Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Contents Introduction ......................4 Software version ...................... 4 Definitions ........................ 5 Safety regulations ....................7 Warning against unintended start ................
Page 8
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA DC bus connection ....................72 High-voltage relay ....................72 Electrical installation, control cables ............... 72 Switches 1-4 ......................
Page 9
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Electrical installation of the relay card ..............168 All about VLT 8000 AQUA ................. 170 Status messages ....................
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8000 AQUA Instruction Manual Software version: 1.5x This Instruction Manual can be used for all VLT 8000 AQUA, AFDs (Adjustable Frequency Drives) with software version 1.5x.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Definitions A stop command gi v en as a group 1 command Definitions are gi v en in alphabetical order.
Page 12
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA The control panel is detachable and may, as an alternati v e, be installed up to 10 feet away from the AFD, i.e.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA The voltage of the adjustable frequency applications ETR provides Class 20, over-load ® dri v e is dangerous whenever the equipment protection in accordance with the NEC is connected to line.
Page 14
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA It is the responsibility of the user or the person installing the VLT to provide proper...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Introduction to Instruction Manual This Instruction Manual is di v ided into four sections with information about VLT 8000 AQUA.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Control principle An AFD rectifies AC voltage from line into DC voltage, The motor is thus supplied with variable voltage and...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA AEO - Automatic Energy Optimization AEO is intended for use on Variable Torque single motor applications. Normally, the U/f characteristics have to be set on the basis of the expected load at different frequencies.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Example of application - Constant pressure regulation in water supply system The demand for water from waterworks varies considerably during the course of a day. In the night, practically no water is used, while in the morning and in the evening the consumption is high.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA PC software and serial communication MCT 10 Set-up Software Danfoss offers various options for serial MCT 10 has been designed as an easy-to-use communication.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA units, such as sensors and actuators, to the controls Modbus RTU by means of a two-conductor cable.
Page 21
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Accessories IP 20 bottom cover Application option MG.80.A7.22 - VLT is a registered Danfoss trademark...
Page 22
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Type Description Ordering no. IP 4x top cover IP Option, VLT type 8006-8011 380-480 V compact...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8000 AQUA is available with an integral serial communication option or application option. Ordering numbers for the indi v idual VLT types with integrated options can be seen from the relevant manuals or instructions.
Page 24
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Ordering numbers, LC filter modules Line supply 3 x 200 - 240 V LC filter...
Page 25
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA LC filters VLT 8006-8011 380 - 480 V The drawing on the left gi v es the measurements of IP 20 LC filters for the above-mentioned power range.
Page 26
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA LC filters VLT 8006-8032, 200 - 240 V / Max. motor cable length: 8016-8062 380 - 480 V...
Page 27
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA LC filter VLT 8042-8062 200-240 V / Max. motor cable length: 8072-8600 380 - 480 V...
Page 28
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Harmonic filter can offer two advanced harmonic filters AHF05 Harmonic currents do not directly affect the electricity...
Page 29
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 440-480V, 60Hz Typical Motor Used Danfoss ordering number VLT 8000 AHF,N AHF 005 AHF 010...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Unpacking and ordering an AFD Hardware variant If you are in doubt as to which AFD you have...
Page 31
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 200-240 V Typecode Position in string 9-10 11-13 11-13 11-13 11-13 14-15 14-15 16-17 16-17 16-17 4.0 kW/5.0 HP...
Page 32
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 525-600 V Typecode Position in string 9-10 11-13 11-13 11-13 14-15 16-17 1.1 kW/1.5 HP 8002 1.5 kW/2.0 HP...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA TYPE CODE Table/Ordering form MG.80.A7.22 - VLT is a registered Danfoss trademark QP Id: VM207...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA General technical data Line supply (L1, L2, L3): Supply voltage 200-240 V units ............... 3 x 200/208/220/230/240 V ±10% Supply voltage 380-480 V units ..............
Page 35
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Reliable galvanic isolation: All digital inputs are galvanically isolated from the supply voltage (PELV). In addition, the digital inputs can be isolated from the other terminals on the control card by connecting an external 24 V DC supply and opening switch 4.
Page 36
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Reliable galvanic isolation: All digital and analog outputs are galvanically isolated from the supply voltage (PELV) and other high-voltage terminals.
Page 37
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Resolution on output frequency ......................±0.003 Hz System response time ..........................3 msec. Speed, control range (open loop) ..................1:100 of synchro. speed Speed, accuracy (open loop) ................
Page 38
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA • The adjustable frequency dri v e is protected against short-circuiting on motor terminals U, V, W.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 200 - 240 V According to international requirements VLT type...
Page 40
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 200 - 240 V According to international requirements VLT type...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 380 - 480 V According to international requirements VLT type...
Page 42
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 380 - 480 V According to international requirements VLT type...
Page 43
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 380 - 480 V According to international requirements VLT type...
Page 44
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 380 - 480 V According to international requirements VLT type...
Page 45
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 380 - 480 V According to international requirements VLT type 8450...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 525 - 600 V According to international requirements VLT type...
Page 47
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 525 - 600 V According to international requirements 8016...
Page 48
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Technical data, line supply 3 x 525 - 600 V According to international requirements 8100...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Fuses UL compliance To comply with UL/cUL approvals, pre-fuses according to the table below must be used.
Page 50
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 525-600 V Bussmann SIBA Littel fuse Ferraz-Shawmut 8002 KTS-R3 5017906-004 KLS-R003 A6K-3R 8003 KTS-R4 5017906-004...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Mechanical dimensions All the below listed measurements are in mm/in. VLT type aa/bb Type IP 00/Chassis 200 - 240 V 8042 - 8062 800/31.5...
Page 52
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Mechanical dimensions All the below listed measurements are in mm./in VLT Type aa/bb* Type IP 00/Chassis 525 - 600 V 8100 - 8150 800/31.55...
Page 53
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Mechanical dimensions MG.80.A7.22 - VLT is a registered Danfoss trademark QP Id: VM207 Active: 03/09/2013...
Page 54
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Mechanical dimensions (cont.) Type H, IP 20, IP 54 Type I, IP 00 Type J, IP 00, IP 21, IP 54 MG.80.A7.22 - VLT is a registered Danfoss trademark...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Mechanical installation Please pay attention to the requirements that apply to integration and field mounting kit, see the below list.
Page 56
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Installation of VLT 8006-8352 All AFDs must be installed in a way that Side by side/flange by flange ensures proper cooling.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Installation of VLT 8450-8600 380-480 V Compact IP 00/Chassis, IP 20/NEMA 1 and IP 54/NEMA 12...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA General information about electrical installation example, has a lower HF impedance than a round conductor for the same conductor cross-section C...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA aluminium or iron. Shield armor intended for NOTE mechanical protection, for example, is not suitable.
Page 60
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8016 - 8022 200 - 240 V VLT 8032 - 8042 525 - 600 V...
Page 61
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8016 - 8032 200 - 240 V Compact IP 54/NEMA 12 VLT 8006 - 8011 380 - 480 V...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA High voltage test EMC-correct electrical installation A high voltage test can be carried out by...
Page 63
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA This however does not apply to IP54/NEMA 12 units (enclosure) together with an output contactor and is...
Page 64
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA MG.80.A7.22 - VLT is a registered Danfoss trademark QP Id: VM207 Active: 03/09/2013 Page 64 of 208...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Earthing/Grounding of shielded/armored control cables Correct earthing/grounding Generally speaking, control cables must be shielded/ Control cables and cables for serial communication...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Electrical installation, enclosures Compact IP 54/NEMA 12 VLT 8006-8011, 380-480 V Compact IP 20/NEMA 1...
Page 67
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8100-8150, 525-600 V Compact IP 00/Chassis VLT 8042-8062, 200-240 V VLT 8100-8150, 525-600 V...
Page 68
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Compact IP 20/NEMA 1 VLT 8102-8122, 380-480 V IP 00/Chassis VLT 8200-8300, 525-600 V Compact IP 54/NEMA 12...
Page 69
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA IP 54/NEMA 12, IP 21/NEMA 1 VLT 8152-8352, 380-480 V IP 54/NEMA 12, IP 21/NEMA 1 with disconnect...
Page 70
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Compact IP 00/Chassis, IP 20/NEMA 1, and IP 54/NEMA 12 VLT 8450-8600, 380-480 V MG.80.A7.22 - VLT is a registered Danfoss trademark...
Page 71
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Electrical installation, power cables IP 20/NEMA 1 VLT 8006-8032, 200-240 V VLT 8016-8122, 380-480 V...
Page 72
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Electrical installation, power cables IP 00/Chassis and IP 20/NEMA 1 IP 54/NEMA 12 VLT 8042-8062, 200-240 V...
Page 73
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Electrical installation, power cables Compact IP 00/Chassis, IP 20/NEMA 1, and IP 54/NEMA 12 VLT 8450-8600 380-480 V without disconnectors and line fuses...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Use of EMC-correct cables Braided shielded/armored cables are recommended Transfer impedance (Z ) can be assessed on...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Tightening torque and screw sizes These figures apply to the following terminals: The table shows the torque required when fitting 91, 92, 93 terminals to the AFD.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Line connection Line must be connected to terminals 91, 92, 93. Nos. 91, 92, 93...
Page 77
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA If it is necessary to break the shield to install a The total current consumption of the motors...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE Use 24 V DC supply of type PELV to ensure correct galvanic isolation (type PELV) on the control terminals of the AFD.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA See Earthing/Grounding of shielded (armoured control 68, 69 RS 485 interface, serial cables for correct termination of control cables.
Page 80
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Bus connection In order to avoid potential equalizing currents in the The serial bus connection in accordance with...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Connection example VLT 8000 AQUA The diagram below gi v es an example of a typical There are 8 digital inputs, which are controlled with VLT 8000 AQUA installation.
Page 82
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Connection examples Run permissive Single-pole start/stop - Start permitted with terminal 16. - Start/stop using terminal 18.
Page 83
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 3-wire start/stop - Stop inverse by means of terminal 32. Parameter 306 = Stop inverse[14] - Latched start using terminal 18.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Control unit LCP respecti v ely. All AFD parameter Setups can be The front of the AFD features a control panel - LCP changed immediately via the control panel, unless this (Local Control Panel).
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE The voltage indicator lamp is acti v ated when [QUICK MENU] gi v es access to the the AFD recei v es voltage.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE 80.0% 5.08A 2.15kW An acti v e HAND-OFF-AUTO signal via the 40.0Hz digital inputs will have higher priority than the SETUP control keys [HAND START]-[AUTO START].
Page 87
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Line 4 says that the AFD is in Auto mode with remote reference, and that the motor is running.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Navigation between display modes FREQUENCY 40.0Hz AUTO REMOTE RUNNING Display mode I Press briefly With remote...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Changing data Regardless of whether a parameter has been FREQUENCY selected under the Quick menu or the Extended 50.0 Hz...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Quick Menu The QUICK MENU key gi v es access to 12 of the shown in the table below. A complete description most important setup parameters of the dri v e.
Page 91
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE Programming of extended parameters functions available through EXTENDED MENU key is done in accordance with same procedure as described for Quick Menu functions.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Programming Parameter 003 Copying of Setups enables copying from one Setup to another. Using the [EXTEND MENU] key, it is...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Connection examples 004 LCP copy Setup change (LCP COPY) Value: No copying (NO COPY) Upload all parameters (UPLOAD ALL PARAMET.)
Page 94
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 005 Max. value of user-defined readout Function: (CUSTOM READOUT) Value: 0.01 - 999,999.99 100.00 Function: This parameter allows a choice of the max.
Page 95
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA [10] Frequency [Hz] gi v es the output frequency Setpoint 1 [unit] (SETPOINT 1 [UNITS]) from the AFD.
Page 96
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Thermal load, VLT [%] states the calculated/ A B C D E F G H I J K L M N O P Q R S T U V W X Y Z estimated thermal load on the AFD.
Page 97
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: 013 OFF/STOP on LCP (STOP BUTTON) There is a choice of 33 different data values, see parameter 007 Large display readout.
Page 98
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE NOTE If [HAND START] or [AUTO START] cannot Only select Disable [0] if an external reset signal be acti v ated by the keys on the control has been connected via the digital inputs.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Load and motor 100-124 This parameter group allows the configuration of 101 Torque characteristics regulation parameters and the choice of torque (VT CHARACT) characteristics to which the AFD is to be adapted.
Page 100
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE Description of choice: It is important that the values set in parameters Select a value that equals the nameplate data on 102-106 Nameplate data correspond to the the motor.
Page 101
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 104 Motor frequency, f NOTE (MOTOR FREQUENCY) It is important to set the correct value, since this...
Page 102
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA for small motors, depending on the rating of the motor used (the time for a 7.5 HP motor, If there is a fault, the display reads: ALARM 22 for example, is approx.
Page 103
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: Description of choice: Adjust the damping percentage until the motor Select Disable [0] if this function is not required. Select resonance has disappeared.
Page 104
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA DC braking 115 DC braking time In DC braking, the motor recei v es a DC current (DC BRAKE TIME) that brings the shaft to a halt.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 118 Motor power factor (Cos ϕ) - Via a thermistor sensor fitted to the motor. The...
Page 106
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Torque control, Speed feedback and Special motor characteristics. Description of choice: Enter a %-value of the rated motor frequency (parameter 104).
Page 107
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA V), a special ohm-meter should be used (Thomson bridge or similar). R = 0.5 x R PHASE-to-PHASE 4.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA References and Limits 200-208 202 Output frequency high limit, f (MAX. FREQUENCY) Value: - 120 Hz (par.
Page 109
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA the [+/-] keys. If local reference has been selected, the output frequency range is limited by parameter...
Page 110
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 203 Reference site If Closed loop has been selected in parameter 100 (REFERENCE SITE) Configuration, the minimum reference is limited by parameter 413 Minimum feedback.
Page 111
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 206 Ramp-up time short. If, during deceleration, the AFD registers that the intermediate circuit voltage is higher than the max.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Reference type The example shows how the resulting reference is calculated when Preset references are used together with Sum and Relati v e in parameter 210 Reference type.
Page 113
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 215 Current limit, I NOTE (CURRENT LIMIT) If Sum or Relati v e is selected, one of the Value: preset references will always be acti v e.
Page 114
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 217 Frequency bypass 1 (BYPASS FREQ. 1) 218 Frequency bypass 2 (BYPASS FREQ. 2) 219 Frequency bypass 3 (BYPASS FREQ.
Page 115
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 223 Warning: Low frequency, f range of the AFD. See drawing at parameter 221 Warning: Low current, I (WARN.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA The warning functions in parameters 221-228 are Description of choice: not acti v e during ramp-up after a start command, Set the required value within the feedback range ramp-down after a stop command or while stopped.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA time. The Initial Ramp is used to quickly accelerate the 2 - param. 419 ) and continues operation in motor/equipment to minimum speed at which point, standard (normal) "closed loop"...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: The dimension of this parameter is Units/Second. The Units will be the value selected in parameter 415.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Inputs and outputs 300-328 In this parameter group, the functions that relate to the input and output terminals of the AFD are defined.
Page 120
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA ) Global default setting Reversing and start is used for start/stop and reversing using the same signal.
Page 121
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA This function is only acti v e if Freeze reference or Pulse reference is selected if a pulse sequence Freeze output has been selected.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA will be effected in accordance with the selected Inputs and outputs, 300-328. Motor alternation ramp (parameters 206 and 207).
Page 123
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 310 Terminal 53, max. scaling (AI 53 SCALE HIGH) Thermistor Is selected if a thermistor integrated in the...
Page 124
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: reference, Ref /413 Minimum feedback, FB . See Reference handling or Feedback handling .
Page 125
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 318 Function after time out (LIVE ZERO FUNCT.) Value: Off (NO FUNCTION) Freeze output frequency (FREEZE OUTPUT FREQ.)[1]...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Analog/digital outputs The two analog/digital outputs (terminals 42 and 45) (depending on the value set in parameter 322 Terminal can be programmed to show the present status 45, output, pulse scaling.
Page 127
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Function: Hand mode activeThe output is acti v e when This output can act both as a digital or an analog the AFD is in Hand mode.
Page 128
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA ⇒ 0-32000 p, which generates an output signal 320 Terminal 42, output, pulse scaling proportional to the output frequency in the interval 0 -...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: Set the desired value. Relay outputs Relay outputs 1 and 2 can be used to gi v e the present status or a warning.
Page 130
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: Enter the desired value. If the parameter 556 Bus time interval function becomes acti v e, relay 1 and relay 2 will become cut off if they are acti v ated via the serial communication.
Page 131
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: Set the desired feedback value. = factory setting. () = display text [] = value for use in communication via serial communication port MG.80.A7.22 - VLT is a registered Danfoss trademark...
Page 132
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 364 Terminal 42, bus control (CONTROL OUTPUT 42) 365 Terminal 45, bus control (CONTROL OUTPUT 45) Value: 0.0 - 100 %...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Sleep mode Sleep mode makes it possible to stop the motor when While the AFD has stopped the motor in sleep mode, a it is running at low speed, similar to a no load situation.
Page 135
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 403 Sleep mode timer Description of choice: (SLEEP MODE TIMER) Set the required frequency. Value: 0 - 300 sec.(OFF)
Page 136
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA If Warning [2] is selected, the AFD will gi v e a warning NOTE if the output current drops below the threshold value Switching frequencies higher than 4.5...
Page 137
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 411 Function at overtemperature 413/414 Minimum/Maximum feedback, and the unit (°C, °F) in parameter 415 Process units.
Page 138
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 415 Units relating to closed loop (REF. / FDBK. UNIT) No unit °C [21] [22]...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA PID for process control Reference The PID controller maintains a constant process In parameter 205 Maximum reference, Ref condition (pressure, temperature, flow, etc.) and...
Page 140
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA by means of a speed change. This function can be disabled in parameter 421 PID anti windup.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA PID overview The block diagram below shows reference and setpoint in relation to the feedback signal.
Page 142
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA on the feedback function selected in parameter 417 Feedback function, a calculation will be made...
Page 143
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 417 Feedback function If the difference between Setpoint 2 and feedback (2 FEEDBACK, CALC.) 2 is the larger of the two, the remote reference will be added to the parameter 419 Setpoint 2.
Page 144
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 419 Setpoint 2 Used in Closed loop [1] (parameter 100). (SETPOINT 2) Description of choice:...
Page 145
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE 425 PID differentiation time PID start frequency is always applied (PID DIFF. TIME) in clockwise direction.
Page 146
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA the process regulation. This can be an advantage The timer resets after completition of the if there is a lot of noise on the signal.
Page 147
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Description of choice: In some cases this dynamic compensation can cause resonance’s in the DC link and should then be disabled.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Serial communication for FC protocol Protocols As standard, all VLT 8000 AQUA units have a RS 485 port which enables a choice among four protocols.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Each transferred character begins with a start If the baudrate is 9600 kbaud and the telegram bit.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 2. Address format 1-126 Data character (byte) The byte for the 1-126 address range has...
Page 151
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 1. Parameter bytes If the command cannot be carried out, the slave will send this reply (0111) Command cannot be...
Page 152
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Example - Index: In order to read a text via the PWE block, the The first error code (index [1]) in parameter parameter command (AK) must be set to ’F’...
Page 153
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Example - Write a parameter value: Parameter 202 Output frequency high limit, f is to Example - Read a parameter value: be changed to 100 Hz.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Conversion: The different attributes for each parameter can be seen Conversion table: in the section on factory settings. Since a parameter...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Control word as per FC protocol The control word is used for transmitting commands Bit 03, Coasting stop: from a master (e.g.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Bit 15, No function/reversing: Bit 08, Jog: Bit 15 = "0" leads to no reversing.
Page 157
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Bit 13 = "0" means that there is no voltage warning. Bit 03, No trip/trip: Bit 13 = "1"...
Page 158
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Present output frequency Example - control word and serial communication ref.: The AFD must recei v e a start command, and the reference is to be set to 50 % (2000 Hex) of the reference range.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Serial communication 500-556 Description of choice: In this parameter group, the serial communication The transmission speed of the AFD must be set of the AFD is set up.
Page 160
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Digital input [0] Serial communication [1] Digital input [0] Serial communication [1] Serial Serial Serial Serial Kl.
Page 161
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 506 Reversering Function: See functional description under parameter (REVERSING) 503 Coasting. Value: Digital input (DIGITAL INPUT)
Page 162
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Logic and [2] Setup/Pre- Setup/Pre- Setup no. Preset ref. Logic or [3] Setup/Pre- Setup/Pre- Setup no.
Page 163
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 509 - 532 Data read-out Value: Parame- Description Display text Unit Updating ter no. interval...
Page 164
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Power [HP], parameter 516: Gi v es the present power absorption of the motor in HP.
Page 165
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 534 Display text 2 NOTE (DISPLAY TEXT ARRAY 2) Parameters 555 Bus time interval and...
Page 166
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 570 Modbus parity and message framing time out. The resulting retransmissions of messages will slow communications on the network.
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Hex code Warning word Warning words 1+2 and Alarm word 00000001 Reference high Warning word, extended status word and alarm...
Page 168
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Bit (Hex) Alarm word 00000001 Unknown fault 00000002 Trip locked 00000004 Auto-optimisation not OK 00000008...
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Service functions 600-631 This parameter group contains functions such as It also has information on the nameplate operating data, data log and fault log.
Page 170
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 606 - 614 Data log Value: Parameter Description Display text Unit Range Data log: Digital input...
Page 171
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Parameter 614 Data log: DC-link voltage: 617 Fault log: Value This gi v es the latest log data for the intermediate (F.
Page 172
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE When the [OK] key has been acti v ated, the reset has been carried out.
Page 173
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA 621 - 631 Nameplate Value: Parameter Description Display text Nameplate: Unit type (DRIVE TYPE) Power component (POWER SECTION) VLT ordering no.
Page 174
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA NOTE 702 Relay 6, OFF delay Parameters 700-711 for the relay card (RELAY6 OFF DELAY)
Page 175
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA = factory setting. () = display text [] = value for use in communication via serial communication port MG.80.A7.22 - VLT is a registered Danfoss trademark...
Page 176
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Status messages Status messages appear in the 4th line of the Remote reference (REM.) display - see example below.
Page 177
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA The cause may be noise on the line, motor Freeze output request (FRZ.REQ.) or control cables, leading to a stop of the A freeze output command has been gi v en, but the control card microprocessor.
Page 178
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA List of warnings and alarms The table gi v es the different warningsand alarmsand Wherever a cross is placed under both Warning and indicates whether the fault locks the AFD.
Page 179
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Warnings Alarms A warning will flash in line 2, while an If an alarm is gi v en, the present alarm number explanation is gi v en in line 1.
Page 180
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA The electronic, thermal inverter protection reports that ALARM: 15 the AFD is about to cut out because of an over-load Switch mode fault (SWITCH MODE FAULT) (too high current for too long).
Page 181
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA There is a fault in the EEPROM on the control card. LIMIT VALUE FAULT [8]...
Page 182
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Auto-optimization warnings 39-42 WARNING/ALARM: 63 Automatic motor adaptation has stopped, since Output current low (I MOTOR < I LOW)
Page 183
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Special conditions In environments with high temperatures and humidity, corrosi v e gases such as sulphur, nitrogen and chlorine...
Page 184
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Calculation of resulting reference The calculation made below gi v es the resulting External reference is the sum of references from reference when parameter 210 Reference type is terminals 53, 54, 60 and serial communication.
Page 185
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Ground leakage current NOTE Ground leakage current is primarily caused by the capacitance between motor phases and the motor Since the leakage current is >...
Page 186
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Extreme running conditions Short circuit Static overload VLT 8000 AQUA is protected against short circuits...
Page 187
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA VLT 8152-8352 380-480 V VLT 8152-8352 380-480 V Cable Line Peak IP00/Chassis/IP21/NEMA 1/IP54/NEMA 74 dB(A)
Page 188
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Derating for ambient temperature If VLT 8000 AQUA is operated at temperatures The ambient temperature (T ) is the above 45°C (113°F), a derating of the continuous...
Page 189
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Derating for running at low speed Switching frequency [kHz] Min. Max. Fact. VLT 8006-8032, 200 V 14.0...
Page 190
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Air humidity Efficiency VLT 8000 AQUA has been designed to meet the To reduce energy consumption it is very important IEC 68-2-3 standard, EN 50178 pkt.
Page 191
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA it is important to maintain harmonic currents at transformer or cause resonance in connection a low level to avoid overload of the transformer with power-factor correction batteries.
Page 192
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA CE labelling What is covered What is CE labelling? The EU "Guidelines on the Application of Council The purpose of CE labelling is to avoid technical Directi v e 89/336/EEC"...
Page 193
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Danfoss AFD and CE labeling CE labelling is a positi v e feature when used Compliance with EMC directive 89/336/EEC for its original purpose, i.e.
Page 194
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual EMC test results (Emission, Immunity) The following test results have been obtained using a system with an AFD (with options if relevant), a shielded control cable, a control box with potentiometer, as well as a motor and motor cable.
Page 195
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA EMC Immunity In order to confirm immunity against interference from electrical phenomena, the following immunity test has been made on a system consisting of an AFD (with options, if relevant), a shielded/armored control cable and control box with potentiometer, motor cable and motor.
Page 196
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Immunity, continued VLT 8006-8600 380-480 V, VLT 8006-8027 200-240 V Radiated Burst Surge electro- Mains...
Page 197
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Con- Data description during version type operation...
Page 198
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Con- Data description during ver- type operation...
Page 199
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Conversion index Conversion factor 0.01 0.001 0.0001 Data type Data type shows the type and length of the telegram.
Page 200
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Conver- Data description during sion type operation...
Page 201
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Conversion index: This number refers to a conversion figure to be used when writing or reading to or from an AFD by means of serial communication.
Page 202
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Conver- Data description during sion type operation...
Page 203
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Con- Data description during ver- type opera-...
Page 204
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Factory settings Parameter Factory setting Range Changes 4-setup Con- Data description during version type operation...
Page 205
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Option Card (for the four relay option card) Parameter Factory setting Range Changes 4-setup Con-...
Page 206
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA Index ............Data control byte ..............Data log .............. Dataread-out ..............DC braking ............... alarms ..........
Page 207
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA ..................... Galvanic isolation (PELV)* OFF/STOP on LCP ........................General technical data Output data ...............
Page 208
Rosewood STP ST42 General (Operation and Maintenance Manual - Part 4: Section 6.3 Manufacturers Manuals 6.3.33 Danfoss VLT Aquadrive 8000) Vendor Manual ® 8000 AQUA ........................Setpoint 24 Volt external DC supply ................. Setup ............Setup configuration ......... Setup of user-defined readout ..........
Need help?
Do you have a question about the STP ST42 and is the answer not in the manual?
Questions and answers