Please call our Technical Service meets the high standards set by Beverage-Air! You have Department at (800) 684-1195. 8:00 AM to 5:00 PM EST. made a quality investment that with proper maintenance...
R290 equipment. • Clean a dirty condenser with a sharp object. • Use ONLY Beverage-Air factory service parts. Use of • Store gasoline, kerosene or any other flammable non OEM parts can be dangerous because of the design material near the cabinet.
User Manual for DD Refrigerators Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site.
User Manual for DD Refrigerators Beverage-Air AIRFLOW DD36, DD48, DD50 Note: Compressor and Airflow can be on left or right end of cabinet. DD 58, DD68, DD72, DD78, DD94 Note: Compressor and Airflow can be on left or right end of cabinet.
User Manual for DD Refrigerators Beverage-Air PRODUCT INFORMATION CLEARANCE AND PLACEMENT Cabinet Dimensions Door Glass or Full Load Power Cord Refrigerant Type / Model w x d x h (Inches) Count Solid Door Amps Plug (NEMA) Charge (g) / (oz)
User Manual for DD Refrigerators Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim.
Page 9
User Manual for DD Refrigerators Beverage-Air Skid Removal and Caster Attachment the bottom of the cabinet. Tighten by hand as much Tip the unit forward and remove the skid. as possible. Some models may already have levelers installed. If so, then the levelers will need to first be WARNING removed and discarded.
User Manual for DD Refrigerators Beverage-Air KEG INSTALLATION Safety First! If in doubt about how to handle the CO2 system contact your dealer/distributor How to Install a CO2 Regulator and Replace an Empty CO2 Cylinder 1. Shut off gas pressure to dispenser by closing the Cylinder Valve and the Shut off Valve.
User Manual for DD Refrigerators Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers.
User Manual for DD Refrigerators Beverage-Air USING THE UNIT Operation is simple, just keep it connected to the correct The temperature was set at the factory at 38 F, but º power supply and the refrigerator will maintain the you can adjust it to your own selected temperature. 30 internal temperature it has been set to.
User Manual for DD Refrigerators Beverage-Air SEQUENCE OF OPERATIONS REFRIGERATOR The refrigerator operates based on the air temperature measured by the probe located at the return air. COMPONENT OPERATION CONTROLLER ACTION OPERATION CONTROLLER ACTION Compressor turns The Compressor The Compressor...
Page 14
User Manual for DD Refrigerators Beverage-Air Electronic Controller DEFROST (ESC) SELECT (OK) DOWN Control Panel Display Defrost LED Alarm LED On fixed: Defrost active On fixed: ALARM Present Off: Defrost is off Flashing: ALARM Silenced Off: No Alarm Fan LED...
Page 15
User Manual for DD Refrigerators Beverage-Air Control Panel Connections Changing the Set point Rev. 06/20 Beverage-Air...
Page 16
User Manual for DD Refrigerators Beverage-Air Electronic Controller Alarms Alarm Trigger Automatic Outputs Comments Code Clearance "Hi" Air temperature is higher than User Bl ink "Hi" with the highest temperature; If High temperature "ALA->Hat• for "ALA->Htd" configured configured: cut in alarm relay, beep the buzzer alarm "Lo"...
User Manual for DD Refrigerators Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection, check Annually that hinges are tight to Weekly interior the cabinet. Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up.
User Manual for DD Refrigerators Beverage-Air CONDENSER CLEANING The condenser coil is located right behind the front grille on models with end mounted condensing units, and behind the rear grille on the DD24HC model. It should be inspected once a month and cleaned as required.
User Manual for DD Refrigerators Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Satisfactory for use on all Areal 20, Lac-O-Nu, Lumin Wash Rub with cloth as directed finishes. Smears and fingerprints O’Cedar Cream Polish, Stainless...
User Manual for DD Refrigerators Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution Connect to proper voltage circuit Replace Unit not plugged in. fuse or reset breaker. No cooling - unit is silent Fuse or circuit breaker tripped.
User Manual for DD Refrigerators Beverage-Air FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a Evacuation: It is critical that a refrigeration system be reminder and checklist for the service tech.
User Manual for DD Refrigerators Beverage-Air FOR THE SERVICE TECH - WIRING DIAGRAM CNTRL *SEE CONTROLLER DETAIL CONDENSER FAN CURRENT RELAY COMP *SEE CONTROLLER DETAIL COMPRESSOR DETAIL (115V 1PH) EVAP FANS POWER *SEE CONTROLLER DETAIL SUPPLY *NOT ALL MODELS* LAMP L.E.D.
(87) months from the date of defective. shipment from Beverage-Air, provided upon receipt of the The labor warranty shall be for self-contained units compressor, manufacturer examination shows the sealed only and for standard straight time, which is defined as compressor to be defective.
With the exception of Blast Chillers product is designed for LIMITATION OF LIABILITY: maintaining temperature and not bringing food to a desired Beverage-Air Corporation or their affiliates shall not be temperature therefore cannot be held responsible for this liable for any indirect, incidental, special or consequential function under warranty.
Page 25
User Manual for DD Refrigerators Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below. Cabinet Model Number: _____________________________________________ Date Of Installation: _________________ Cabinet Serial Number: _____________________________________________ Location Of Product Business Name: ____________________________________________________...