All rights reserved. No part of this publication may by reproduced, stored in a CONFIGURATION SETUP retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 31205 Version 1.5...
Current consumption Procedure on how to upgrade the software of the DVD Portable DC-IN SUPPLY (9.0V) Download the latest software from the Philips Battery Charging Current 1.2A typ. support site. Unzipped the files and then burn it onto a CD ROM BATT.
Page 3
All manuals and user guides at all-guides.com 2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 4
All manuals and user guides at all-guides.com 2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
Page 5
All manuals and user guides at all-guides.com SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
All manuals and user guides at all-guides.com 3.0 INSTRUCTIONS FOR USE DVD PLAYER LAYOUT , , , OPEN Up / down / left / right cursor Opens disc door to insert or remove disc Confirms selection 5 IR REMOTE Remote sensor Pause playback CHG/POWER Power and charging indicator...
Page 7
All manuals and user guides at all-guides.com Remote Control , , , 7 0 - 9 Numeric keypad Up / down / left / right cursor Confirms selection 8 MUTE Muting play volume VOLUME REPEAT Volume control Repeats chapter / title / disc 9 RETURN For previous ( ) or next ( ) For VCD menu page...
Page 8
All manuals and user guides at all-guides.com 4.0 MECHNICAL INSTRUCTIONS 1. Back View as Fig.1 4. Remove key board and other parts as Fig.5 Remove screws to remove base Fig.5 Fig.1 5. Remove top cover as Fig.6 2. Soldered short pattern for laser diode as Fig.2 soldered Fig.6 Fig.2...
1. Power on player and open DVD Door. 2. Press <Set Up> at Remote Control. In <Set Up Menu> select <Preferences> and then <OK>. 3. For PET706 - Press successively 2 1 2 2 2 5. . . 4. Display will show <Region Code 2> for Europe: 5.
Page 10
All manuals and user guides at all-guides.com 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: NO POWER, NO GREEN LED start Check if the power cable replace cable/ No defect, return set OK? adapter set to customer AC adapter Check if the replace connector power and play and switch unit...
Page 11
All manuals and user guides at all-guides.com 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE INITIAL SCREEN IS NOT DISPLAYED ON THE LCD Refer to the symptom NO start POWER, NO GREEN LED Replace broken Check if the Repair connector harness LED on the front lights up? Remove the LCD...
Page 12
All manuals and user guides at all-guides.com 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE DVD DRIVE DOES NOT WORK Press the DISC cover switch at the center of the DVD player and turn on the power. Then check whether or not the optical pick- up lens of the DVD drive lights.
Page 13
All manuals and user guides at all-guides.com 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY start Install a good battery does the LED lights up orange while the AC adapter is connected and does the DVD drive operate OK? NOTE: - For this check, use a battery which is not fully Replace battery...
All manuals and user guides at all-guides.com 6.0 OVERALL BLOCK DIAGRAM OSCILLATOR DC 9V OZ9930 27MHz +3.3V +3.3V +3.3V 27MHz UPD5210G HIGH VOLTAGE ASS'Y 8M FlashROM TFT MONITOR 64M SDRAM TC4W53 MX26LV008BTC-55G HY57V641620ETP-7 VIDEO OUT SERVO & DVD PROCESSOR KHM252C MPEG-2 DECODER mechanism &...
Page 15
All manuals and user guides at all-guides.com 7.0 BLOCK DIAGRAM SWITCH PCB BATTERY XS002 XS001 LD/DVD LD/CD VRDVD VRCD HV POWER PCB HV9V TFTON BRIGHCON LDVCC ISEN VSEN VCOMS TFT-13V SPIO CD DVD SW MOD1 TFT3.3V TFT5V TFT5V TFT3.3V LIMIT TFT3.3V MAIN PCB SPL+...
All manuals and user guides at all-guides.com 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (MPEG) JITFO 390pF JITFN DV33 RFV33 RFV33 RFVDD3 750k ADACVDD 10uH Crystal 2200pF APLLVDD3 0.1uF/NC DACVDD3 680k ADIN 0.1uF 0.01uF 2200pF CE14 10uF/10v 10uF/6.3v 100k 0.1uF C10UF6.3V/D4H5 10uF/6.3v 10uF/10v...
Page 17
All manuals and user guides at all-guides.com 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (FLASH & SDRAM) D001 $$$148 $$$150 $$$151 $$$152 $$$153 $$$155 $$$156 $$$189 $$$190 $$$157 $$$188 $$$191 $$$158 DV33 $$$187 $$$192 $$$159 $$$186 $$$193 MA10 $$$160 A10/AP DQ10 $$$185 $$$194...
Page 18
All manuals and user guides at all-guides.com 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (UPD5210) Crystal R257 TFT3.3V R256 C214 100K +P5V C228 1N 100UH 10UF/10V C106 C2220 100NF 100NF 100NF C227 470P 10U/10V CLK_ I N CLK_ O UT 10UF 10UF 100N...
Page 19
All manuals and user guides at all-guides.com 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (AUDIO) PCM1753 ACLK ABCK DV33 ASDATA0 DATA ALRCK R558 R158 LRCK +P5V R559 VD524 DGND DV33 KTA1298 +P5V +3.3V ZERONA MUTE VD522 1SS355 R567 R556 VD525 1SS355 R557 VD520...
Page 20
All manuals and user guides at all-guides.com 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (DC POWER) #HV9V L005 C077 C088 CDRH6D38-330MC 16v/100u 100N 100N C091 C024 C167 5.5V OUT 10U/10V 100N 100U/10V CATION:REPLACE PUSE WITH SAME DRVCC 5V5 TYPE AND RATING littel fuse T3A/125V VD003...
Page 21
All manuals and user guides at all-guides.com 8.0 ELECTICAL DIAGRAM - HIGH VOLTAGE BOARD CIRCUIT DIAGRAM 1210 UI8.5 SOT-23 SOT-23...
All manuals and user guides at all-guides.com 10.0 SERVICE PARTS LIST The following service BOMs are applied for all versions unless specified. Model# Philips 12NC Spare part description Photo Location Code PET706 RB-LI73 LITHIUM 996500038671 BATTERY PET707 BATTERY PET706 RC810 REMOTE...
Page 25
PET706/05 (for S/N: LL2Bxxxxxxxx) PET706/00 PET706 IF PCBA PET706/05 996500038673 (for S/N: LL01xxxxxxxx & PET707/00 VN1Axxxxxxxx) PET707/05 PET706 LED HV & IF PET706/00 996510002007 PCBA PET706/05 (for S/N: LL2Bxxxxxxxx) PET706/75 IF PCBA 996500041646 (for S/N: LL01xxxxxxxx) PET706/75 PET706 IF PCBA...
Page 26
10.0 SERVICE PARTS LIST The following service BOMs are applied for all versions unless specified. Note: Different spare parts are applied for S/N: LL01xxxxxxxx / VN1Axxxxxxxx & LL2Bxxxxxxxx. Location Model# Philips 12NC Spare part description Photo Code LB070W02-TMB2 TFT PET706/00...
Page 28
10.0 SERVICE PARTS LIST The following service BOMs are applied for all versions unless specified. Location Model# Philips 12NC Spare part description Photo Code PET706 996500038680 PET706 BASE COVER PET707 996510001127 PET707 BASE COVER PET706 PET706 FUNCTION KEY 996500038688 PET707 DISCRETENESS PET706...
Version 1.1 (3141 785 31201) • Update Section 10, Replaced 994000002241 (LE140) by 994000002242 (LE105) Added new spare part for PET706/75 (996500041646 / 996500041647 / 996500041648 / 994000005792) Added location code of spare parts Version 1.2 (3141 785 31202) •...