Weil-McLain GOLD CGa Manual page 31

GOLD CGa Gas-Fired Water Boiler — Boiler Manual
6b
Start-up — operate boiler
Start the boiler
jacket door and note the gas valve manufacturer
and model number. Use only the lighting/operat-
ing instruction which applies to this gas valve (see
the boiler provides the same information.)
Check system and boiler
1.
down boiler and repair immediately.
2.
the system will interfere with circulation and cause
heat distribution problems and noise.
3.
deterioration from corrosion, physical damage or
good condition, with no obstructions, and there are
no openings into the chimney.
4.
procedure of Section
5.
procedure in Section
6c
Start-up — if boiler doesn't start . . .
Check for:
1. Loose connections, blown fuse or
3. Thermostat set below room tem-
Part Number 550-101-009/0107
to start the boiler. Remove boiler
, page 30). (The lighting instruction label on
if boiler fails to start.
using manual vents. Air in
thoroughly for signs of
for gas odor following the
of this manual.
per Section . Perform check-out
and fill in the
on the same page.
(continued)
from
If found, shut
5. Incoming gas pressure less than:
6. If none of the above corrects the problem, refer to
Section of this manual.
ing ,
will reduce boiler life. Minerals
can build up in sections, reduc-
ing heat transfer, overheating
cast iron, and causing section
failure.
If you discover evidence of any
gas leak, shut down the boiler
at once. Find the leak source
with bubble test and repair im-
again until corrected. Failure to
comply could result in severe
personal injury, death or sub-
stantial property damage.
in boiler system. Severe damage
to boiler will occur, resulting in
substantial property damage.
31