Table of Contents
Related Manuals for Beverage-Air DP Series
Summary of Contents for Beverage-Air DP Series
- Page 1 INSTALLATION AND OPERATING INSTRUCTIONS for all DP and DPD Models 809-140A Rev. B: 06/03/2020 SEE BACK COVER FOR 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 WARRANTY REGISTRATION Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web: beverage-air.com...
-
Page 2: Table Of Contents
User Manual for DP & DPD Beverage-Air WELCOME Thank you for purchasing a Beverage-Air cabinet. This Please read the following installation and maintenance series has passed our strict quality control inspection instructions before installing or using your unit. If you... -
Page 3: Safety
R290 equipment. • Clean a dirty condenser with a sharp object. • Use ONLY Beverage-Air factory service parts. Use of • Store gasoline, kerosene or any other flammable non OEM parts can be dangerous because of the design material near the cabinet. -
Page 4: Important Information
User Manual for DP & DPD Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site. -
Page 5: Product Information
User Manual for DP & DPD Beverage-Air PRODUCT INFORMATION Cabinet Dimensions Full Load Compressor Refrigerant Charge Model Door Count Drawers w x d x h (Inches) Amps (g) (R-290) DP46HC 46 x 36.8 x 53.125 DP60HC 60 x 37 x 53.25... -
Page 6: Clearance And Placement
User Manual for DP & DPD Beverage-Air CLEARANCE AND PLACEMENT Placement Consider the following when selecting a location for your cooler: • Clearance: 2 inches at back. None at sides. • Floor Load: the floor on which the cooler is located must be even and level, free from vibrations, and strong enough to support the combined weights of the unit and maximum product load. -
Page 7: Unpacking And Set Up
User Manual for DP & DPD Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim. Do NOT contact the manufacturer. -
Page 8: Shelf Installation
4. Install all remaining clips. manner. Contact Beverage-Air customer service if fewer shelves or a different configuration to ensure 5. Install shelves onto clips with the product retention shelf overloading will not occur. -
Page 9: Drawer Maintenance
User Manual for DP & DPD Beverage-Air DRAWER MAINTENANCE Drawer models are shipped with the drawers already installed in the cabinets. Drawers are designed with slides which have locking mechanisms to prevent drawers from coming off cabinets during normal opening and closing operations. -
Page 10: Electrical
User Manual for DP & DPD Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers. -
Page 11: Using The Unit
User Manual for DP & DPD Beverage-Air USING THE UNIT Operation is simple, just keep it connected to the correct The refrigerator will automatically defrost as needed, power supply and the refrigerator will maintain the there is no set time for defrost. Push and immediately internal temperature it has been set to. -
Page 12: Sequence Of Operations Refrigerator
User Manual for DP & DPD Beverage-Air SEQUENCE OF OPERATIONS REFRIGERATOR The refrigerator operates based on the air temperature measured by the probe located at the return air. COMPONENT OPERATION CONTROLLER ACTION OPERATION CONTROLLER ACTION Compressor turns The Compressor The Compressor... - Page 13 User Manual for DP & DPD Beverage-Air Electronic Controller DEFROST (ESC) SELECT (OK) DOWN Control Panel Display Defrost LED Alarm LED On fixed: Defrost active On fixed: ALARM Present Off: Defrost is off Flashing: ALARM Silenced Off: No Alarm Fan LED...
- Page 14 User Manual for DP & DPD Beverage-Air Control Panel Connections Changing the Set point Electronic Controller Alarms The alarm condition is always signaled by the alarm icon . To turn off the relative icon will continue flashing. NOTE: If alarm exclusion times are in progress (ALA folder of the parameter table), the alarm is not signaled.
- Page 15 User Manual for DP & DPD Beverage-Air Alarm Trigger Automatic Outputs Comments Code Clearance "Hi" Air temperature is higher than User Bl ink "Hi" with the highest temperature; If High temperature "ALA->Hat• for "ALA->Htd" configured configured: cut in alarm relay, beep the buzzer alarm "Lo"...
-
Page 16: Cleaning And Maintenance
User Manual for DP & DPD Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection, check Annually that hinges are tight to Weekly interior the cabinet. Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up. -
Page 17: Condenser Cleaning
User Manual for DP & DPD Beverage-Air CONDENSER CLEANING Keeping the condenser coil clean is critical to efficient 3. Pull grill carefully out and off the cabinet. operation. 1. Unplug unit from power supply. Rotating fan blade can cause CAUTION personal injury. -
Page 18: Methods For Cleaning Stainless Steel
User Manual for DP & DPD Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Satisfactory for use on all Areal 20, Lac-O-Nu, Lumin Wash Rub with cloth as directed finishes. Smears and fingerprints O’Cedar Cream Polish, Stainless... -
Page 19: Help
User Manual for DP & DPD Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution Connect to proper voltage circuit Replace Unit not plugged in. fuse or reset breaker. No cooling - unit is silent Fuse or circuit breaker tripped. -
Page 20: For The Service Tech
User Manual for DP & DPD Beverage-Air FOR THE SERVICE TECH Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a Evacuation: It is critical that a refrigeration system be reminder and checklist for the service tech. -
Page 21: For The Service Tech - Wiring Diagram
User Manual for DP & DPD Beverage-Air FOR THE SERVICE TECH - WIRING DIAGRAM Rev. 05/20 Beverage-Air... -
Page 22: Limited Warranty
(87) months from the date of defective. shipment from Beverage-Air, provided upon receipt of the The labor warranty shall be for self-contained units compressor, manufacturer examination shows the sealed only and for standard straight time, which is defined as compressor to be defective. -
Page 23: Limited Warranty (Continued)
With the exception of Blast Chillers product is designed for LIMITATION OF LIABILITY: maintaining temperature and not bringing food to a desired Beverage-Air Corporation or their affiliates shall not be temperature therefore cannot be held responsible for this liable for any indirect, incidental, special or consequential function under warranty. - Page 24 User Manual for DP & DPD Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below. Cabinet Model Number: _____________________________________________ Date Of Installation: _________________ Cabinet Serial Number: _____________________________________________ Location Of Product Business Name: ____________________________________________________...