Table Of Contents - Burnham V7 SERIES Installation & Operating Instructions Manual

Table of Contents

Important Information2
Table Of Contents3
General Information3
Dimensional Data3
V72 Thru V79 Water Boiler Without Tankless Heater (Wb) - Diagrams3
V73 Thru V79 Water Boiler With Tankless Heater (Wbt)4
V73 Thru V79 Steam Boiler With Or Without Tankless Heater ("Sbt"/"Sb")4
V713 And V714 Packaged Water Boiler Less Tankless Heater (Wb)5
V713 And V714 Packaged Water Boiler With Tankless Heater (Wbt)5
Front And Side Views Of Boiler6
Boiler Location6
Basement Installation6
Provide Service Clearance6
Provide Air Supply And Ventilation6
Knockdown Boiler Assembly7
Removal Of Bare Boiler From Skid7
Test Boiler For Leaks7
Boiler Canopy Installation7
Boiler Tapping Locations And Usage (Knockdown Boilers Only)8
Install Flush Jacket9
Jacket Front Panel9
Jacket Left Side Panel9
Knockdown Boiler Jacket Assembly - Diagram9
Install Oil Burner10
Install Steam Boiler Trim And Controls10
Install Water Trim And Controls11
Float-Type Low Water Cutoff Installation11
Limit Installation For Probe Lwco Equipped Boilers11
Remove Crate (Packaged Boilers)12
Installation Instructions12
Inspect Combustion Target Wall And Combustion Chamber Liner12
Connect Supply And Return Piping To Heating System12
Guidelines To Follow When Piping The Tankless Heater14
Connect Tankless Heater Piping14
Flow Regulation14
Tempering Of Hot Water14
Tankless Heater Data15
Flushing Of Heater15
Hard Water15
Install Smokepipe15
Install Electric Wiring16
Fuel Units And Oil Lines16
Recommended Smokepipe Arrangement And Chimney Requirements16
Proper And Improper Locations Of Draft Regulator16
Single-Stage Units (3450 Rpm) - Two-Pipe Systems17
Two-Stage Units (3450 Rpm) - Two-Pipe Systems17
Boiler Sequence Of Operation With Probe Lwco18
Wiring Diagrams18
Boiler Sequence Of Operation With Float Lwco19
Sequence Of Opration20
Operating And Service Instructions21
Fill Heating System With Water21
Lubrication21
Setting Controls21
Remove Gun Assembly22
Adjust Oil Burner Before Starting22
Start Oil Burner22
Adjust Oil Pressure/Other Adjustments22
Cad Cell Location And Service23
Flame Failure23
Check For Clean Cut Off Of Burner24
Test Controls24
Cad Cell Test24
Maintenance Of Low Water Cutoff Devices24
Boiler And System Cleaning Instructions For Trouble Free Operation25
Float Type Low Water Cut-Off25
Steam Boilers Cleaning25
Water Boilers Cleaning26
Hints On Combustion27
Nozzles27
Flame Shape27
Fuel Leaks/Air Leaks27
Attention On Boiler While Not In Operation28
Frequent Water Addition28
Boiler Cleaning29
Aquastat Switching Action Within L8124C Control29
Aquastat Switching Action Within L8148A Controls29
Adjustable Differential29
Clean The Flueways30
Clean The Firebox30
After Cleaning30
Reassemble Boiler30
Repair Parts31
Bare Boiler Assembly Diagram32
Bare Boiler Assembly33
V713 And V714 Flush Jacket Components37
V72 Thru V79 Flush Jacket Components39
V73 Thru V79 Steam Boilers - Trim And Controls Diagram40
V72 Thru V79, V713 And V714 Water Boilers - Trim And Controls Diagram42
Beckett Afg Burner Diagrams44
Burner Specifications46