Subscribe to Our Youtube Channel
Related Manuals for Clemas & Co i-move 2.5B
Summary of Contents for Clemas & Co i-move 2.5B
- Page 1 2.5B Operator Manual Clemas & Co. Unit 16 Ashchurch Business Centre, Alexandra Way, Tewkesbury, Gloucestershire, GL20 8NB. Tel: 01684 850777 Fax: 01684 850707 Email: info@clemas.co.uk Web: www.clemas.co.uk...
-
Page 2: Preface
Become familiar with the correct operation and maintenance procedures. Store the manual in a safe place. The manual is an essential part of the i-move 2.5B and must be handed over to the new owner upon resale or exchange. Each i-move 2.5B has a unique identification number that can be found on top of the main body. -
Page 3: Reading Guide
Reading guide The following symbols and terms are used throughout this manual to alert the reader to safety issues and important information: Symbol Term Explanation WARNING Indicates a hazardous situation which, if the safety instructions are not followed, can lead to injuries of the operator or bystanders, light and/or moderate damage to the product or the environment. -
Page 4: Table Of Contents
Content Preface ..................................3 Purpose of the user manual ............................ 3 Target audience ..............................3 Operators of the i-move 2.5B ..........................3 Reading guide ................................4 Introduction ..............................7 Intended use of the product ........................7 Non-intended use of the product ......................8 Lifespan .............................. - Page 5 Cleaning ............................... 28 7.1.1 Cleaning the machine ........................28 7.1.2 Cleaning the hose and wand ......................28 7.1.3 Cleaning the filters .......................... 28 Replacing the filters ..........................29 7.2.1 Replacing the cassette filter ......................29 7.2.2 Replacing the motor filter ....................... 31 7.2.3 Replacing the fragrance cartridge ....................
-
Page 6: Introduction
1 Introduction The i-move 2.5B® is an easy and safe machine to use. This manual helps you get started and explains the operation and maintenance procedure. The battery must be fully charged before use. Please refer to the user manual of the i-charge® 5 for the correct procedure. -
Page 7: Non-Intended Use Of The Product
Keep the i-move 2.5B and the accessories clean. In order to use the i-move 2.5B on different types of surfaces, besides the standard floor tool, also a crevice tool, an upholstery tool and a round brush are available. These tools are easy to replace. -
Page 8: Specifications
1.5 Specifications Figure 2 Body size excluding harness (W x T x H): 224 x 240 x 480 mm Weight (excl. hose and wand, incl. batteries): 5.28 kg Battery weight (1 battery): 0.70 kg Hose length (retracted/stretched out): 50 cm/200 cm Capacity: 2.5 L Sound level (1 m distance and 1 m distance on 1.5... -
Page 9: Warranty
The i-move 2.5B® should only be operated with the materials supplied. Using alternative supplies may cause damage to the i-move 2.5B and may cause a risk to the operator. The use of alternative supplies voids manufacturer's warranty. The warranty period is 1 year. -
Page 10: Identification
1.7 Identification Each i-move 2.5B® has a unique serial number that can be found on the bottom of the main body. Your i-team partner needs this number when you order parts. Explanation type plate: Product type: i-move 2.5B Serial number:... -
Page 11: Description
The unique carrying system of the i-move 2.5B® ensures ultimate comfort during lengthy working times. You can turn the i-move 2.5B on and off with the remote control. The i-move 2.5B uses a HEPA H11 filter and also includes a fragrance cassette for pleasant smelling air. Combine the i-move 2.5B with our i-brush®... -
Page 12: The Remote Control
2.1 The remote control 1. Battery power status display (Figure 5, pos 1). The blue battery power status LEDs are on during normal use. When the battery is full all blue LEDs are on, when the batteries get empty the blue LEDs will go off one by one. -
Page 13: Safety
DO NOT operate the i-move 2.5B without a filter dust bag. WARNING DO NOT use the i-move 2.5B on damp or wet surfaces. This will cause damage to the i- move 2.5B and is dangerous to the user. The damage caused by the use on a wet... -
Page 14: Transport And Storage
2.5B is stored for a longer period, remove the battery. See section 6.3.2; • before you transport the i-move 2.5B , remove the battery. See section 6.3.2; • before you use the i-move 2.5B again, make sure the battery is loaded, see the User Manual of the i-charge® 5. -
Page 15: Assembly And Installation
The i-move 2.5B® does not require much assembly, the harness is already attached to the i-move 2.5B. A battery and a battery charger can be ordered separately. 5.1 Unboxing The i-move 2.5B is packed in 1 box. It includes the i-move 2.5B itself and a starter package of tools. Figure 6 Legend 1x crevice tool 1x i-move 2.5B... -
Page 16: Assembly
5.2 Assembly 1. Insert the hose (Figure 7, pos 1) into the body of the i-move 2.5B® (Figure 7, pos 4) and into the wand (Figure 7, pos 2). 2. Attach the desired tool (Figure 7, pos 3) onto the narrow end of the wand. -
Page 17: Replacing The Dust Bag
5.3 Replacing the dust bag ATTENTION • Only use original i-team dust bags. 1. Place the i-move 2.5B® on a level surface. 2. Push the yellow button (Figure 8, pos 1) to unlock the hatch. 3. Remove the hatch (Figure 8, pos 2). - Page 18 7. Place the yellow holder (Figure 10, pos 1) in its top position. Push the yellow button (Figure 10, pos 2) and it will click into its locked position. 8. Insert the cardboard collar of the new dust bag (Figure 10, pos 3) fully into the yellow bag holder.
-
Page 19: Operation
6.1 Before you start 1. Check the i-move 2.5B® for damage or defects. 2. Make sure that the dust bag is placed in the i-move 2.5B. 3. Make sure you have the correct tool for the intended purpose. 4. Check the brush from the tool for wear and tear. -
Page 20: Normal Operation
Make sure that the harness is well adjusted, so it fits comfortably on your body. Otherwise it can cause physical discomfort. 1. Place the i-move 2.5B on a table or similar (Figure 14, pos 4). 2. Open the waistband (Figure 14, pos 3). - Page 21 8. Fasten the buckle at the front (Figure 15, pos 4). 9. Clip the remote control on the waistband or on one of the buckle loops (Figure 15, pos 1). 10. Press the ON/OFF button (Figure 15, pos 3) to turn on the i-move 2.5B. Figure 15...
-
Page 22: After Normal Operation
6.2.1 After normal operation 1. Press the ON/OFF switch (Figure 15, pos 3) to turn off the i-move 2.5B®. 2. Undo the buckle at the front (Figure 15, pos 4). 3. Undo the two buckles (Figure 15, pos 2). 4. Open the waistband (Figure 15, pos 5). -
Page 23: Operation With I-Brush
3. Insert the hose of the i-brush into the connector (Figure 17, pos 2). 4. Turn the hose of the i-brush clockwise to lock it into place. 5. Connect the plug from the i-brush (Figure 17, pos 3) onto the connector on the i-move 2.5B (Figure 17, pos 4). - Page 24 7. Place the i-move 2.5B® on a table or similar (Figure 18, pos 4). 8. Open the waistband (Figure 18, pos 3). 9. Loosen the buckle at the front (Figure 18, pos 2). 10. Loosen the 2 buckles (Figure 18, pos 1).
- Page 25 15. Clip the remote control on the waistband or on one of the buckle loops (Figure 19, pos 1). 16. Press the ON/OFF switch (Figure 19, pos 3) to turn on the i-move 2.5B. 17. Press the ON/OFF switch (Figure 19, pos 5) to turn on the i-brush®, the i-brush works best if no pressure is applied to the brush.
-
Page 26: After Operation With I-Brush
6.3.1 After operation with i-brush® 1. Press the ON/OFF switch (Figure 19, pos 5) to turn off the i-brush. 2. Press the ON/OFF switch (Figure 19, pos 3) to turn off i-move 2.5B®. 3. Undo the buckle (Figure 19, pos 4) at the front. -
Page 27: Maintenance
Maintenance that is not described in this manual should be done by your i-move 2.5B partner. Please make sure to have the model and serial number of the i-move 2.5B available when you call a partner. For more information please fill out the contact form on www.i-teamglobal.com. -
Page 28: Replacing The Filters
6 to 8 months. 7.2.1 Replacing the cassette filter CAUTION When you place the new cassette filter in the can of the i-move 2.5B®, make sure the arrows on the filter point upwards. 1. Place the i-move 2.5B on a level surface. - Page 29 Figure 23 HEPA filter Your i-move 2.5B is equipped with an H11 HEPA cassette filter, which is perfect for everyday cleaning. The HEPA filter will remove pathogens, allergens and particles that may cause health issues that are often associated with asthma.
-
Page 30: Replacing The Motor Filter
7.2.2 Replacing the motor filter 1. Turn off the i-move 2.5B® with the ON/OFF switch (Figure 24, pos 1). 2. Place the i-move 2.5B flat on an horizontal surface. 3. Turn the filter housing (Figure 24, pos 2) counterclockwise to remove it from the bottom of the i-move 2.5B. -
Page 31: Replacing The Fragrance Cartridge
To adapt the strength of the fragrance you can add or remove fragrance pods. The minimum amount is 1 fragrance pod, the maximum amount is 3 fragrance pods. 1. Turn off the i-move 2.5B® with the ON/OFF switch (Figure 26, pos 1). -
Page 32: Brush And Tool Condition
7.5 Maintenance frequency Make sure that routine and preventive maintenance is carried out periodically to ensure safe operation. Failure to carry out maintenance as necessary may cause damage to the i-move 2.5B® and may cause a risk to the operator. -
Page 33: Trouble Shooting
Wait approximately 30 minutes. Start the i-move 2.5B by pushing the ON/OFF switch. Empty battery Charge battery. i-move 2.5B makes strange sound Motor is broken Replace motor. Hose blocked Turn off the i-move 2.5B and remove blockage. Dust bag is full Turn off the i-move 2.5B and... -
Page 34: Decommissioning And Disposal
It is the responsibility of the i-move 2.5B® owner to dispose of the product. At the end-of-life the i-move 2.5B still contains valuable resources and needs to be disposed of according to your local laws and regulations regarding recycling of electrical equipment. -
Page 35: Attachments
10 Attachments 10.1 CE Certificate... - Page 36 This document is part of the technical file of the i-move 2.5B® and will be available upon request.
Need help?
Do you have a question about the i-move 2.5B and is the answer not in the manual?
Questions and answers