Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Jenn-Air 750-0594
Summary of Contents for Jenn-Air 750-0594
- Page 1 K20Y07PN-2...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions Exploded View Model 750-0594 Placement of the Grill Parts List Model 750-0594 Exploded View Model 740-0594 SECTION TWO Parts List Model 740-0594 Model Specifications Island Construction SECTION SIX Front View of Opening... -
Page 3: Safety Instructions
SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION... - Page 4 24 inches from all sides to combustible materials. Outdoor cooking appliance shall not be used under Model 750-0594 Natural Gas Grill overhead combustible construction. WARNING 1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected...
- Page 5 SAFETY INSTRUCTIONS This grill is not intended to be installed in or on WARNING recreational vehicles or boats. Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this Children should not be left alone or unattended in an manual.
-
Page 6: Placement Of The Grill
Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 750-0594 and 740-0594 grills are designed for do not use a wet sponge or cloth to clean the grill optimum performance without the use of briquettes. -
Page 7: Model Specifications
GRILL SPECIFICATIONS Description 750-0594 and 740-0594 Cutout Width 38 in. (96.52 cm) Cutout Depth 21 in. (53.34 cm) Cutout Height 11 in.(27.94 cm) Natural Gas: Standard residential 1/2 in. (1.3 cm) ID gas service line. Natural gas hose/regulator assembly included with quick-connect fitting for attachment to house natural gas line. -
Page 8: Island Construction
There should be a minimum 37 3/4 in.(95.89cm) clearance of at least 24in.(60.96cm)from all sides to combustible materials. Island cutout dimensions for Jenn-Air 5 burner LP and NG built-in grills: Width 38 inches (96.52 cm) Depth 21 inches (53.34 cm) Height 11 inches (27.94 cm) - Page 9 Measurements shown are for attaching the LP regulator to the island. 1 7/16 in.(3.65cm) 13/16 in.(2.06cm) 2 15/16 in.(7.46cm) 750-0594 1 9/16 in.(3.97cm) 2 15/16 in.(7.46cm) Measurements shown are for attaching the NG regulator to the island. 1 9/16 in.(3.97cm)
-
Page 10: Front View Of Opening
FRONT VIEW FOR BUILT-IN OPENING 8 in.(20.32cm) 6 in.(15.24cm) 37 1/4 in.(94.62cm) 2 50 3 in.(7.62cm) ° ° 2 in.(5.08 2 in.(5.08cm) 1 7/8 in.(4.76cm) The following are minimum dimensions necessary to install the 5 burner’s built-in grills Width of grill head: 37 1/4 in. Depth for grill control panel: 10 7/8 in. -
Page 11: Side View Of Opening
The following are minimum clearances necessary around the Jenn-Air built-in 5 burner grills. Rear Clearance: 24 in. to combustible materials Combustion gap below control panel: 1 7/8 in. -
Page 12: Battery Installation
BATTERY INSTALLATION 1. Unscrew the ignition button by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed. -
Page 13: Lp Gas Hook Up
LP GAS HOOK-UP Only the pressure regulator and hose assembly LP GAS HOOK-UP supplied with the grill should be used. Any Make sure the black plastic grommets on the LP replacement pressure regulator and hose assembly cylinder valve are in place, and the hose does not must be specified by the grill manufacturer. -
Page 14: Propane Tank Assembly
INSTALLATION OF PROPANE LIQUID REGULATOR Fig. 1 Make sure the LP regulator is located under island hole as shown in Fig. 1. Fig. 2 Use the 4 screws and clamp provided to attach the brass connector to the island as shown in Fig. 2. The brass connector is located between the flex tube and gas hose. -
Page 15: Installation Of Ng Regulator
INSTALLATION OF NATURAL GAS REGULATOR 1. The Natural Gas regulator has been factory installed. Attach the PVC gas hose to the regulator (see drawing below). 2. Adjust the brass elbow so that it is pointing down. 3. Connect the other end of the PVC gas hose to the house gas line using the quick-connect fitting. -
Page 16: Natural Gas Hook-Up Xxxxxxxxxxxxxxxxxxxxxxxx
The installation of this appliance must conform with the local codes or, in the absence of local codes, to the national fuel gas code, ANSI Z223.1. Total gas consumption (per hour) of the 750-0594 grill with all burners on the “IGNITE / HI” setting: Main burners... -
Page 17: Leak Testing Xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx
LEAK TESTING XXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXX GENERAL Although all gas connections on the grill are leak 6. If it is evident there is excessive abrasion or tested at the factory prior to shipment, a complete wear, or the hose is cut, it must be replaced gas tightness check must be performed at the prior to the outdoor cooking gas appliance installation site. -
Page 18: Installer Final Checklist
Keep the instruction manual with the grill for future reference. Model 750-0594 WARNING 1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 1/2 psi (3.5 kpa). -
Page 19: Operating Instructions
OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 12,000 BTU/Hr. The CAUTION main grill burners encompass the entire cooking Do not leave the grill unattended while cooking. area and are side ported to minimize blockage from falling grease and debris. - Page 20 LOADING THE ROTISSERIE SKEWER It is normal for the skewer to flex when larger cuts 1. Screw the bushing into the skewer rod at the of meat are being cooked. It may also be necessary opposite end from the point. to remove the cooking grids for larger cuts of meat.
-
Page 21: Lighting Instructions
LIGHTING INSTRUCTIONS BEFORE LIGHTING… Inspect the gas supply piping prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. WARNING Do not use the grill if gas odor is present. Contact Yellow flames indicate insufficient air. -
Page 22: Lighting Illustrations
LIGHTING ILLUSTRATIONS MAIN BURNER LIGHTING ROTISSERIE BURNING LIGHTING 1. Open the top cover or lid. 4. Push and turn the Rear Burner knob to the “IGNITE/ON” setting and hold in for 5 seconds while holding, push electronic ignition button, until burner is lit. -
Page 23: To Match Light The Grill
MATCH LIGHTING THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. -
Page 24: Care And Maintenance
To reinstall the main burners: 3. Insert the burner over the valve assembly CAUTION (model 750-0594/740-0594 Item # 19 on Before cleaning, make sure the gas supply and pages 24 and 26). control knobs are in the “OFF” position and the Insert the back of the burner into the hole at burners have cooled. -
Page 25: Troubleshooting
TROUBLE SHOOTING WHEN TO LOOK FOR SPIDERS INSECT WARNING You should inspect the burners twice a year or Spiders and insects can nest in the burners of immediately after any of the following conditions this and other grills, which could disrupt gas occur: flow. -
Page 26: Exploded View Model 750-0594
EXPLODED VIEW MODEL 750-0594... -
Page 27: Parts List Model 750-0594
PARTS LIST MODEL 750-0594 REF# DESCRIPTION REF# DESCRIPTION Main lid screw cover Smoke Tray Cover Main lid screw Rotisserie Thermocouple gas valve Main Lid Main Burner Flex Gas Line Temperature Gauge NG brass connector A Logo Regulator, NG Main Lid Handle Heat Insulating... -
Page 28: Exploded View Model 740-0594
EXPLODED VIEW MODEL 740-0594... -
Page 29: Parts List Model 740-0594
PARTS LIST PARTS LIST MODEL 740-0594 REF# DESCRIPTION REF# DESCRIPTION Main lid screw cover Smoke Tray Cover Main lid screw Rotisserie Thermocouple gas valve Main Lid Main Burner Flex Gas Line Temperature Gauge Regulator, LP Logo 90 Degree Brass Adaptor Main Lid Handle Heat Insulating Main Burner Flex Gas Clamp cover... -
Page 30: Grilling Hints
GRILLING HINTS The preparation of meat, whether rare, medium, or To get the juiciest meat, add seasoning or salt after well done, is affected to a large degree by the cooking is finished and turn the meat only once thickness of the cut. during cooking. - Page 31 WEIGHT FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD SIZE TIME AND TIPS THICKNESS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended. A flare-up could occur quickly. Tenderloin, High 8 to 15 minutes...
- Page 32 POULTRY 1 to 1-1/2 hours Place skin side up. Grill. Turn and Broiler/fryer 2 to 3 pounds brush frequently with melted butter, margarine, oil, or marinade. FOOD WEIGHT FLAME APPROXIMATE SPECIAL INSTRUCTIONS SIZE TIME AND TIPS THICKNESS Breasts Medium 30 to 45 minutes Marinate with Italian dressing well-done FISH AND SEAFOOD...
-
Page 33: Grill Recipe Suggestions
GRILL RECIPES BBQ SALMON Half-hour before cooking, turn the 1tsp. Worcestershire sauce 2 large salmon steaks burner to the grill on high. Drain 1tsp. Dry mustard 2 tbs. oil seafood-reserving marinade. On each 1/4 tsp. Thyme, crushed Salt & pepper of twelve 10 in. - Page 34 heat tortillas on grill. Slice meat across CHICKEN TANDOORI STYLE 2 oz. lemon juice grain in thin slices. Place on hot platter. 8 large chicken thighs or drumsticks 10 lbs. pork roast Squeeze lemon juice over. Wrap meat and 1 c. plain nonfat yogurt any of the following toppings in tortillas: 1/2 c.
-
Page 35: Limited Warranty
Nexgrill Industries warrants to the original consumer-purchaser only that this product (Model #750-0594/740-0594) shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and examination.