Advertisement
Quick Links
Advertisement
Summary of Contents for Presto Lifts TT
- Page 1 TT & WT Tilt Tables Installation, Operation and Service Manual Model Number ___________________ Serial # _________________________ Date Placed in Service _____________ IMPORTANT: READ CAREFULLY BEFORE INSTALLING OR OPERATING LIFT Part orders are subject to a $50 minimum charge. January 2012...
- Page 2 This manual was current at the time of printing. To obtain the latest, most updated version, please contact Presto Lifts Customer Service Department or go to our website: www. PrestoLifts.com -- you will find a complete list of current owner’s manuals to print.
- Page 3 Figure 4 Electrical Schematic Pump Unit 3 Phase 208, 240, 460 Volts AC ......12 Figure 5 TT Series Lightweight Tilt Specifications ............13 Figure 6 WT Series Wide Base Tilt Specifications ............14 Page 3 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —...
- Page 4 S E C T I O N 1 INTRODUCTION The TT & WT Series Lifts are tilters and are designed for lifting, tilting and positioning a wide vari- ety of loads. These tilters are capable of being mounted on other Presto tables and stands or lagged directly to the floor.
-
Page 5: Installation
Make sure that the floor and the operation area reinstall. is flat, stable, relatively smooth and free from dirt, obstacles and surface defects. Page 5 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —... - Page 6 If the load is unstable or may become unstable, See the diagram pointing out the particular fasten it into position. Page 6 — PRESTO OWNER’S MANUAL: TT & WT TILT TABLES...
-
Page 7: Routine Maintenance
Inspect the following: Page 7 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —... -
Page 8: Troubleshooting & Maintenance
2 seconds. removing the coil stem from the pump. Note: 5. Raise lift, remove and replace chock to its straight do not overtighten the stem when reinstall- position. ing. Page 8 — PRESTO OWNER’S MANUAL: TT & WT TILT TABLES... - Page 9 15. Assemble rod nut to piston rod and torque to 100 ft/lb. 16. Lubricate piston and seals and install in cylinder. 17. Insert retainer ring. 18. Install cylinder and hydraulic lines. 19. Fill reservoir. Page 9 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —...
- Page 10 Table 1 – Hydraulic Oil Specifications If the lift will be used at normal ambient temperatures, Presto Lifts supplies the unit with Conoco Super Hydraulic 32 oil. This may be replaced by any other good quality oil with 150 SSU at 100° F and rust and oxidation inhibitors and anti-wear properties.
- Page 11 Figure 1: Hydraulic Schematic Figure 2: Electrical Schematic Pump Unit Single Phase 120 Volts AC Page 11 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —...
- Page 12 Figure 3: Electrical Schematic Pump Unit 1 Phase 208, 240 Volts AC Figure 4: Electrical Schematic Pump Unit 3 Phase 208, 240, 460 Volts AC Page 12 — PRESTO OWNER’S MANUAL: TT & WT TILT TABLES...
- Page 13 Page 13 PRESTO OWNER’S MANUAL: TT & WT TILT TABLES —...
- Page 14 Figure 6: WT Series (Wide Base) Tilt Specifications Page 14 — PRESTO OWNER’S MANUAL: TT & WT TILT TABLES...
- Page 15 Ordering Replacement Parts Presto Lifts has carefully chosen the components in your unit to be the best available for the purpose. Replacement parts should be identical to the original equipment. Presto Lifts will not be responsible for equipment failures resulting from the use of incorrect replacement parts or from unauthorized modifications to the unit.
-
Page 16: Quality Issues
Parts orders are determined to be complete based upon Presto Lift, Inc. inspection sheets and carrier shipping weights. Page 16 — PRESTO OWNER’S MANUAL: TT & WT TILT TABLES... - Page 17 Canada, or Mexico have thirty (30) days from date of RGA issue to have the product arrive at Presto Lifts’ facility. All merchandise must arrive Free on Board at Presto Lifts’ facility or the shipment will be refused and returned to the sender. All credits are issued less restocking and refurbishing charges, regardless if the merchandise was damaged in transit.
- Page 18 Presto Lifts Limited Warranty Policy Presto Lifts warrants all of its products against defects in the welded structural frame and, if ap- plicable, scissor legs from faulty material and workmanship for a period of five (5) years from the date of invoice.
- Page 19 MANY NEEDS REQUIRE MANY OPTIONS... LET PRESTO MEET THOSE NEEDS! Call Presto Sales for stock or customized lift inquiries: 800-343-9322 Email: sales@prestolifts.com...
Need help?
Do you have a question about the TT and is the answer not in the manual?
Questions and answers