Table of Contents
Advertisement
Adjusting the Parking Brake
Check the parking brake for proper adjustment.
1. Disengage the brake lever (lever down).
2. Measure the length of the spring; the measurement
should be 2-3/4 inch (74 mm) between the washers
(Fig. 59).
4
7
1 1
3
Figure 59
1. Brake lever
2. Spring, 2-3/4 inch
(74 mm)
3. Adjusting nuts
4. Collar on brake rod
3. If an adjustment is necessary, do the following:
A. Loosen the jam nut below the spring and tighten the
nut directly below the yoke (Fig. 59).
B. Turn the nut until you obtain the correct
measurement.
C. Tighten the 2 nuts together and repeat on the
opposite side of the machine.
4. Turn the nuts clockwise to shorten the spring length;
counterclockwise to lengthen the spring.
5. Engage the parking brake, with the lever up.
6. Measure the distance between the trunnion roller and
the collar on the brake rod. The measurement should be
3/16 to 1/4 inch (5 to 7 mm) (Fig. 59).
7. If an adjustment is necessary, do the following:
A. Loosen the jam nut directly below the yoke.
B. Turn the bottom adjusting nuts until the correct
measurement is obtained (Fig. 59).
C. Tighten the jam nut at the yoke.
5
6
2
m-4120
5. 3/16 to 1/4 inch
(5 to 7 mm)
6. Jam nut and yoke
7. Trunnion
43
Servicing the Fuses
Service Interval/Specification
The electrical system is protected by fuses. It requires no
maintenance; however, if a fuse blows, check the
component/circuit for a malfunction or short.
Fuse: Main F1—30 amp, blade-type
Charge Circuit F2—25 amp, blade-type
Optional Headlight Kit—10 amp, blade type
1. Raise the seat to gain access to the fuse holder (Fig. 60).
4
5
Figure 60
1. Main—30 amp
2. Charge circuit—25 amp
3. For optional Headlight
Kit—10 amp
2. To replace a fuse, pull out on the fuse to remove it
(Fig. 60).
Servicing the Battery
Warning
CALIFORNIA
Proposition 65 Warning
Battery posts, terminals, and related accessories
contain lead and lead compounds, chemicals
known to the State of California to cause cancer
and reproductive harm. Wash hands after
handling.
1
2
3
m–7724
4. Ignition switch
5. Throttle lever
Advertisement
Table of Contents
