Page 1
WATER TRAILER MODEL MWT0500 OPERATORS MANUAL / PARTS BOOK...
Page 2
NOTES: Engine Make: Engine Serial #: Engine Model #: Pump Make: Pump Model #: Pump Serial #: Unit Model #: Unit Serial #:...
Page 3
THE INFORMATION CON- TAINED IN THIS MANUAL WAS BASED ON MACHINES IN PRODUCTION AT THE TIME OF PUBLICATION. MAGNUM PRODUCTS, LLC. RESERVES THE RIGHT TO CHANGE ANY POR- TION OF THIS INFORMATION WITHOUT NOTICE.
SPECIFICATIONS PUMP MANUFACTURER: TSURUMI PUMP MODEL: TE2-50HA PUMP TYPE: CENTRIFUGAL PUMP INLET/OUTLET: 2-INCH ENGINE MANUFACTURER: HONDA ENGINE MODEL: GX 120 ENGINE OIL REQUIREMENTS: SEE ENGINE OWNER’S MANUAL PUMP OUTPUT: 137 gal/min (520 l/min) WATER TANK CAPACITY: 500 gal (1895 liters) WATER FILL RATE: Full tank (500 gal) in 3-4 minutes @ full throttle EMPTY WEIGHT OF TRAILER:...
Page 6
National Highway Traffic Safety Administration (NHTSA) in addition to notifying Magnum Products, Inc. If NHTSA receives similar complaints, it may open an investigation; and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problem between you, your dealer, or Magnum Products, Inc.
Page 7
NEVER remove any of the instruction or safety or tank failure. decals from the trailer. If any are damaged or missing, contact your dealer or Magnum Prod- Keep all people and objects clear of the spray ucts, Inc. for replacements.
FILLING THE WATER TRAILER To fill the tank from a hydrant: 1. Remove the tank covers (A). 2. Open valve 1 and close valves 2, 3 and 4. Make sure the gravity drain bibb (H) is closed. 3. Attach the hydrant adapter to the hydrant. Attach the threaded end of the 2” rigid fill hose to the hydrant adapter.
DISCHARGING FROM THE WATER TRAILER To discharge from the rear spray nozzles: 1. Open valve 4 and close valves 1, 2 and 3. Make sure the gravity drain bibb (H) is closed. 2. Start the pump engine. Refer to the engine owner’s manual for proper starting and operation procedures.
SAFETY PRECAUTIONS WHEN OPERATING THE PUMP 1. DO NOT drive over the hoses while they are pressurized or if the pump is running. This will cause a rapid increase/decrease in line pressure that could break or damage the pump engine, pump housing or rupture hoses on the unit.
Replace any missing or hard to read decals immediately; contact your dealer or Magnum Products, LLC for replacements. This water trailer is designed for specific applications. Do not modify or use this unit for any application other than which it was designed.
DECAL LOCATIONS REAR BUMPER BOTH SIDES Warning decal sheet 40487 REAR FENDER BOTH SIDES BOTH SIDES BOTH SIDES BOTH SIDES BOTH SIDES Fender decal 40488 Instruction decal 11540...