 FTG, STR, 12MORFF X 16MORB 100432-027 Hyd Fitting - Straight ORFS(12) - SAE(12) 100432-015 FTG, STR, 8MORFF X 8MORB 058504-030 Bolt, SktCapScrew DIN912 M10 x 4 104764-000 6 MORFF X 6MB X 6 MORFF RUN TEE 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 6091942 CAP, HYD TANK 660SJ 6091943 SIGHT GAGE, HYD TANK 660SJ...
Page 40 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOM TO TURRET SUB ASSEMBLY REPAIR PARTS BOOM TO TURRET SUB ASSEMBLY Tue Mar 23 01:25:52 UTC 2021 2-11...
Page 41 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOM TO TURRET SUB ASSEMBLY BOOM TO TURRET SUB ASSEMBLY Tue Mar 23 01:25:52 UTC 2021 2-11...
Page 42 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOM TO TURRET SUB ASSEMBLY アイテム部品番号名前数量 1432310 A BOOM TO TURRET SUB- Shown ASSEMBLY 511541-500 BASE BOOM WELDMENT 2504857 BEARING 1431003 PLATE, RETAINER PIN 100553 CYLINDER, MASTER 2509848 BUSHING, LIFT CYLINDER LOWER 1431509 MASTER CYLINDER BASE FLT 100434-008 6MB X 6M ORFF 90° FITTING 1431510 LIFT CYLINDER END PLATE 1431002 PIN MAIN BOOM 1431554 PIN, BOOM LIFT CYL END...
Page 43 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK MODULE ASSEMBLY REPAIR PARTS HYDRAULIC TANK MODULE ASSEMBLY Tue Mar 23 01:25:53 UTC 2021 2-12...
Page 44 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK MODULE ASSEMBLY HYDRAULIC TANK MODULE ASSEMBLY Tue Mar 23 01:25:53 UTC 2021 2-12...
Page 45 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK MODULE ASSEMBLY アイテム部品番号名前数量 1430731 C HYDRAULIC TANK MODULE Shown ASSEMBLY 106776-000 MODULE SUPPORT WELDMENT SHORT 056064-010 Nut NylockNut DIN985 M10 10.0 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 5569917 BLT HEX HD M10 90MM GR 8.8 056060-090 BLT HEXHD M10 X 90MM DIN 931 8.8 ZP 1430743 FUEL TANK, LOW FILL 1430748 HYDRAULIC TANK ASSEMBLY 1430713 HYD MODULE BASE WLDMT 1430766 MODULE SUPPORT WLDMT...
Page 46 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC TANK MODULE ASSEMBLY アイテム部品番号名前数量 1430896 LOWER CONTROL BRKT LEFT 1430897 LOWER CONTROL BRKT RIGHT 1431145 LATCH WLDMT 1431148 LATCH WLDMT 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 058493-020 BOLT HEXSETSCREW DIN933 M10 X 20MM 8.8 ZP 5560080 BUMPER ADHESIVE BACK 0084570 Filler Cap 0070483 Fuel Gauge, 375mm (14.75") HYDRAULIC TANK MODULE ASSEMBLY Tue Mar 23 01:25:53 UTC 2021 2-12...
Page 47 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 RADIATOR SHROUD ASSEMBLY REPAIR PARTS RADIATOR SHROUD ASSEMBLY Tue Mar 23 01:25:53 UTC 2021 2-13...
Page 48 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 RADIATOR SHROUD ASSEMBLY アイテム部品番号名前数量 1431403 B RADIATOR SHROUD ASSEMBLY Shown 1431404 SHROUD, RADIATOR 1431990 SHROUD RAD 1431991 SHROUD RAD, RH 1431992 SHROUD RAD, TOP 1431993 SHROUD RAD, BOTTOM 056069-008 WASHER, STEELFLATWASHER DIN12M8 FLAT WASHER DIN 056064-008 NUT HEX M8-1.25 GR10.9 SELF LOCKING DIN 985 510681-020 HHCS M8X1.25X20 G10.9 ISO 4014 DIN 933 9920035 TRIMSEAL X3/16G TRIM LOK RADIATOR SHROUD ASSEMBLY Tue Mar 23 01:25:53 UTC 2021 2-13...
Page 49 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ENGINE SWING OUT ASSEMBLY REPAIR PARTS ENGINE SWING OUT ASSEMBLY Tue Mar 23 01:25:54 UTC 2021 2-14...
Page 50 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ENGINE SWING OUT ASSEMBLY アイテム部品番号名前数量 1431374 A ENGINE SWING OUT ASSEMBLY Shown 1430726 ENGINE ASSY KUBOTA DIESEL 660SJ 100209-000 ISOLATOR - ENGINE 1432155 ASSY BAT CNTL PNL KU 1431885 RUBBER STOP FOR OVERFLOW 1431479 WELDMENT, ENG TRAY KU V2403 5563500 BOLT HXHD M10X1.5X30 YZ GR10.9 5563543 WSHR, FLAT M10 YL ZN GR 10.9 25 5563556 NUT HEX M10X1.5 YL ZN GR10.9 5563740 BOLT HX HD M10X1.5X75 ZN...
Page 51 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA V2403 TURBO DIESEL ENGINE REPAIR PARTS KUBOTA V2403 TURBO DIESEL ENGINE Tue Mar 23 01:25:55 UTC 2021 2-15...
Page 52 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA V2403 TURBO DIESEL ENGINE アイテム部品番号名前数量 104673-000 A KUBOTA V2403 TURBO DIESEL Shown ENGINE 7630948 OIL DRAIN PLUG 104673-100 OIL DRAIN PLUG GASKET 104763-101 UPPER GASKET KIT 104673-102 LOWER GASKET KIT 104673-103 MUFFLER GASKET 104673-104 INTAKE MANIFOLD GASKET 104673-105 FAN BELT 104673-106 THERMOSTAT 260466 THERMOSTAT HSG. GASKET 067614-023 OIL PRESSURE SWITCH 104673-107...
Page 53 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL REPAIR PARTS KUBOTA ENGINE ASSEMBLY DIESEL Tue Mar 23 01:25:55 UTC 2021 2-16...
Page 54 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL KUBOTA ENGINE ASSEMBLY DIESEL Tue Mar 23 01:25:56 UTC 2021 2-16...
Page 55 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL KUBOTA ENGINE ASSEMBLY DIESEL Tue Mar 23 01:25:56 UTC 2021 2-16...
Page 56 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL アイテム部品番号名前数量 1430726 E KUBOTA ENGINE ASSEMBLY Shown DIESEL 660SJ 104673-000 KUBOTA ENGINE V2403-M-T- E3B-KEA2 REPLACEMENT PARTS 104711-000 ENGINE MOUNT FRONT 104701-000 RADIATOR KIT 104712-000 ENGINE MOUNT REAR 1430841 MUFFLER, END INLET, END OUTLET OFFSET 2'' 104735-400 EXHAUST OUTLET AT TURBO 100180-041 CLAMP, MUFFLER #P00235 1 7630755 AIR CLEANER CUMMINS 3.3 KUBOTA WG2403 TIER 3 AND TIER 4 ASSEMBLY 013259-008 MUFFLER CLAMP 2"...
Page 57 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL アイテム部品番号名前数量 104703-000 HOUSING ADAPTER KIT AB62 POLARIS HAYES 1431577 ADPTR, TUBE INTK V2403 1431574 TUBE, INTK TOP V2403 1431575 TUBE, INTK BTM V2403 1431576 TUBE, INTK TO FLTR V2403 25743-000 OVERFLOW RESERVOIR 1431886 RUBBER STOP FOR ENGINE TRAY 5563589 BOLT HXHD 1/2-13X1-1/4YLZN 5563625 WASHER, FLAT 1/2" YL ZN GR8 5563490 BOLT HXHD M8X1.25X20 YZ GR10.9 5563542 WSHR, FLAT M8 YL ZN GR 10.9 5563555...
Page 58 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA ENGINE ASSEMBLY DIESEL アイテム部品番号名前数量 7119925 O-RING -219 NBR 90 7119926 O-RING, -225 NBR 90 5260037 INLT ADPTR BRB TO SPLT FLNG 5059726 HOSE CLAMP 2" PARKER 88DB- KUBOTA ENGINE ASSEMBLY DIESEL Tue Mar 23 01:25:56 UTC 2021 2-16...
Page 59 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 RADIATOR KIT KUBOTA V2403 REPAIR PARTS RADIATOR KIT KUBOTA V2403 Tue Mar 23 01:25:57 UTC 2021 2-17...
Page 60 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 RADIATOR KIT KUBOTA V2403 アイテム部品番号名前数量 104701-000 A RADIATOR KUBOTA V2403 1431994 RADIATOR CAP 1430538 HOSE, WATER 1430539 HOSE, WATER 1430541 CUSHION 1430542 CUSHION 1430543 CUSHION 1430544 SUPPORT 1, RADIATOR 1430545 SUPPORT 2, RADIATOR 1430546 STAY 1430547 STAY 1, RADIATOR 1430548 STAY 2, RADIATOR 1430549 STAY 3, RADIATOR...
Page 61 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AIR CLEANER REPAIR PARTS AIR CLEANER Tue Mar 23 01:25:57 UTC 2021 2-18...
Page 62 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AIR CLEANER アイテム部品番号名前数量 7630755 B AIR CLEANER ASSEMBLY CUMMINS 45 HP CUMMINS 65 HP FORD LRG 425 GM T3 2.4L KUBOTA V1505T TIER 3 V2403 8140014 cap retainer clip 8140013 cover 8050097 PRIMARY ELEMENT 8140011 element 8050098 SAFETY ELEMENT 8050099 EXTERNAL EJECTOR 068903-009 DUST EJECTOR 8050100 METAL BRACKET AIR CLEANER Tue Mar 23 01:25:57 UTC 2021 2-18...
Page 63 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FUEL FILTER & BRACKET DIESEL REPAIR PARTS FUEL FILTER & BRACKET DIESEL Tue Mar 23 01:25:57 UTC 2021 2-19...
Page 64 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FUEL FILTER & BRACKET DIESEL アイテム部品番号名前数量 104743-000 FUEL FILTER & BRKT DIESEL Shown 6091847 COVER 6091848 BOLT, JOINT 6091849 PLUG 5089682 FUEL FILTER FOR V2403T 6091850 GASKET 6091851 CONNECTOR 6091582 GASKET (VO) 6091853 HOLDER, FUEL FILTER 6091854 BOLT JOINT FUEL FILTER & BRACKET DIESEL Tue Mar 23 01:25:57 UTC 2021 2-19...
Page 65 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 THROTTLE BRACKET ASSEMBLY REPAIR PARTS THROTTLE BRACKET ASSEMBLY Tue Mar 23 01:25:58 UTC 2021 2-20...
Page 66 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 THROTTLE BRACKET ASSEMBLY アイテム部品番号名前数量 104618-000 THROTTLE BRACKET ASSY Shown 104737-000 THROTTLE BRACKET 3040174 SOLENOID, THROTTLE 011261-000 JAM NUT .250-28 064423-000 SWIVEL, IN LINE 011760-004 ROD END 510588-006 WSHR FLAT M6 056058-018 BOLT, HEXBOLT DIN 931 M6 X 16MM 8.8 ZP 056064-006 NUT NYLOCK DIN985 M6 10.0 THROTTLE BRACKET ASSEMBLY Tue Mar 23 01:25:58 UTC 2021 2-20...
Page 67 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FLYWHEEL COUPLING ASSEMBLY REPAIR PARTS FLYWHEEL COUPLING ASSEMBLY Tue Mar 23 01:25:58 UTC 2021 2-21...
Page 68 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FLYWHEEL COUPLING ASSEMBLY アイテム部品番号名前数量 104703-000 A FLYWHEEL ASSY Shown 104703-100 FLYWHEEL PLATE 104703-101 COUPLING HUB 104703-102 NEOPRENE INSERT 104703-103 THREADED BUSHING 104703-104 HOUSING FLYWHEEL COUPLING ASSEMBLY Tue Mar 23 01:25:58 UTC 2021 2-21...
Page 69 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN BOOM INSTALL REPAIR PARTS MAIN BOOM INSTALL Tue Mar 23 01:25:58 UTC 2021 2-22...
Page 70 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN BOOM INSTALL アイテム部品番号名前数量 1432246 A MAIN BOOM INSTALLATION Shown 2509848 BUSHING, LIFT CYLINDER LOWER 1431554 PIN, BOOM LIFT CYL END 2509849 BUSHING 40X50X6 1431508 PLATE, FLOATING PIN COVER 058508-025 HHCS M10 X 25MM GR10.9 DIN933 1431555 PIN, MASTER CYLINDER ROD 5563543 WSHR, FLAT M10 YL ZN GR 10.9 24 1431003 PLATE, RETAINER PIN 2504857 BEARING 1431002 PIN MAIN BOOM 1431511...
Page 71 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN BOOM ASSEMBLY REPAIR PARTS MAIN BOOM ASSEMBLY Tue Mar 23 01:25:59 UTC 2021 2-23...
Page 72 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN BOOM ASSEMBLY アイテム部品番号名前数量 1432247 MAIN BOOM ASSEMBLY 1430722 CYLINDER SUPPORT ASSEMBLY 1430721 BOOMS TO TURRET 1430723 TIP BOOM TO INTERMEDIATE BOM ASSEMBLY 511541-500 BASE BOOM WELDMENT MAIN BOOM ASSEMBLY Tue Mar 23 01:25:59 UTC 2021 2-23...
Page 73 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CYLINDER SUPPORT ASSEMBLY REPAIR PARTS CYLINDER SUPPORT ASSEMBLY Tue Mar 23 01:25:59 UTC 2021 2-24...
Page 74 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CYLINDER SUPPORT ASSEMBLY アイテム部品番号名前数量 1430722 A CYLINDER SUPPORT ASSEMBLY Shown 511553-400 WELDMENT CYL SUPPT 511211-400 SLIDE PAD 511219-300 SLIDE PAD, BOTTOM CYLINDER SUPPORT 511303-000 COVER INTERACTIVE LINK SLOT 512727-016 CSK SKT FLT MACH SCREW M10-1.5 X 16 10.9 056060-015 BOLT, HEX BOLT DIN931 M10 X 15MM 8.8 ZINC PLTD 056021-012 Washer, SpringWasher DIN127B 511601-000 TOWER SLIDE WEAR PAD 512727-030 BOLT, CSK SKT FIT MACHINE SCREW DIN7991 M10 X 30MM 10.9 ZINC PLTD 056064-010...
Page 75 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY REPAIR PARTS BOOMS TO TURRET ASSEMBLY Tue Mar 23 01:25:59 UTC 2021 2-25...
Page 76 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY BOOMS TO TURRET ASSEMBLY Tue Mar 23 01:26:00 UTC 2021 2-25...
Page 77 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY BOOMS TO TURRET ASSEMBLY Tue Mar 23 01:26:00 UTC 2021 2-25...
Page 78 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY BOOMS TO TURRET ASSEMBLY Tue Mar 23 01:26:00 UTC 2021 2-25...
Page 79 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY アイテム部品番号名前数量 1430721 A BOOMS TO TURRET ASSEMBLY 511302-000 65 ID X 75 OD X 50 MM LONG BEARING 511335-000 BUSHING 4050DU, 40mm ID 50mm LG DU STYLE 511214-000 PIN, EXTEND CYL @ LINK 514281-020-DR BOLT, HEX SETSCREW, DIN961 M12 x 1.25 x 20mm 10.9 ZINC PLTD 9980012 .040 S. S. SAFETY LOCKWIRE 511628-000 SIDE WEAR PAD 511336-000 EXTERNAL RETAINING RING 40MM 1430732 SUPPORT, ANCHOR 511228-000 WELDMENT ANCHOR WIRE ROPE...
Page 80 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOMS TO TURRET ASSEMBLY アイテム部品番号名前数量 970449 HHD BLT .375-16 X .750 GR5 511632-000 WEAR PAD BASE TOP 1430698 GUIDE, CARRIER TRACK BOOMS TO TURRET ASSEMBLY Tue Mar 23 01:26:00 UTC 2021 2-25...
Page 81 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY REPAIR PARTS TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY Tue Mar 23 01:26:01 UTC 2021 2-26...
Page 82 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY Tue Mar 23 01:26:02 UTC 2021 2-26...
Page 83 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY アイテム部品番号名前数量 1430723 B TIP BOOM TO INTERMEDIATE BOOM ASSY TCB 19.013 660SJ GEN I BOOM UP DATE S/N 660SJ-11-161200002 - 660SJ- 11-170600039 511545-000 TIP BOOM WELDMENT 511544-501 INTERMEDIATE BOOOM WELDMENT 511291-400 ANCHOR WELDMENT WIRE ROPE 1430724 TELESCOPE ASSEMBLY 056060-015 BOLT, HEX BOLT DIN931 M10 X 15MM 8.8 ZINC PLTD 5560009 NUT 1/2-13 SELF LOCKING 1431077 WIRE ROPE ASSY RETRACT, (3/8...
Page 84 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TIP BOOM TO INTERMEDIATE BOOM ASSEMBLY アイテム部品番号名前数量 106540-100 SLAVE LEVEL CYLINDER 511347-000 4MORFF X 4MORFF 90° UNION FITTING 511390-000 WEARPAD INTERMEDIATE TOP 511389-000 WEARPAD RETAINER INTERMEDIATE 056060-020 HEX HD BOLT M10-1.50 X 20MM GR 8.8 511396-000 WEARPAD INTERMEDIATE TOP 511397-000 WEARPAD RETAINER TIP BOOM 511626-000 WEARPAD INTERMEDIATE BOTTOM 511627-000 WEARPAD TIP BOTTOM 511628-000 SIDE WEAR PAD...
Page 85 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EXTEND CYLINDER ASSEMBLY REPAIR PARTS EXTEND CYLINDER ASSEMBLY Tue Mar 23 01:26:02 UTC 2021 2-27...
Page 86 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EXTEND CYLINDER ASSEMBLY アイテム部品番号名前数量 1430724 B TELESCOPE CYLINDER ASSEMBLY 1430666 EXTEND CYLINDER, 3.50X 173 X 2.25 511205-500 WELDMENT, SHEAVE MOUNT 511211-000 SLIDE PAD 511218-000 Shim, Slide Pad 2mm Shown 511210-000 Slide Pad Hose Cable Assembly 511551-000 WEAR PAD, CYLINDER SUPPORT BOTTOM FRONT 2500047 BRG 1.50ID 2.00OD .875 0081776 SHEAVE 5560256 BRG THR 1.50ID 2.50OD .059 510567-016 CSK SKT FLT MACH SCREW M6- 1.0 X 16 10.9...
Page 87 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 JIB ASSEMBLY 78" 460SJ 660SJ REPAIR PARTS JIB ASSEMBLY 78" 460SJ 660SJ Tue Mar 23 01:26:03 UTC 2021 2-28...
Page 88 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 JIB ASSEMBLY 78" 460SJ 660SJ アイテム部品番号名前数量 1430842 C JIB ASSEMBLY 78" 460SJ 660SJ Shown 1430860 QUADRANT ASSEMBLY 0420732 WLDMT JIB ARM LOWER 7' JIB 0420114 ASSEMBLY, ROTATOR PLATF 0420731 WLDMT ARM JIB UPPER 7' 1431664 PIN, 1.25 DIA X 5.915 GRIP 0172216 PIN TEARDROP 1.0 X 9.43 5560712 MACH BSHG 1.25 ID X 1.88 OD 5560713 MACH BSHG 1.00IDX2.00ODX.075 0420111 CYLINDER JIB 5563577 BOLT HHS 3/8-16 X .375 YLZN GR10.9...
Page 89 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 QUADRANT ASSEMBLY REPAIR PARTS QUADRANT ASSEMBLY Tue Mar 23 01:26:04 UTC 2021 2-29...
Page 90 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 QUADRANT ASSEMBLY アイテム部品番号名前数量 1430860 A QUADRANT ASSEMBLY Shown 1430843 WELDMENT, JIB INNER QUADRANT 2509717 BEARING 40-48-40 2500060 BEARING 1.0ID X 1.125OD X 1.00LG 2500035 BEARING QUADRANT ASSEMBLY Tue Mar 23 01:26:04 UTC 2021 2-29...
Page 91 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PLATFORM MOUNT ASSEMBLY REPAIR PARTS PLATFORM MOUNT ASSEMBLY Tue Mar 23 01:26:04 UTC 2021 2-30...
Page 92 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PLATFORM MOUNT ASSEMBLY アイテム部品番号名前数量 1432066 A ASSEMBLY, PLATFORM MOUNT 0113545 ASSY, SD PLATFORM 986299 WASHER, FLAT, .375 STANDARD, PLATED 972479 BLT HEXHD .375-16 1.25 GR5 5560033 .375-16UNC HEX LOCK NUT 1432064 WELDMENT PLATFORM MOUNT 1 PLATFORM MOUNT ASSEMBLY Tue Mar 23 01:26:04 UTC 2021 2-30...
Page 93 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PLATFORM, JIB TO BOOM ASSEMBLY REPAIR PARTS PLATFORM, JIB TO BOOM ASSEMBLY Tue Mar 23 01:26:05 UTC 2021 2-31...
Page 94 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PLATFORM, JIB TO BOOM ASSEMBLY アイテム部品番号名前数量 1430720 B PLATFORM, JIB TO BOOM Shown ASSEMBLY 116346-000 overload cell ‒ CE ONLY BEFORE SN 01-0004 (Not illustrated) 1430852 SLAVE CYL ROD PIN 106568-100 TIP BOOM PIVOT PIN 065214-000 ROD END 3/8" 512649-280 BOLT,HexBolt,DIN931,M24 x 280m 5563549 WASHER, FLAT M24 YL ZN GR 10.9 5563563 NUT, HEX M24X3 YL ZN PLT GR10.9 058508-025 HHCS M10 X 25MM GR10.9 DIN933...
Page 95 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PLATFORM ROUND TUBE ASSEMBLY COMPONENTS REPAIR PARTS PLATFORM ROUND TUBE ASSEMBLY COMPONENTS Tue Mar 23 01:26:05 UTC 2021 2-32...
Page 96 5563541 WASHER, FLAT, M6, STEEL, C10.9, YELLOW ZINC 5663509 WASHER, FLAT M6 YL ZN GR 10.9 5563544 WSHR, FLAT M12 YL ZN GR 10.9 8 3030188 OVERLOAD SENSOR PLATE 0113634 PLATE, 120V COVER 0113450 WLDMT CONTROL BOX SKIRT 1432230 ASSY SNORKEL GUARD 660SJ 1431693 BRACKET SNORKEL GUARD LIGHT 972479 BLT HEXHD .375-16 1.25 GR5 986299 WASHER, FLAT, .375 STANDARD, PLATED 5560033 .375-16UNC HEX LOCK NUT 1432066 ASSY PLATFORM MOUNT PLATFORM ROUND TUBE ASSEMBLY COMPONENTS Tue Mar 23 01:26:06 UTC 2021...
Page 97 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SNORKEL GUARD ASSEMBLY REPAIR PARTS SNORKEL GUARD ASSEMBLY Tue Mar 23 01:26:06 UTC 2021 2-33...
Page 98 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SNORKEL GUARD ASSEMBLY アイテム部品番号名前数量 1432230 A SNORKEL GUARD ASSEMBLY 0113519 WLDMT, SNORKEL GUARD 0113529 WLDMT ACTIVATION BAR 0113528 PIN .375 X 2.31 GRIP 5563789 HHCS M6X1X70 G10.9 ISO 4014 DIN 931 0113530 SPRING ANTI-ENTRAPMENT 5593018 RETAINING RING, EXTERNAL, .375 DIA, BASIC 3028844 IFS241 (IFM PROXY) 0113538 WLDMT SHEILD 984069 NUT HEX .250-20 970029 BLT .25-20 .750 7030163 DECAL SNORKEL GUARD...
Page 99 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK INSTALL REPAIR PARTS CARRIER TRACK INSTALL Tue Mar 23 01:26:07 UTC 2021 2-34...
Page 100 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK INSTALL CARRIER TRACK INSTALL Tue Mar 23 01:26:07 UTC 2021 2-34...
Page 101 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK INSTALL CARRIER TRACK INSTALL Tue Mar 23 01:26:08 UTC 2021 2-34...
Page 102 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK INSTALL アイテム部品番号名前数量 1430719 B CARRIER TRACK INSTALLATION Shown 511566-000 CAT TRACK SUPPORT BRKT 511595-001 CAT TRACK TUBE @BASE BOOM 1430991 CARRIER TRACK PRE ASSEMBLY 056069-008 WASHER, STEELFLATWASHER DIN12M8 FLAT WASHER DIN 500595-020 Bolt, SktButCapScrew DIN9427 500595-025 Bolt, SktButCapScrew DIN9427 056064-008 NUT HEX M8-1.25 GR10.9 SELF LOCKING DIN 985 056021-008 Washer SpringWasher DIN127B 500595-016 BLT SKTBUTCAPSCREW M8 X 16MM DIN9427 GR10.9 Z P 056060-015 BOLT, HEX BOLT DIN931 M10 X 15MM 8.8 ZINC PLTD...
Page 103 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK INSTALL アイテム部品番号名前数量 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 056060-020 HEX HD BOLT M10-1.50 X 20MM GR 8.8 1431524 HOSE PRTR SQ TB CAT TRACK 1431525 HOSE PRTR RD TB CAT TRACK 0072015 CLEVIS PIN CARRIER TRACK INSTALL Tue Mar 23 01:26:08 UTC 2021 2-34...
Page 104 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HOSE CARRIER TUBE GUIDE ASSEMBLY REPAIR PARTS HOSE CARRIER TUBE GUIDE ASSEMBLY Tue Mar 23 01:26:08 UTC 2021 2-35...
Page 105 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HOSE CARRIER TUBE GUIDE ASSEMBLY アイテム部品番号名前数量 1430765 A HOSE CARRIER TUBE GUIDE Shown ASSEMBLY 1430761 HOSE CARRIER TUBE GUIDE WELDMENT 0190842 PLASTIC ROLLER 1.50/1.00 X 3.50 0084677 TOP COVER 0181271 SPACER 986299 WASHER, FLAT, .375 STANDARD, PLATED 970629 BLT HHD .375-16 X 5 GR5 5560033 .375-16UNC HEX LOCK NUT 5560645 BLT HEXHD .375-16 5.50 GR5- HOSE CARRIER TUBE GUIDE ASSEMBLY Tue Mar 23 01:26:08 UTC 2021...
Page 106 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK PRE ASSEMBLY REPAIR PARTS CARRIER TRACK PRE ASSEMBLY Tue Mar 23 01:26:08 UTC 2021 2-36...
Page 107 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CARRIER TRACK PRE ASSEMBLY アイテム部品番号名前数量 1430991 A CARRIER TRACK PRE ASSEMBLY Shown 511557-300 CABLE TRACK 1430735 GUIDE, CARRIER TRACK 505082-008 SKT BUT CAP SCREW M5-0.8 X 5MM GR10.9 CARRIER TRACK PRE ASSEMBLY Tue Mar 23 01:26:08 UTC 2021 2-36...
Page 108 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA REPAIR PARTS COWLING INSTALL KUBOTA Tue Mar 23 01:26:09 UTC 2021 2-37...
Page 109 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA COWLING INSTALL KUBOTA Tue Mar 23 01:26:09 UTC 2021 2-37...
Page 110 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA COWLING INSTALL KUBOTA Tue Mar 23 01:26:10 UTC 2021 2-37...
Page 111 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA COWLING INSTALL KUBOTA Tue Mar 23 01:26:10 UTC 2021 2-37...
Page 112 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA アイテム部品番号名前数量 1431891 B COWLING INSTALLATION Shown KUBOTA 1431897 FRAME ASSY - LH 1431898 DOOR ASSY - LH REAR 1431899 DOOR ASSY - LH FRONT 508247-010 Washer,PennyWasher, DIN9021,M1 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 510561-006 Washer, SteelFlatWasher DIN125 6 058508-025 HHCS M10 X 25MM GR10.9 DIN933 1431460 MOUNT-BUMPER 056064-010 Nut NylockNut DIN985 M10 10.0...
Page 113 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 COWLING INSTALL KUBOTA アイテム部品番号名前数量 1431968 NOSE CONE-LH WA 1431966 BRACKET BUMPER 1432043 SUPPORT-LH NOSE CONE 058509-030 Bolt, HexBolt DIN931 M10 x 30mm 10.9 Dacromet COWLING INSTALL KUBOTA Tue Mar 23 01:26:10 UTC 2021 2-37...
Page 114 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FRAME LEFT HAND ASSEMBLY REPAIR PARTS FRAME LEFT HAND ASSEMBLY Tue Mar 23 01:26:11 UTC 2021 2-38...
Page 115 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FRAME LEFT HAND ASSEMBLY アイテム部品番号名前数量 1431897 B FRAME LEFT HAND ASSEMBLY 5534385 10 MM BALL STUD, .3125-18 056069-008 WASHER, STEELFLATWASHER DIN12M8 FLAT WASHER DIN 1431933 FRAME WA-LH 1431544 COVER-HAND 510681-016 HHCS M8X1.25X16 G10.9 ISO 4014 FRAME LEFT HAND ASSEMBLY Tue Mar 23 01:26:11 UTC 2021 2-38...
Page 116 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR ASSEMBLY-LH REAR REPAIR PARTS DOOR ASSEMBLY-LH REAR Tue Mar 23 01:26:11 UTC 2021 2-39...
Page 117 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR ASSEMBLY-LH REAR アイテム部品番号名前数量 1431898A DOOR ASSEMBLY-LH REAR Shown 1431953 DOOR WA-LH REAR 5516370 HINGE-.375 PIN ASSY 5510022 ADJUSTABLE LEVER LATCH 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 056069-006 WSHR STEELFLATWSHE M6 DIN125A 058508-025 HHCS M10 X 25MM GR10.9 DIN933 5534385 10 MM BALL STUD, .3125-18 5516357 STRAP-NYLON, 24 INCH 056064-006 NUT NYLOCK DIN985 M6 10.0 2540015 PLUG-PIPE, .84-.93" ID 512630-020...
Page 118 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR LEFT HAND FRONT ASSEMBLY REPAIR PARTS DOOR LEFT HAND FRONT ASSEMBLY Tue Mar 23 01:26:12 UTC 2021 2-40...
Page 119 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR LEFT HAND FRONT ASSEMBLY アイテム部品番号名前数量 1431899B DOOR LEFT HAND FRONT ASSEMBLY 5510022 ADJUSTABLE LEVER LATCH 056069-010 Washer, SteelFlatWasher Shown DIN125A M10 ZincPlated 5534385 10 MM BALL STUD, .3125-18 2540015 PLUG-PIPE, .84-.93" ID 1431946 DOOR WA-LH FRONT 5516370 HINGE-.375 PIN ASSY 058508-025 HHCS M10 X 25MM GR10.9 DIN933 5516357 STRAP-NYLON, 24 INCH 056069-006 WSHR STEELFLATWSHE M6 DIN125A...
Page 120 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR RIGHT HAND REAR ASSEMBLY REPAIR PARTS DOOR RIGHT HAND REAR ASSEMBLY Tue Mar 23 01:26:12 UTC 2021 2-41...
Page 121 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR RIGHT HAND REAR ASSEMBLY アイテム部品番号名前数量 1431895B DOOR RIGHT HAND REAR ASSEMBLY 5510022 ADJUSTABLE LEVER LATCH 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 056069-006 WSHR STEELFLATWSHE M6 DIN125A 5534385 10 MM BALL STUD, .3125-18 056064-006 NUT NYLOCK DIN985 M6 10.0 2540015 PLUG-PIPE, .84-.93" ID 1431912 DOOR WA-RH REAR 5516370 HINGE-.375 PIN ASSY 5516357 STRAP-NYLON, 24 INCH 512630-020 HHCS M6 X X 20 G10.9 DIN 933 2...
Page 122 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR RIGHT HAND FRONT ASSEMBLY REPAIR PARTS DOOR RIGHT HAND FRONT ASSEMBLY Tue Mar 23 01:26:12 UTC 2021 2-42...
Page 123 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DOOR RIGHT HAND FRONT ASSEMBLY アイテム部品番号名前数量 1431894 B DOOR RIGHT HAND FRONT ASSEMBLY 5510022 ADJUSTABLE LEVER LATCH 056069-010 Washer, SteelFlatWasher DIN125A M10 ZincPlated 5534385 10 MM BALL STUD, .3125-18 2540015 PLUG-PIPE, .84-.93" ID 5516370 HINGE-.375 PIN ASSY 1431922 DOOR WA-RH FRONT 056069-006 WSHR STEELFLATWSHE M6 DIN125A 058508-025 HHCS M10 X 25MM GR10.9 DIN933 5516357 STRAP-NYLON, 24 INCH 512630-020...
Page 124 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DECALS KIT REPAIR PARTS DECALS KIT Tue Mar 23 01:26:13 UTC 2021 2-43...
Page 125 Shown 0074209 PLACARD, PRE-START Shown INSTRUCTION 0074210 DECAL, DANGER ELEC/TIP Shown HAZARD 0074316 DECAL, CAUTION GOVERNOR Shown DAMAGE 0083426 Decal, Lifting and Tie Down Shown 0083733 DECAL, SNORKEL BRAND LOGO Shown 10.0 150448 Decal, lanyard attachment Shown 0151410 DECAL, DANGER ROTATING Shown PARTS 161014 PLAC BATTERY OFF/ON Shown 190989 DECAL, DANGER DO NOT REACH Shown DECALS KIT Tue Mar 23 01:26:13 UTC 2021...
Page 126 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DECALS KIT アイテム部品番号名前数量 323896 DECAL, DANGER ELECT HAZARD Shown 323897 DECAL, DANGER MUST NOT Shown OPERATE 569295 DECAL, SNORKEL BRAND LOGO Shown 3.00 1430864 DECAL, MAIN CONTROL PANEL Shown 1431697 DECAL, MAIN CONTROL PANEL Shown UPPR 1431454 DECAL WEIGHT CAPACITY Shown 1431455 DECAL, SNORKEL ID Shown 1431648 DECAL, SNORKEL 660SJ LG...
Page 127 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DECALS KIT アイテム部品番号名前数量 0075887 DECAL, MANIFOLD DRIVE Shown 0075888 DECAL, MANIFOLD LIFT Shown 0075889 DECAL, MANIFOLD EXTEND Shown 0075890 DECAL, MANIFOLD SWING Shown 0075891 DECAL, MANIFOLD Shown JIB/PLATFORM 0075892 DECAL, MANIFOLD STEER Shown 0075893 DECAL, MANIFOLD LEVEL Shown 0075894 DECAL, MANIFOLD SHIFT Shown 0075895 DECAL, MANIFOLD OSCILLATE Shown...
Page 128 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC HYDRAULICS HYDRAULIC HOSE DIAGRAM 660SJ OSC Tue Mar 23 01:26:14 UTC 2021...
Page 129 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC HYDRAULIC HOSE DIAGRAM 660SJ OSC Tue Mar 23 01:26:14 UTC 2021...
Page 130 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC HYDRAULIC HOSE DIAGRAM 660SJ OSC Tue Mar 23 01:26:15 UTC 2021...
Page 131 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC HYDRAULIC HOSE DIAGRAM 660SJ OSC Tue Mar 23 01:26:15 UTC 2021...
Page 132 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC HYDRAULIC HOSE DIAGRAM 660SJ OSC Tue Mar 23 01:26:16 UTC 2021...
Page 133 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC アイテム部品番号名前数量 1431728F HYDRAULIC HOSES, 660SJ OSC 1432092 2" SUCTN HOSE 7219-2000025- 1430963 HYD HOSE 451 TC TYPE 3/4" 1430961 HYD HOSE 471 TC -12 3000 PSI 1430964 HYD HOSE 451 TC TYPE 3/4" 3000 PSI 12FORFF STR X 12FORFF STR X78" 1430595 CS 1-1/2 A36 Tie Down 1430960 HYD HOSE 787TC-10 TYPE 5/8" 1430958 HYD HOSE 471 TC TYPE 1/4" 1430969 HYD HOSE 451 TC TYPE 1/4" 1430970 HYD HOSE 451 TC TYPE 3/8" 1430966 HYD HOSE 451 TC TYPE 3/8"...
Page 134 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC アイテム部品番号名前数量 1430977 HYD HOSE 451 TC TYPE 3/8" 1430985 HYD HOSE 451 TC TYPE 1/4" 1430984 HYD HOSE 451 TC TYPE 1/4" 1430981 HYD HOSE 451 TC TYPE 1/4" 1430982 HYD HOSE 451 TC TYPE 1/4" 1430983 HYD HOSE 451 TC TYPE 1/4" 1430980 HYD HOSE 451 TC TYPE 1/4" 1430971 HYD HOSE 451 TC TYPE 3/8" 1430978 HYD HOSE 451 TC TYPE 1/4" 1430979 HYD HOSE 451 TC TYPE 1/4" 1430939 HYD HOSE 787TC-8 TYPE 1/2" 1430938 HYD HOSE 787TC-8 TYPE 1/2"...
Page 135 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC アイテム部品番号名前数量 1430945 HYD HOSE 787TC-10 TYPE 5/8" 1430946 HYD HOSE 451 TC TYPE 3/8" 1430946 HYD HOSE 451 TC TYPE 3/8" 1432014 HYD HOSE 471 TC -4, 101.5" 1432013 HYD HOSE 471 TC -4, 101.5" 1430948 HYD HOSE 451 TC TYPE 1/4" 1430948 HYD HOSE 451 TC TYPE 1/4" 1430949 HYD HOSE 451 TC TYPE 1/4" 1432015 HYD HOSE 471 TC -4, 66.5" 1432016 HYD HOSE 471 TC -4, 66.5" 1432017 HYD HOSE 471 TC -4, 97" 1430952 HYD HOSE 451 TC TYPE 1/4"...
Page 136 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM 660SJ OSC アイテム部品番号名前数量 511617-000 FTG, 8MORFF X 8MORFF X 8MORFF UTEE 1431731 HYD HOSE 471 TC-4, 3000PSI 49" 1431732 HYD HOSE 471 TC-4, 3000PSI 12" 100435-001 FTG 4 MORFFX X 4 FORFF90 100435-003 FTG, 90°, 8MORFF X 8FORFF 11354-000 SLEEVE-TUBE CLAMP 11355-002 BODY CLAMP HYDAC 11356-000 STIRRUP CLAMP HYDAC 11355-006 BODY-TUBE CLAMP #1 X 1/2 11356-001 STIRRUP-TUBE CLAMP #2 11355-014 BODY CLAMP HYDAC 00264713 4...
Page 137 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AXLE LOCK CYLINDER HENGLI HYDRAULICS AXLE LOCK CYLINDER HENGLI Tue Mar 23 01:26:16 UTC 2021...
Page 138 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AXLE LOCK CYLINDER HENGLI アイテム部品番号名前数量 5290013 AXLE LOCK CYLINDER HENGLI 6091953 THROTTLE BALANCING VALVE 6091954 BEARING 6091955 SEAL KIT-(INCLUDES ITEMS 11- AXLE LOCK CYLINDER HENGLI Tue Mar 23 01:26:16 UTC 2021...
Page 139 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AXLE LOCK CYL HYDRAULICS AXLE LOCK CYL Tue Mar 23 01:26:16 UTC 2021...
Page 140 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AXLE LOCK CYL アイテム部品番号名前数量 6047163 660 SJ OSC AXLE LOCK CYL Shown 6047177 BEARING 106771-105 BLEEDER SCREW 6091838 1/8 - 27 STR. SELFTAP LUBE FIT 6091839 INT. SNAP RING, 3.156 BORE 6091840 C/B VALVE CBAH-LJN (3500) 6091837 SEAL KIT Shown KIT ITEM O-RING KIT ITEM BACKUP RING KIT ITEM DEEP Z - SEAL KIT ITEM HD ROD WIPER, SEALED OD KIT ITEM WAREBAND KIT ITEM...
Page 141 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TRACTION MANIFOLD ASSEMBLY HYDRAULICS TRACTION MANIFOLD ASSEMBLY Tue Mar 23 01:26:17 UTC 2021...
Page 142 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TRACTION MANIFOLD ASSEMBLY アイテム部品番号名前数量 511621-000 C TRACTION MANIFOLD Shown ASSEMBLY 6019298 TRACTION MANIFOLD 511585-000 GTG STR 10 MORB X 12 MORFS 100434-002 FITTING 4MORFF X 4MORB 90° 100432-002 Hyd Fitting - Straight ORFS(04) - SAE(04) 100434-013 Hyd Fitting - 90 Elbow ORFS(08) - SAE(08) 100432-015 FTG, STR, 8MORFF X 8MORB 5075303 ADAPTER PLUG SOCKET -4 SAE TRACTION MANIFOLD ASSEMBLY Tue Mar 23 01:26:17 UTC 2021...
Page 143 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MANIFOLD TRACTION HYDRAULICS MANIFOLD TRACTION Tue Mar 23 01:26:17 UTC 2021...
Page 144 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MANIFOLD TRACTION アイテム部品番号名前数量 6019298 TRACTION MANIFOLD Shown 6091832 FLOW DIVIDER COMBINER 6091833 FLOW DIVIDER COMBINER 6091834 OVERCENTER VALVE 6091835 PRESSURE REDUCING VALVE 6091836 CHECK VALVE MANIFOLD TRACTION Tue Mar 23 01:26:17 UTC 2021...
Page 145 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY HYDRAULICS OMNI POWER WHEEL ASSEMBLY Tue Mar 23 01:26:18 UTC 2021...
Page 146 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY アイテム部品番号名前数量 116324-000 Wheel Gearbox 8010399 HOUSING VB07 H1 8010401 CAP LOCKOUT VB07 8010400 CAP END VB07 8010412 SEAL OIL; 0637-60008 8010412 SEAL OIL; 0637-60008 056066-014 NUT NYLOCK DIN985 M14 8.0 ZINC PLTD 058490-006 HEXSETSCREW 8010406 SPINDLE VB07 8010409 BEARING CONE 32928 8010408 BEARING CUP 32928 056058-012 BLT HEXBOLT 6MM X 12MM DIN931 GR8.8 ZP...
Page 147 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 OMNI POWER WHEEL ASSEMBLY アイテム部品番号名前数量 8010419 ROLL PIN HD; 4MM X19 8010405 GEAR SUN VB07 25T LS 8010429 SNAP RING; GB#40 8010403 INPUT SHAFT VB07 13T 8010422 CARRIER ASSY; VB07 PRI 10.15 8010428 BRAKE ASSY; VB07 8010440 BRAKE ROTOR; VB07 8010436 PLATE SPRING RETAINING VB07 8010430 SNAP RING; GB#105; INTERNAL 8010441 HYDRAULIC PISTON; VB07 8010438 BACKUP RING; VB07 8010437 BACKUP RING; VB07 8010415 SEAL O-RING -154...
Page 148 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR REAR ASSEMBLY HYDRAULICS HYDRAULIC MOTOR REAR ASSEMBLY Tue Mar 23 01:26:18 UTC 2021...
Page 149 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC MOTOR REAR ASSEMBLY アイテム部品番号名前数量 511581-000 B HYDRAULIC MOTOR REAR ASSEMBLY 104665-000 DRIVE MOTOR HYD 38cc/9.22cc 1 100434-013 Hyd Fitting - 90 Elbow ORFS(08) - SAE(08) 100434-015 Hyd Fitting - 90 Elbow ORFS(08) - SAE(12) 511481-000 FTG, 90°, 6MORFF X 6MORB 100432-002 Hyd Fitting - Straight ORFS(04) - SAE(04) HYDRAULIC MOTOR REAR ASSEMBLY Tue Mar 23 01:26:18 UTC 2021...
Page 150 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DRIVE MOTOR HYD 38cc HYDRAULICS DRIVE MOTOR HYD 38cc Tue Mar 23 01:26:19 UTC 2021...
Page 151 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DRIVE MOTOR HYD 38cc アイテム部品番号名前数量 104665-000 A DRIVE MOTOR HYD 38cc Shown 8190343 SEAL KIT FOR 116325-000 MOTOR 106751-101 CYLINDER BLOCK KIT 104665-100 SHAFT DRIVE MOTOR HYD 38cc Tue Mar 23 01:26:19 UTC 2021...
Page 152 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CYLINDER, STEER HYDRATECH HYDRAULICS CYLINDER, STEER HYDRATECH Tue Mar 23 01:26:19 UTC 2021...
Page 153 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CYLINDER, STEER HYDRATECH アイテム部品番号名前数量 5290010 660 STEER CYLINDER Shown 6091842 COMPOSITE BUSHING 6091841 SEAL KIT (COMPONENTS IN KIT NOT SHOWN) CYLINDER, STEER HYDRATECH Tue Mar 23 01:26:19 UTC 2021...
Page 154 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SWING DRIVE GEARBOX HYDRAULICS SWING DRIVE GEARBOX Tue Mar 23 01:26:19 UTC 2021 3-10...
Page 155 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SWING DRIVE GEARBOX アイテム部品番号名前数量 106755-000 A SWING DRIVE GEARBOX 106755-100 PINION, OUTPUT 106755-101 BUSHING, BRONZE 106755-102 BRG, ROLL CUP M802011 & CONE M802048 NOT SOLD SEPARATELY 106755-103 SEAL, OIL #12172PTC 106755-104 PIN, DOWELL 3/8x1" 106755-105 O-RING, PARKER 2-043 106755-106 CAP, BLIND GEAR 106755-107 CAP, WORM NOT SOLD SEPARATELY NOT SOLD SEPARATELY 106755-108 WORM GEAR 44:1 106755-109 WORM 44:1 106755-110...
Page 156 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 7 PORT ROTARY MANIFOLD ASSEMBLY HYDRAULICS 7 PORT ROTARY MANIFOLD ASSEMBLY Tue Mar 23 01:26:20 UTC 2021 3-11...
Page 157 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 7 PORT ROTARY MANIFOLD ASSEMBLY アイテム部品番号名前数量 1432072 A 7 PORT ROTARY MANIFOLD Shown ASSEMBLY 1430782 ROTARY MANIFOLD 1430679 ROTARY MANIFOLD STOP 5560626 BLT HEXHD M10-1.5 X 30MM 5560719 NUT HEX LKG M 10 - 1.50 GR 986009 WSHR FLAT 10 100432-009 Hyd Fitting Straight ORFS(06) - SAE(06) 100434-008 6MB X 6M ORFF 90° FITTING 100432-004 Hyd Fitting - Straight ORFS(04) - SAE(06) 104764-000 6 MORFF X 6MB X 6 MORFF RUN TEE...
Page 158 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ROTARY MANIFOLD HYDRAULICS ROTARY MANIFOLD Tue Mar 23 01:26:20 UTC 2021 3-12...
Page 159 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ROTARY MANIFOLD アイテム部品番号名前数量 1430782 ROTARY MANIFOLD Shown 6091814 RETAINING RING 6091813 THRUST RING 6091812 SEAL KIT KIT ITEM POLYSEAL SQUARE-B KIT ITEM O-RING SQUARE KIT ITEM CAP SEAL KIT ITEM CAP SEAL KIT ITEM POLYSEAL SQUARE-B 6091814 RETAINING RING 6091813 THRUST RING ROTARY MANIFOLD Tue Mar 23 01:26:20 UTC 2021 3-12...
Page 160 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EMERGENCY POWER UNIT WUXI DELI APRIL 2016 AND AFTER HYDRAULICS EMERGENCY POWER UNIT WUXI DELI APRIL 2016 AND AFTER Tue Mar 23 01:26:20 UTC 2021 3-13...
Page 161 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EMERGENCY POWER UNIT WUXI DELI APRIL 2016 AND AFTER アイテム部品番号名前数量 6020058 B EMERGENCY POWER UNIT WUXI DELI 6029699 GEAR PUMP 6029698 DC MOTOR EMERGENCY POWER UNIT WUXI DELI APRIL 2016 AND AFTER Tue Mar 23 01:26:20 UTC 2021 3-13...
Page 162 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MASTER LEVEL CYLINDER ROSENBOOM HYDRAULICS MASTER LEVEL CYLINDER ROSENBOOM Tue Mar 23 01:26:21 UTC 2021 3-14...
Page 163 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MASTER LEVEL CYLINDER ROSENBOOM アイテム部品番号名前数量 100553-100A MASTER LEVEL CYLINDER ROSENBOOM 100553-104 JOURNAL BEARING 100553-106 JOURNAL BEARING 100553-108 SEAL KIT (10- THRU 19) MASTER LEVEL CYLINDER ROSENBOOM Tue Mar 23 01:26:21 UTC 2021 3-14...
Page 164 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LIFT CYLINDER ROSENBOOM HYDRAULICS LIFT CYLINDER ROSENBOOM Tue Mar 23 01:26:21 UTC 2021 3-15...
Page 165 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LIFT CYLINDER ROSENBOOM アイテム部品番号名前数量 1431076 A LIFT CYLINDER ROSENBOOM 6091881 SEAL KIT 6091314 COUNTER BALANCE VALVE 6010115 CARTRIDGE NEEDLE VALVE 6091802 SEAL KIT KIT ITEM O-RING KIT ITEM O-RING KIT ITEM O-RING KIT ITEM BACKUP RING, DYNAMIC KIT ITEM BACKUP RING KIT ITEM DZR SEAL KIT ITEM CAST IRON PISTON RING KIT ITEM CAPPED T-SEAL KIT ITEM...
Page 166 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN MANIFOLD ASSEMBLY HYDRAULICS MAIN MANIFOLD ASSEMBLY Tue Mar 23 01:26:22 UTC 2021 3-16...
Page 167 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN MANIFOLD ASSEMBLY アイテム部品番号名前数量 1432076C MANIFOLD ASSEMBLY-OSC Shown 6019349 HYD MANIFOLD OSC AXLE 1431495 BRACKET, BOTTOM HAWE VLV 1431494 BRACKET, TOP HAWE VALVE MOUNT 056069-008 WASHER, STEELFLATWASHER DIN12M8 FLAT WASHER DIN 510681-016 HHCS M8X1.25X16 G10.9 ISO 4014 511587-016 ORFS SWIVEL/SAE ORB ADAPTER 063965-001 PLUG-TEST PORT 511339-000 FTG, STR, 6MORFF X 8MORB 100434-002 FITTING 4MORFF X 4MORB 90°...
Page 168 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CONTROL VALVE HAWE HYDRAULICS CONTROL VALVE HAWE Tue Mar 23 01:26:22 UTC 2021 3-17...
Page 169 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CONTROL VALVE HAWE アイテム部品番号名前数量 6019349A MAIN HYDRAULIC MANIFOLD OSCILLATING AXLE 6091815 CONTROL VALVE HAWE (INLET SECTION) 6091816 PRESSURE LIMITING VALVE 6091817 SEAL KIT FOR 6091815 6091818 IDLE CIRCULATION VALVE 12V 6091819 VALVE SECTION, DRIVE 6091598 SEAL KIT 6091820 COIL, 12VDC 6091821 ADAPTER SECTION SZ3 TO SZ2 6091822 SEAL KIT FOR 6091821 6091823 VALVE SECTION, BOOM 8080150 SEAL KIT-WORK SECTION (HAWE)
Page 170 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CONTROL VALVE HAWE アイテム部品番号名前数量 6091828 VALVE SECTION, LEVEL 8080150 SEAL KIT-WORK SECTION (HAWE) 8080151 COIL ( for valve 6019057) 6091829 SEAL KIT INTERMEDIATE PLATE 6019221 CARTRIDGE 3-WAY 6091830 COIL, 12VDC 6091831 PRESSURE REDUCING CARTRIDGE CONTROL VALVE HAWE Tue Mar 23 01:26:22 UTC 2021 3-17...
Page 171 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FILTER, IN-TANK RETURN HYDRAULICS FILTER, IN-TANK RETURN Tue Mar 23 01:26:22 UTC 2021 3-18...
Page 172 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FILTER, IN-TANK RETURN アイテム部品番号名前数量 6019326 A FILTER, IN-TANK RETURN Shown 6091861 FILTER, ELEMENT REPLACEMENT 6091860 SEAL KIT Shown KIT ITEM COVER SEAL KIT ITEM EXTERNAL SEAL KIT ITEM DEFUSER SEAL KIT ITEM INSERT ASSEMBLY, INTERNAL SEAL KIT ITEM HEAD SEAL KIT ITEM FILTER ELEMENT SEAL KIT ITEM AIR BREATHER SCREW SEAL KIT ITEM PLUG-ANTI SPLASH SEAL KIT ITEM...
Page 173 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HP FILTER ASSEMBLY HYDRAULICS HP FILTER ASSEMBLY Tue Mar 23 01:26:23 UTC 2021 3-19...
Page 174 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HP FILTER ASSEMBLY アイテム部品番号名前数量 1432101 A HP FILTER ASSEMBLY Shown 6019325 Pressure Filter 100434-021 Hyd Fitting - 90 Elbow ORFS(12) - SAE(12) HP FILTER ASSEMBLY Tue Mar 23 01:26:23 UTC 2021 3-19...
Page 175 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PRESSURE FILTER ASSEMBLY HYDRAULICS PRESSURE FILTER ASSEMBLY Tue Mar 23 01:26:23 UTC 2021 3-20...
Page 176 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 PRESSURE FILTER ASSEMBLY アイテム部品番号名前数量 6019325 A PRESSURE FILTER ASSEMBLY Shown 6019325 Pressure Filter 6091845 REPLACEMENT FILTER ELEMENT 6091846 SEAL KIT FOR 6019325 Shown KIT ITEM O-RING FOR FILTER ELEMENT KIT ITEM O-RING FOR HOUSING KIT ITEM ANTI-EXTRUSION RING KIT ITEM GASKET KIT ITEM O-RING KIT ITEM PROTECTOR SEAL PNNA INDICATOR PRESSURE FILTER ASSEMBLY Tue Mar 23 01:26:23 UTC 2021...
Page 177 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOAD SENSE PUMP HENGLI HYDRAULICS LOAD SENSE PUMP HENGLI Tue Mar 23 01:26:23 UTC 2021 3-21...
Page 178 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOAD SENSE PUMP HENGLI アイテム部品番号名前数量 6029697 LOAD SENSE PUMP HENGLI 6091855 CONTROL VALVE 6091856 TORQUE LIMIT CONTROL 6091857 NEEDLE BRARING 6091858 CYLINDER ROLLER BEARING 6091859 SEAL KIT KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS KIT ITEMS...
Page 179 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EXTEND CYLINDER ROSENBOOM HYDRAULICS EXTEND CYLINDER ROSENBOOM Tue Mar 23 01:26:24 UTC 2021 3-22...
Page 180 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 EXTEND CYLINDER ROSENBOOM アイテム部品番号名前数量 1430666 D EXTEND CYLINDER ROSENBOOM 6091794 COUNTERBALANCE VALVE 3000 106815-010 COUNTERBALANCE VALVE 2500 6091266 SEAL REPAIR KIT includes items 11 through 20 KIT ITEM O-RING KIT ITEM O-RING KIT ITEM BACKUP RING, DYNAMIC KIT ITEM BACK UP RING KIT ITEM DISO-PAC KIT ITEM BS U-CUP KIT ITEM HD ROD WIPER, SEALED OD KIT ITEM PRECISION WEARBAND KIT ITEM...
Page 181 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SLAVE LEVEL CYLINDER ROSENBOOM HYDRAULICS SLAVE LEVEL CYLINDER ROSENBOOM Tue Mar 23 01:26:24 UTC 2021 3-23...
Page 182 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SLAVE LEVEL CYLINDER ROSENBOOM アイテム部品番号名前数量 106540-100 A SLAVE LEVEL CYLINDER ROSENBOOM 100553-105 JOURNAL BEARING 106540-108 CB VALVE (3000) 106540-109 CB VALVE (1500) 100553-108 SEAL KIT (10- THRU 19) KIT ITEM O-RING KIT ITEM O-RING KIT ITEM O-RING KIT ITEM BACKUP RING KIT ITEM DISO-PAC KIT ITEM DEEP Z-SEAL KIT ITEM HD ROD WIPER, SEAL OD KIT ITEM...
Page 183 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 JIB CYLINDER HENGLI HYDRAULICS JIB CYLINDER HENGLI Tue Mar 23 01:26:25 UTC 2021 3-24...
Page 184 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 JIB CYLINDER HENGLI アイテム部品番号名前数量 0420111 H JIB CYLINDER HENGLI Shown 6047189 COUNTER BALANCE VALVE 6091901 CHECK VALVE-0420111 CYLINDER 561196 BRG 1.00ID X 1.125OD X 1.25LG 4 6091897 SEAL KIT-0420111 CYLINDER Shown KIT ITEM WIPER RING KIT ITEM ROD SEAL KIT ITEM WEAR RING KIT ITEM BUFFER RING KIT ITEM O-RING KIT ITEM BACK-UP RING KIT ITEM...
Page 185 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ROTATOR PLATFORM ASSEMBLY 460SJ 660SJ HYDRAULICS ROTATOR PLATFORM ASSEMBLY 460SJ 660SJ Tue Mar 23 01:26:25 UTC 2021 3-25...
Page 186 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ROTATOR PLATFORM ASSEMBLY 460SJ 660SJ アイテム部品番号名前数量 0420114 D PLATFORM ROTATOR ASSEMBLY 8080152 SEAL KIT 0420113 WLDMT ROTATOR PLATF 978419 BLT SKTHD .250-20 X 1.50 GR8 2500051 BASE END BRG 1.25ID X 1.50OD (10001174 FISHER CYL) 2509677 BUSHING BOTTOM 5035303 FTG ELB90STRTHD-4B-4S STL 6019089 VALVE DUAL COUNTERBALANCE 6019169 ORIFICE ELBOW FITTING SHOWN ROTATOR PLATFORM ASSEMBLY 460SJ 660SJ Tue Mar 23 01:26:25 UTC 2021 3-25...
Page 187 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DUAL COUNTERBALANCE VALVE HELAC ROTATOR HYDRAULICS DUAL COUNTERBALANCE VALVE HELAC ROTATOR Tue Mar 23 01:26:25 UTC 2021 3-26...
Page 188 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 DUAL COUNTERBALANCE VALVE HELAC ROTATOR アイテム部品番号名前数量 6019089 B DUAL COUNTERBALANCE Shown VALVE HELAC ROTATOR 6019277 VALVE COUNTERBALANCE (SET 3350PSI) 6019278 O-RING SEAL SIZE -110 70 DURO 2 6019279 ORIFICE 1/4 IN NPT PLUG DRILLED .015 IN 6019169 ORIFICE ELBOW FITTING DUAL COUNTERBALANCE VALVE HELAC ROTATOR Tue Mar 23 01:26:25 UTC 2021 3-26...
Page 189 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE ASSEMBLY HYDRAULICS SELECTOR VALVE ASSEMBLY Tue Mar 23 01:26:26 UTC 2021 3-27...
Page 190 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE ASSEMBLY アイテム部品番号名前数量 1430830 A SELECTOR VALVE ASSEMBLY Shown 6019324 SELECTOR VALVE 12VDC 100432-009 Hyd Fitting Straight ORFS(06) - SAE(06) 100433-005 FTG, 45°, 6MORFF X 6MORB SELECTOR VALVE ASSEMBLY Tue Mar 23 01:26:26 UTC 2021 3-27...
Page 191 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE JIB ROTATE HYDRAULICS SELECTOR VALVE JIB ROTATE Tue Mar 23 01:26:26 UTC 2021 3-28...
Page 192 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE JIB ROTATE アイテム部品番号名前数量 6019324 SELECTOR VALVE 12VDC 6091843 SEAL KIT FOR 6019324 VALVE 6091844 COIL 12 VDC SELECTOR VALVE JIB ROTATE Tue Mar 23 01:26:26 UTC 2021 3-28...
Page 193 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) HYDRAULICS HYDRAULIC HOSE DIAGRAM (KIT) Tue Mar 23 01:26:27 UTC 2021 3-29...
Page 194 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) HYDRAULIC HOSE DIAGRAM (KIT) Tue Mar 23 01:26:27 UTC 2021 3-29...
Page 195 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) HYDRAULIC HOSE DIAGRAM (KIT) Tue Mar 23 01:26:28 UTC 2021 3-29...
Page 196 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) HYDRAULIC HOSE DIAGRAM (KIT) Tue Mar 23 01:26:28 UTC 2021 3-29...
Page 197 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) アイテム部品番号名前数量 511630-000 F HYD HOSE DIAGRAM 660SJ Shown (KIT) 1432092 2" SUCTN HOSE 7219-2000025- 1430963 HYD HOSE 451 TC TYPE 3/4" 1430961 HYD HOSE 471 TC -12 3000 PSI 1460964 HYD HOSE 451 TC TYPE 3/4" 1430595 CS 1-1/2 A36 Tie Down 1430960 HYD HOSE 787TC-10 TYPE 5/8" 1430958 HYD HOSE 471 TC TYPE 1/4" 1430969 HYD HOSE 451 TC TYPE 1/4" 1430970 HYD HOSE 451 TC TYPE 3/8" 1430966 HYD HOSE 451 TC TYPE 3/8"...
Page 198 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) アイテム部品番号名前数量 1430977 HYD HOSE 451 TC TYPE 3/8" 1430985 HYD HOSE 451 TC TYPE 1/4" 1430984 HYD HOSE 451 TC TYPE 1/4" 1430981 HYD HOSE 451 TC TYPE 1/4" 1430982 HYD HOSE 451 TC TYPE 1/4" 1430983 HYD HOSE 451 TC TYPE 1/4" 1430980 HYD HOSE 451 TC TYPE 1/4" 1430971 HYD HOSE 451 TC TYPE 3/8" 1430978 HYD HOSE 451 TC TYPE 1/4" 1430979 HYD HOSE 451 TC TYPE 1/4" 1430939 HYD HOSE 787TC-8 TYPE 1/2" 1430938 HYD HOSE 787TC-8 TYPE 1/2"...
Page 199 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) アイテム部品番号名前数量 1430945 HYD HOSE 787TC-10 TYPE 5/8" 1430946 HYD HOSE 451 TC TYPE 3/8" 1430946 HYD HOSE 451 TC TYPE 3/8" 1430947 HYD HOSE 451 TC TYPE 1/4" 1430947 HYD HOSE 451 TC TYPE 1/4" 1430948 HYD HOSE 451 TC TYPE 1/4" 1430948 HYD HOSE 451 TC TYPE 1/4" 1430949 HYD HOSE 451 TC TYPE 1/4" 1430950 HYD HOSE 451 TC TYPE 1/4" 1430950 HYD HOSE 451 TC TYPE 1/4" 1430951 HYD HOSE 451 TC TYPE 1/4" 1430952 HYD HOSE 451 TC TYPE 1/4"...
Page 200 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC HOSE DIAGRAM (KIT) アイテム部品番号名前数量 967359 HOSESAE30R2-03 TYPE 3 3/16 012733-099 1/4" 50PSI FUEL HOSE X 12" 012733-099 1/4" 50PSI FUEL HOSE X 12" 012733-099 1/4" 50PSI FUEL HOSE X 12" 104769-000 FTG, 4MORFF X 4MORFF X 4MORFF UTEE 511617-000 FTG, 8MORFF X 8MORFF X 8MORFF UTEE 11355-002 BODY CLAMP HYDAC 100434-013 Hyd Fitting - 90 Elbow ORFS(08) - SAE(08) 11354-000 SLEEVE-TUBE CLAMP 12139-999 GUARD HOSE WRAP SL-3.0- Shown 1050B HYDRAULIC HOSE DIAGRAM (KIT)
Page 201 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL ELECTRICAL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:29 UTC 2021...
Page 202 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:29 UTC 2021...
Page 203 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:29 UTC 2021...
Page 204 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:29 UTC 2021...
Page 205 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:30 UTC 2021...
Page 206 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL LOWER CONTROL BOX ASSEMBLY SJ DIESEL Tue Mar 23 01:26:30 UTC 2021...
Page 207 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL アイテム部品番号名前数量 1430788 G 1-3 LOWER CONTROL BOX Shown ASSEMBLY SJ DIESEL 1430785 LOWER BOX SHELL 1430787 BACKING PLATE 3030181 Trionics - TBM 3030174 VALVE CURRENT CONTROL MODULE 512941-000 GP400C 056057-025 Bolt, HexBolt DIN931 M5 x 25mm 056069-005 Washer SteelFlatWasher DIN125A 056064-005 Nut, NylockNut DIN985 M5 10.0 1430786...
Page 208 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL アイテム部品番号名前数量 3049971 DEUTSCH 8-PIN BLKHD RCPT CONN- 510563-016 Bolt, SktCapScrew DIN912 M4 x 3040411 Alarm Buzzer 3028810 PUSH/PULL EMERGENCY STOP 3087803 EZCal Panel - Trionics 1430866 MOUNT LCD SCREEN 056069-006 WSHR STEELFLATWSHE M6 DIN125A 056058-020 Bolt, HexBolt DIN931 M6 x 20mm 056064-006 NUT NYLOCK DIN985 M6 10.0 1430864 DECAL, MAIN CONTROL PANEL 3069524...
Page 209 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX ASSEMBLY SJ DIESEL アイテム部品番号名前数量 3011641 WIRE 16GA SINGLE CONDUCTOR WHT 3011601 WIRE 16GA SINGLE CONDUCTOR BLK 3220199 CONNECTOR AMP 3 PIN 3220181 CONN AMP 2PIN P/N:1-480698- 3220024 CONNECTOR AMP 12 PIN 1-480- 3220142 CONNECTOR AMP 15 PIN PLUG 3049986 AMP SOCKET CONTACT 3011802 CABLE 18GA/2 CONDUCTOR Shown WIRE 18/2 TYPE SJOBLACK JACKETCABL 3220163 CONNECTOR AMP 4 PIN 1- Shown...
Page 210 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ ELECTRICAL LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:30 UTC 2021...
Page 211 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:30 UTC 2021...
Page 212 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:31 UTC 2021...
Page 213 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:31 UTC 2021...
Page 214 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:31 UTC 2021...
Page 215 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ LOWER CONTROL BOX CUMMINS 660SJ Tue Mar 23 01:26:31 UTC 2021...
Page 216 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ アイテム部品番号名前数量 1432928 A GROUND CONTROL BOX CUMMINS 660SJ 1430787 BACKING PLATE 3030181 Trionics - TBM 3030174 VALVE CURRENT CONTROL MODULE 512941-000 GP400C 056057-025 Bolt, HexBolt DIN931 M5 x 25mm 056069-005 Washer SteelFlatWasher DIN125A 056064-005 Nut, NylockNut DIN985 M5 10.0 1432105 LID LOWER CONTROL 100338-001 RECPT. DEUTSCH 015790-011...
Page 217 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ アイテム部品番号名前数量 056058-020 Bolt, HexBolt DIN931 M6 x 20mm 056064-006 NUT NYLOCK DIN985 M6 10.0 1432184 DECAL LOWER CONTROL PANEL CUMMINS 3069524 LIGHT RED LED 12V 1431983 WINDOW, CLEAR PLEXIGLASS 3028886 ASY KEY SW 3 POS CPTV2XNO 1432929 SHELL, LWR CTL CMNS 1432197 BRKT LCD SCREEN CUMMINS 5563889 PLUG PLASTIC SNAP-IN ID.50"BLK 3028879 CNCTR 2WAY PLUG GREY DT04- 3040341 PIN CONTACT SIZE 16 16/18...
Page 218 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX CUMMINS 660SJ アイテム部品番号名前数量 3220142 CONNECTOR AMP 15 PIN PLUG 3049986 AMP SOCKET CONTACT 3220163 CONNECTOR AMP 4 PIN 1- Shown 480702-0 3028875 CNCTR 4WAY PLUG GREY DT04- 3028884 LOCK WEDGE 4 PIN DEUTSCH W4-P 3014785 WIRE 10GA SINGLE COND RED 3014786 WIRE 10GA SINGLE COND BLACK 12554-009 RECEPTACLE 2 WIRE 12554-016 WEDGELOCK FOR DTP04-2P 12554-008 CONNECTOR DEUTSCH DTP04- 12554-018...
Page 219 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LIMIT SWITCH ASSEMBLY ELECTRICAL LIMIT SWITCH ASSEMBLY Tue Mar 23 01:26:32 UTC 2021...
Page 220 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LIMIT SWITCH ASSEMBLY アイテム部品番号名前数量 1430935 LIMIT SWITCH ASSEMBLY Shown 0260347 ASS'Y. LIMIT SWITCH 1430704 MNT BRKT, LIMIT SW 3040116 CONN .75 .500-.625 058501-040 SKT CAP SCREW M5-0.8 X 40MM GR12.9 ZINC 056064-005 Nut, NylockNut DIN985 M5 10.0 LIMIT SWITCH ASSEMBLY Tue Mar 23 01:26:32 UTC 2021...
Page 221 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FOOT SWITCH ELECTRICAL FOOT SWITCH Tue Mar 23 01:26:32 UTC 2021...
Page 222: Foot Switch Harness
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FOOT SWITCH アイテム部品番号名前数量 3020021 J FOOT SWITCH 3020021 Foot Switch 3020037 REPLACEMENT SWITCH, SQUARE D SWITCH, 4 POLE 3020038 REPLACEMENT SWITCH, LINEMASTER SWITCH 511633-000 FOOT SWITCH HARNESS 3040116 CONN .75 .500-.625 3040110 NUT LKG HUB .750 SAMEAS 962129 0070967 CORROSION INHIBITOR STICK- BACK 0060373 JUMPER SWITCH TERMINAL STRAP FOOT SWITCH Tue Mar 23 01:26:32 UTC 2021...
Page 223 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY ELECTRICAL UPPER CONTROL ASSEMBLY Tue Mar 23 01:26:33 UTC 2021...
Page 224 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY UPPER CONTROL ASSEMBLY Tue Mar 23 01:26:33 UTC 2021...
Page 225 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY UPPER CONTROL ASSEMBLY Tue Mar 23 01:26:33 UTC 2021...
Page 226 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY UPPER CONTROL ASSEMBLY Tue Mar 23 01:26:34 UTC 2021...
Page 227 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY アイテム部品番号名前数量 1430807 C 1-2 UPPER CONTROL ASSEMBLY Shown 660SJ DIESEL 1430806 UPPER CONTROL SHELL BOX 3030173 GP440 3049971 DEUTSCH 8-PIN BLKHD RCPT CONN- 056066-004 NUT NYLOCK DIN985 M4 8.0 ZP 14 510563-016 Bolt, SktCapScrew DIN912 M4 x 056069-004 Wshr, SteelFlatWshr M4 DIN125 3028852 BOOM TURRET AND DRIVE STICK CONTROLLER 3028854 SINGLE AXIS TELESCOPE CONTROLLER 600S/660SJ 3028853 TWO AXIS JIB AND PLATFORM JOYSTICK CONTROLLER...
Page 228 DEUTSCH 4-PIN BLKHD CON DTP04--4P-L012 3028877 GRIP CORD MULTICORD 1.43" HEX 3/4 NPT 3028880 TERMINAL BLOCK SINGLE ROW 699 GP 06 5563694 WASHER FLAT #6 YL ZN PLT 5563695 LOCKNUT HEX 6-32 ZN PLT 5563693 SCREW PAN HD 6-32 X 5/8" ZN 3028881 JUMPER RJS TYPE 601RJS-06 3014768 HARNESS, BEACON LIGHT TO GP400 3014753 SNORKEL GUARD SENSOR (CABLE, M12 X 2M L) 1431697 DECAL, MAIN CONTROL PANEL UPPR 1430807 C 3-4 UPPER CONTROL ASSEMBLY Shown 3049804 CONNECTOR 2-PIN DEUTSCH Shown RECEP 3040341 PIN CONTACT SIZE 16 16/18 Shown 3049808 LOCK WEDGE 2-PIN DEUTSCH Shown RECEP 3011601 WIRE 16GA SINGLE...
Page 229 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CONTROL ASSEMBLY アイテム部品番号名前数量 3011641 WIRE 16GA SINGLE CONDUCTOR WHT 3011801 WIRE 18GA SINGLE CONDUCTOR WHT 3220024 CONNECTOR AMP 12 PIN 1-480- 3049986 AMP SOCKET CONTACT 3220142 CONNECTOR AMP 15 PIN PLUG 3220132 CONN AMP 9-PIN PLUG 3220199 CONNECTOR AMP 3 PIN 3220025 CONNECTOR AMP 6 PIN 3040341 PIN CONTACT SIZE 16 16/18 3040650 SOCKET CONTACT -12 DEUTSCH-DEU 3220244 CONNECTOR CAP 4 PIN 3220245 PIN CONTACT...
Page 230 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA BATTERY CONTROL PANEL ASSEMBLY ELECTRICAL KUBOTA BATTERY CONTROL PANEL ASSEMBLY Tue Mar 23 01:26:35 UTC 2021...
Page 231 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 KUBOTA BATTERY CONTROL PANEL ASSEMBLY アイテム部品番号名前数量 1432155 A KUBOTA BATTERY CONTROL Shown PANEL ASSEMBLY 3020061 Battery Disconnect Nut 0161014 PLACard BATTERY OFF/ON 3040411 Alarm Buzzer 5516363 BRACKET, BATTERY DISCONNECT V2403 3041641 CIRCUIT BREAKER 40 AMP 3040252 Circuit Breaker 15AMP 3040469 RELAY SPDT 12V 30AMP SONG 5563762 SCS, BUTTON HD, M5 X 0.8 X 16 ZN PLT GR10.9 5563048 FLAT WASHER M 5 510569-005...
Page 232 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 INSTALL ENGINE CABLE ASSEMBLY ELECTRICAL INSTALL ENGINE CABLE ASSEMBLY Tue Mar 23 01:26:35 UTC 2021...
Page 233 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 INSTALL ENGINE CABLE ASSEMBLY アイテム部品番号名前数量 3014793 INSTALLATION, ENGINE CABLE Shown ASSEMBLY 3014795-01 WIRE VARIABLE LENGTH W/TERMINAL 3014795-02 WIRE VARIABLE LENGTH W/TERMINAL 3014795-03 WIRE VARIABLE LENGTH W/TERMINAL 3014795-04 WIRE VARIABLE LENGTH W/TERMINAL 3014795-05 WIRE VARIABLE LENGTH W/TERMINAL 3014795-06 WIRE VARIABLE LENGTH W/TERMINAL 3014795-07 WIRE VARIABLE LENGTH W/TERMINAL 3014795-08...
Page 234 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CABLE ASSEMBLY ELECTRICAL UPPER CABLE ASSEMBLY Tue Mar 23 01:26:36 UTC 2021...
Page 235 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 UPPER CABLE ASSEMBLY アイテム部品番号名前数量 511612-000 UPPER CABLE ASSY Shown 3049829 CONNECTOR 8-PIN PLUG 3049842 LOCK WEDGE 8-PIN PLUG 3040342 SOCKET CONTACT SIZE 16 16/18GA 3090028 BOOT 8 PIN PLUG DT8S-BT 3014736 20 GA 2COND CABLE (27432MM - 1080 IN) 3014737 18GA 7 COND CABLE (27432MM - 1080 IN) UPPER CABLE ASSEMBLY Tue Mar 23 01:26:36 UTC 2021...
Page 236 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOM TURRET / DRIVE CONTROLLER 600S / 660SJ ELECTRICAL BOOM TURRET / DRIVE CONTROLLER 600S / 660SJ Tue Mar 23 01:26:36 UTC 2021...
Page 237 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BOOM TURRET / DRIVE CONTROLLER 600S / 660SJ アイテム部品番号名前数量 3028852 BOOM TURRET AND DRIVE Shown STICK CONTROLLER 3028852 BOOM TURRET AND DRIVE STICK CONTROLLER 3220267 KNOB 3220268 BOOT JS8 10MM SHAFT 3220269 GASKET JS ENCLOSURE BOOM TURRET / DRIVE CONTROLLER 600S / 660SJ Tue Mar 23 01:26:36 UTC 2021...
Page 238 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TWO AXIS, JIB / PLATFORM CONTROLLER ELECTRICAL TWO AXIS, JIB / PLATFORM CONTROLLER Tue Mar 23 01:26:36 UTC 2021 4-10...
Page 239 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 TWO AXIS, JIB / PLATFORM CONTROLLER アイテム部品番号名前数量 3028853 TWO AXIS JIB AND PLATFORM Shown JOYSTICK CONTROLLER 600S/660SJ 3028853 TWO AXIS JIB AND PLATFORM JOYSTICK CONTROLLER 600S/660SJ 3220267 KNOB 3220270 GASKET B9 1/8" THICK 3220271 BOOT JS9 TWO AXIS, JIB / PLATFORM CONTROLLER Tue Mar 23 01:26:36 UTC 2021 4-10...
Page 240 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SINGLE AXIS TELESCOPE CONTROLLER 600S / 660SJ ELECTRICAL SINGLE AXIS TELESCOPE CONTROLLER 600S / 660SJ Tue Mar 23 01:26:36 UTC 2021 4-11...
Page 241 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SINGLE AXIS TELESCOPE CONTROLLER 600S / 660SJ アイテム部品番号名前数量 3028854 SINGLE AXIS TELESCOPE Shown CONTROLLER 600S/660SJ 3028854 SINGLE AXIS TELESCOPE CONTROLLER 600S/660SJ 3220267 KNOB 3220270 GASKET B9 1/8" THICK 3220271 BOOT JS9 SINGLE AXIS TELESCOPE CONTROLLER 600S / 660SJ Tue Mar 23 01:26:36 UTC 2021 4-11...
Page 242 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CABLE HARNESS KIT KUBOTA ELECTRICAL CABLE HARNESS KIT KUBOTA Tue Mar 23 01:26:37 UTC 2021 4-12...
Page 243: Lower Cable Assembly
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 CABLE HARNESS KIT KUBOTA アイテム部品番号名前数量 1432141 A CABLE HARNESS KIT KUBOTA Shown 3014793 INSTALLATION, ENGINE CABLE ASSEMBLY 3014780 HARNESS, MAIN MAINFOLD BLOCK 3014769 HARNESS, SOLENOID DIN TO DT PLUG 3014787 ASSY HORN 3014788 LIGHT, AMBER BEACON 3014781 HARNESS LWR CNTRL BOX TO AMBR 511612-000 UPPER CABLE ASSY 3014764 HARNESS, ELEV SWITCH DT06- 3014763 HARNESS, LWR CTL TO LMT SW 3014765...
Page 244 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HARNESS, LOWER CONTROL TO PRESSURE SWITCH ELECTRICAL HARNESS, LOWER CONTROL TO PRESSURE SWITCH Tue Mar 23 01:26:37 UTC 2021 4-13...
Page 245: Harness, Lower Control To Pressure Switch
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HARNESS, LOWER CONTROL TO PRESSURE SWITCH アイテム部品番号名前数量 3014762A LOWER CONTROL TO PRESSURE Shown SWITCH HARNESS 3028872 CONNECTOR, 3-WAY PLUG GREY 1 3049888 CONNECTOR 4-PIN HARNESS, LOWER CONTROL TO PRESSURE SWITCH Tue Mar 23 01:26:37 UTC 2021 4-13...
Page 246 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CABLE ASSEMBLY ELECTRICAL LOWER CABLE ASSEMBLY Tue Mar 23 01:26:38 UTC 2021 4-14...
Page 247 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CABLE ASSEMBLY アイテム部品番号名前数量 511611-000 A LOWER CABLE ASSEMBLY Shown 100338-000 DEUTSCH PLUG HDP 26-24- 21SN 100338-005 DEUTSCH BOOT HD-3024BT 068764-000 SEAL PLUG DEUTSCH 114017 3010009 CABLE 18GA/12 CONDUCTOR 3011203 CABLE 12GA/3 CONDUCTOR WIRE SO 3040341 PIN CONTACT SIZE 16 16/18 3040650 SOCKET CONTACT -12 DEUTSCH-DEU LOWER CABLE ASSEMBLY Tue Mar 23 01:26:38 UTC 2021 4-14...
Page 248 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE HARNESS ELECTRICAL SELECTOR VALVE HARNESS Tue Mar 23 01:26:38 UTC 2021 4-15...
Page 249 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SELECTOR VALVE HARNESS アイテム部品番号名前数量 511625-000 SELECTOR VALVE HARNESS Shown 3049803 CONNECTOR 2-PIN DEUTSCH PLUG 3049807 LOCK WEDGE 2-PIN DEUTSCH PLUG 3040342 SOCKET CONTACT SIZE 16 16/18GA 3011802 CABLE 18GA/2 CONDUCTOR Shown WIRE 18/2 TYPE SJOBLACK JACKETCABL SELECTOR VALVE HARNESS Tue Mar 23 01:26:38 UTC 2021 4-15...
Page 250 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FOOT SWITCH HARNESS ELECTRICAL FOOT SWITCH HARNESS Tue Mar 23 01:26:38 UTC 2021 4-16...
Page 251 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 FOOT SWITCH HARNESS アイテム部品番号名前数量 511633-000 B FOOT SWITCH HARNESS 3220108 CONNECTOR 4-PIN 12GA PLUG 3220109 WEDGE LOCK 4-PIN 3040650 SOCKET CONTACT -12 DEUTSCH-DEU 3011204 CABLE 12GA/3 CONDUCTOR WIRE 3044853 TERM R8I 12/10 3220161 BOOT DEUTSCH/LADD FOOT SWITCH HARNESS Tue Mar 23 01:26:38 UTC 2021 4-16...
Page 252 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BEACON LIGHT HARNESS ELECTRICAL BEACON LIGHT HARNESS Tue Mar 23 01:26:39 UTC 2021 4-17...
Page 253 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 BEACON LIGHT HARNESS アイテム部品番号名前数量 3014765 A BEACON LIGHT HARNESS 514404-001 FLASHING BEACON BLUE 3028878 DEUTSCH BEACON LIGHT HARNESS Tue Mar 23 01:26:39 UTC 2021 4-17...
Page 254 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL TO LIMIT SWITCH HARNESS ELECTRICAL LOWER CONTROL TO LIMIT SWITCH HARNESS Tue Mar 23 01:26:39 UTC 2021 4-18...
Page 255 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL TO LIMIT SWITCH HARNESS アイテム部品番号名前数量 3014763 A LOWER CONTROL TO LIMIT Shown SWITCH HARNESS 3028875 CNCTR 4WAY PLUG GREY DT04- 3049888 CONNECTOR 4-PIN LOWER CONTROL TO LIMIT SWITCH HARNESS Tue Mar 23 01:26:39 UTC 2021 4-18...
Page 256 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX TO AMBER LIGHT HARNESS ELECTRICAL LOWER CONTROL BOX TO AMBER LIGHT HARNESS Tue Mar 23 01:26:40 UTC 2021 4-19...
Page 257 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 LOWER CONTROL BOX TO AMBER LIGHT HARNESS アイテム部品番号名前数量 3014781 A LOWER CONTROL BOX TO Shown AMBER LIGHT HARNESS 3028879 CNCTR 2WAY PLUG GREY DT04- 3028878 DEUTSCH LOWER CONTROL BOX TO AMBER LIGHT HARNESS Tue Mar 23 01:26:40 UTC 2021 4-19...
Page 258: Elevation Switch To Dt06-4S Harness
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ELEVATION SWITCH TO DT06-4S HARNESS ELECTRICAL ELEVATION SWITCH TO DT06-4S HARNESS Tue Mar 23 01:26:40 UTC 2021 4-20...
Page 259 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ELEVATION SWITCH TO DT06-4S HARNESS アイテム部品番号名前数量 3014764 A ELEVATION SWITCH TO DT06- Shown 4S HARNESS 3028869 SWITCH SAFETY SPDT SHMRSL PS116 3049888 CONNECTOR 4-PIN ELEVATION SWITCH TO DT06-4S HARNESS Tue Mar 23 01:26:40 UTC 2021 4-20...
Page 260: Horn Assembly
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HORN ASSEMBLY ELECTRICAL HORN ASSEMBLY Tue Mar 23 01:26:40 UTC 2021 4-21...
Page 261 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HORN ASSEMBLY アイテム部品番号名前数量 3014787 A HORN ASSEMBLY 3028879 CNCTR 2WAY PLUG GREY DT04- 3040127 HORN 12VDC HORN ASSEMBLY Tue Mar 23 01:26:40 UTC 2021 4-21...
Page 262 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AMBER RUNNING LIGHT HARNESS ELECTRICAL AMBER RUNNING LIGHT HARNESS Tue Mar 23 01:26:41 UTC 2021 4-22...
Page 263: Amber Running Light Harness
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 AMBER RUNNING LIGHT HARNESS アイテム部品番号名前数量 3014788 A AMBER RUNNING LIGHT HARNESS 514404-000 BEACON WITH GUARD ANBER FLASHING 3028878 DEUTSCH AMBER RUNNING LIGHT HARNESS Tue Mar 23 01:26:41 UTC 2021 4-22...
Page 264 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SOLENOID DIN TO DT PLUG HARNESS ELECTRICAL SOLENOID DIN TO DT PLUG HARNESS Tue Mar 23 01:26:41 UTC 2021 4-23...
Page 265: Solenoid Din To Dt Plug Harness
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 SOLENOID DIN TO DT PLUG HARNESS アイテム部品番号名前数量 3014769 A SOLENOID DIN TO DT PLUG Shown HARNESS 3028882 VALVE CONNECTOR, 4-POS., TYPE A DIN 43650 3028879 CNCTR 2WAY PLUG GREY DT04- 3028883 CABLE, 16 AWG, 2 COND. O.D. .417'' SOLENOID DIN TO DT PLUG HARNESS Tue Mar 23 01:26:41 UTC 2021 4-23...
Page 266 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN MANIFOLD HARNESS 660SJ GEN 1 ELECTRICAL MAIN MANIFOLD HARNESS 660SJ GEN 1 Tue Mar 23 01:26:42 UTC 2021 4-24...
Page 267: Main Manifold Harness 660Sj Gen
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 MAIN MANIFOLD HARNESS 660SJ GEN 1 アイテム部品番号名前数量 3014780 A MAIN MANIFOLD HARNESS Shown 660SJ GEN 1 015790-012 CONNECTOR, 24-PIN 015790-013 BOOT BLACK 3014752 CABLT, 24 COND, 18GA 3049803 CONNECTOR 2-PIN DEUTSCH PLUG 3049807 LOCK WEDGE 2-PIN DEUTSCH PLUG 3040342 SOCKET CONTACT SIZE 16 16/18GA 3049888 CONNECTOR 4-PIN 3049890 LOCK WEDGE 4-PIN MAIN MANIFOLD HARNESS 660SJ GEN 1...
Page 268 When raising a portion of the machine, be sure that adequate blocking is properly positioned. Do Snorkel recommends that you make additional copies of not depend solely on the lifting device to hold and the preventative inspection and maintenance checklists secure weight.
Page 269 Parts should be thoroughly inspected before restoring Clean surrounding areas, as well as the opening and to service at the time of reassembly. Burrs, nicks or fittings before disconnecting air or oil lines. As soon as a scratches may be removed from machines surfaces by line or component is disconnected, cap or cover all open- honing or polishing with a #600 crocus cloth, followed by ings to prevent the entry of dirt or foreign materials.
Page 270 Operating controls – Boom functions, drive, brakes, etc. Proper operation Emergency stop and emergency power Shuts off upper controls/proper operation Sounds when activated Horn Snorkel Guard Proper operation In place and readable Placards and Decals Performed by: Date: 660SJ Maintenance – 3...
Page 271 Maintenance – 4 660SJ...
Page 272 Frequent Inspection and Maintenance – Every 90 Days or 150 Hours Item Procedure Information Chassis Check for damage and cracked welds Structural Steering cylinder snap rings Verify that all fasteners are in place and are tight Oscillating axle lock cylinders Verify that all fasteners are in place and fasteners Steering linkage...
Page 273 Frequent Inspection and Maintenance – Every 90 Days or 150 Hours Item Procedure Information Lower Controls Check for proper operation Control switch in the lower controls With selector in the lower position controls position, upper controls do not work Check for proper operation Station selector switch in the upper With selector in the upper controls position...
Page 274 Frequent Inspection and Maintenance – Every 90 Days or 150 Hours Item Procedure Information Platform Check for damage and cracked welds Structural Check for proper operation Entry Gate Hydraulic tubes and hoses Check for leaks, wear, and damage Slave level cylinder pin caps and Verify that all fasteners are in place and are tight tie wire...
Page 275 Frequent Inspection and Maintenance – Every 90 Days or 150 Hours Item Procedure Information Engine Charging system Check for proper operation Air filter Check for wear and damage Check for proper operation Hour meter Belts and hoses Check for wear and damage Hydraulic pump Check for proper operation Battery terminals...
Page 276 Frequent Maintenance – Every 90 Days or 150 Hours Item Procedure Information Perform maintenance as per schedule Retain copy of checklist Daily maintenance Retain copy of checklist Preventive inspection Perform inspection, complete form maintenance checklist Placards and decals Inspect using drawing and parts listing in Replace any missing or unreadable decals/placards inspection...
Page 277 Maintenance – 10 660SJ...
Page 278 Annual Maintenance – Every 500 Hours Item Procedure Information 90 day or 150 hour Retain copy of checklist Perform maintenance per schedule maintenance Hydraulic oil reservoir Clean and replace fluid Dexron III ATF Hydraulic return filter After first 50 hours, then at Replace recommended interval Hydraulic high pressure filter...
Page 279 Maintenance – 12 660SJ...
Page 280 Major Repairs Date Part Number Part Description Repair Performed 660SJ Maintenance – 13...
Page 281 Maintenance – 14 660SJ...
Page 282 Local oil suppliers ing lubricant as outlined in the maintenance schedule. can generally furnish this information. If questions still remain, contact Snorkel Customer Ser- Swing Drive Swing drive – Item 4. To check oil level, remove check vice Department for further information.
Page 283 Hydraulic Oil Return Filter Danger Return filter – Item 9. Tthe hydraulic oil return filter is Lead-acid batteries produce flammable and explo- mounted inside of the hydraulic oil reservoir. sive gases. Never allow smoking, flames or sparks around batteries. Lead-acid batteries contain sulfu- The filter element is a throw-away type filter and ric acid which will damage eyes or skin on contact.
Page 284 get the job done, no matter how long it tries. An undersized batteries. The correct approach is to oversized charger will cause excess gassing and install adequate battery capacity. If this is impossible heat that could possibly result in a battery meltdown because of lack of space in the battery compartment and/or explosion.
Page 285 Maintenance – 18 660SJ...
Page 286 Fastener Torque Chart Bolt SAE Grade SAE Grade SAE Grade SAE Grade Grade 1 or 2 Marking Minimum Medium Indeterminate Commercial Commercial Definition Quality Quality Quality Medium Medium Carbon Medium Carbon Carbon Steel Alloy Steel Material Carbon Steel Quenched and Quenched and Steel Tempered...
Page 287 Fastener Torque Chart – Metric System Capscrew Grade 8.8 Grade 10.9 In-LBS In-LBS FT-LBS FT-LBS In-LBS In-LBS FT-LBS FT-LBS Clamp Clamp Size Lubed Lubed Load (lb) Lubed Lubed Load (lb) M4 - 0.7 1,173 M5 - 0.8 1,394 1,895 M6 - 1.0 1,971 2,686 M8 - 1.25...
Page 288 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ELECTRIC SCHEMATIC SCHEMATICS ELECTRIC SCHEMATIC Tue Mar 23 01:26:42 UTC 2021...
Page 289: Electric Schematic
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ELECTRIC SCHEMATIC ELECTRIC SCHEMATIC Tue Mar 23 01:26:43 UTC 2021...
Page 290 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 ELECTRIC SCHEMATIC アイテム部品番号名前数量 1432222 B ELECTRIC SCHEMATIC Shown ELECTRIC SCHEMATIC Tue Mar 23 01:26:43 UTC 2021...
Page 291: Hydraulic Schematic Kubota
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC SCHEMATIC KUBOTA SCHEMATICS HYDRAULIC SCHEMATIC KUBOTA Tue Mar 23 01:26:44 UTC 2021...
Page 292 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 HYDRAULIC SCHEMATIC KUBOTA アイテム部品番号名前数量 1432231 B HYDRAULIC SCHEMATIC Shown HYDRAULIC SCHEMATIC KUBOTA Tue Mar 23 01:26:44 UTC 2021...
Page 293: Beacon Light Harness
660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 4-20 7 PORT ROTARY MANIFOLD ASSEMBLY EMERGENCY POWER UNIT WUXI DELI APRIL 3-11 2016 AND AFTER 3-13 AIR CLEANER 2-18 ENGINE SWING OUT ASSEMBLY 2-14 AMBER RUNNING LIGHT HARNESS 4-22 EXTEND CYLINDER ASSEMBLY 2-27 AXLE LOCK CYL EXTEND CYLINDER ROSENBOOM...
Page 294: Lower Control To Limit Switch Harness
4-14 660SJ 4-11 LOWER CONTROL BOX ASSEMBLY SJ SLAVE LEVEL CYLINDER ROSENBOOM 3-23 DIESEL SNORKEL GUARD ASSEMBLY 2-33 LOWER CONTROL BOX CUMMINS 660SJ 4- SOLENOID DIN TO DT PLUG HARNESS 4-23 STEER LINK ASSEMBLY LOWER CONTROL BOX TO AMBER LIGHT...
Page 295 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 0084677 2-35 0060373 010148-001 0070483 2-12 010149-000 0070540 2-43 010178-001 2-12 0070541 2-43 010178-003 2-12 0070967 011239-010 2-1, 2-3 0071425 2-43 011261-000 2-20 0071793 2-43 0113450 2-32 0071926 2-43 0113519 2-33 0071927 2-43 0113528...
Page 296 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 029925-000 4-1, 4-2, 4-5 056069-005 4-1, 4-2, 4-5 0420111 2-28 056069-006 2-12, 2-33, 2-39, 2-40, 2-41, 2-42, 4-1, 4-2 0420111 H 3-24 056069-008 2-13, 2-34, 2-38, 3-16 0420113 3-25 056069-010 2-10, 2-12, 2-12, 2-25, 2-26, 2-34, 2-37, 2- 0420114 2-28 39, 2-40, 2-41, 2-42...
Page 297 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 100432-027 2-10, 3-11, 3-16 104673-110 2-15 100432-029 2-10 104673-111 2-15 100433-005 3-16, 3-27 104673-112 2-15 100434-002 2-11, 2-16, 2-28, 3-4, 3-11, 3-16 104673-113 2-15 100434-008 2-7, 2-11, 2-27, 3-11 104673-114 2-15 100434-013 2-3, 2-3, 2-4, 2-4, 2-7, 3-4, 3-7, 3-29 104673-115 2-15...
Page 298 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 106568-100 2-31 106776-000 2-12 106717-001 106793-000 106717-001 A 106794-000 106717-003 106815-010 3-22 106718-001 106964-001 2-3, 2-4 106751-101 11354-000 2-3, 2-4, 3-1, 3-29 106755-000 11355-002 3-1, 3-29 106755-000 A 3-10 11355-006 2-3, 2-4, 3-1 106755-100 3-10 11355-012...
Page 299 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 1430549 2-17 1430744 2-10 1430550 2-17 1430748 2-12 1430551 2-17 1430748 B 2-10 1430552 2-17 1430753 2-34 1430553 2-17 1430756 2-34 1430595 3-1, 3-29 1430760 2-34 1430611 1430761 2-35 1430627 1430765 2-34 1430666 2-27...
Page 300 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 1430852 2-31 1430961 3-1, 3-29 1430860 2-28 1430963 3-1, 3-29 1430860 A 2-29 1430964 1430864 2-43, 4-1 1430965 3-1, 3-29 1430866 1430966 3-1, 3-29 1430867 2-26 1430967 3-1, 3-29 1430868 2-25 1430968 3-1, 3-29 1430895...
Page 301 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 1431079 1431567 1431145 2-12 1431574 2-16 1431148 2-12 1431575 2-16 1431167 A 1431576 2-16 1431299 1431577 2-16 1431299 B 1431643 3-1, 3-29 1431303 1431648 2-43 1431368 1431664 2-28 1431374 1431685 1431374 A 2-14 1431686 1431375...
Page 302 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 1431898 2-37 1432061 3-1, 3-1 1431898A 2-39 1432062 1431899 2-37 1432064 2-30 1431899B 2-40 1432065 B 2-32 1431912 2-41 1432066 2-32 1431922 2-42 1432066 A 2-30 1431933 2-38 1432072 A 3-11 1431946 2-40 1432076...
Page 303 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 1434170 2-27 3014737 1460964 3-29 3014752 4-24 150448 2-43 3014753 161014 2-43 3014762 4-12 190989 2-43 3014762A 4-13 2500035 2-29 3014763 4-12 2500047 2-26, 2-27 3014763 A 4-18 2500051 3-25 3014764 4-12 2500060 2-29...
Page 304 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 3014795-08 3030173 3014795-09 3030174 4-1, 4-2 3020013 3030181 4-1, 4-2 3020015 3030188 2-32 3020016 4-1, 4-2 3040069 4-1, 4-2 3020018 3040110 3020021 2-32, 4-4 3040116 2-32, 4-3, 4-4 3020021 J 3040127 4-21 3020037 3040174...
Page 305 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 3220024 4-1, 4-2, 4-5 5059725 2-16 3220025 5059726 2-16 3220089 5075303 3220108 4-16 5075306 3-16 3220109 4-16 5076533 2-37 3220132 508247-010 2-37 3220142 4-1, 4-2, 4-5 5089682 2-19 3220161 4-16 510561-006 2-37 3220163 4-1, 4-2...
Page 306 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 511335-000 2-25 511621-000 511336-000 2-25 511621-000 C 511339-000 3-16 511624-000 2-27 511347-000 2-26 511625-000 4-12, 4-15 511356-000 3-16 511626-000 2-26 511384-500 2-26 511627-000 2-26 511389-000 2-26 511628-000 2-25, 2-26 511390-000 2-26 511629-000 2-26 511396-000...
Page 307 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 5560014 2-34 5563555 2-16, 2-32 5560033 2-30, 2-32, 2-35 5563556 2-1, 2-14, 2-16, 2-28 5560039 2-27 5563559 5560080 2-12 5563563 2-9, 2-31 5560216 5563577 2-9, 2-28 5560256 2-27 5563589 2-7, 2-16 5560283 5563590 2-16...
Page 308 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 5569917 2-12 6091598 3-17 5580016 6091794 3-22 5593018 2-33 6091802 3-15 561196 3-24 6091812 3-12 562386 6091813 3-12, 3-12 5663509 2-31, 2-32 6091814 3-12, 3-12 569295 2-43 6091815 3-17 6010115 3-15 6091816 3-17 6019089...
Page 309 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 6091843 3-28 7030170 2-43 6091844 3-28 7030171 2-43 6091845 3-20 7030172 2-43 6091846 3-20 7030173 2-43 6091847 2-19 7119925 2-16 6091848 2-19 7119926 2-16 6091849 2-19 7220055 2-2, 3-6 6091850 2-19 7220056 2-2, 3-6 6091851...
Page 310 660SJ OSCILLATING AXLE PARTS MANUAL S/N 000003 THROUGH 000017 8010422 2-2, 3-6 970629 2-35 8010428 2-2, 3-6 971009 2-27 8010429 2-2, 3-6 972479 2-26, 2-30, 2-32 8010430 2-2, 3-6 978419 3-25 8010431 2-2, 3-6 984069 2-33 8010432 2-2, 3-6 984209 2-25 8010433 2-2, 3-6...

This manual is also suitable for:

000017 series 660sj

Snorkel 000003 Series Repair Parts Manual

Quick Links

Need help?

Questions and answers

Related Manuals for Snorkel 000003 Series

Summary of Contents for Snorkel 000003 Series

This manual is also suitable for:

Table of Contents