Zodi 5148 Instruction Manual

CAUTION - READ THIS BEFORE OPERATING HEATER

WARNING: Follow all instructions and all ALWAYS KEEP HEATER OUTSIDE WHEN
warnings to avoid fire, serious injury or death. HEATING. KEEP BLOWER AND AIR HOSE
CLEAR FROM VEHICLE, GENERATOR, GAS
FOR OUTDOOR USE ONLY. Do not operate
POWERED PRODUCT, CAMP FIRE, SMOKE,
propane fueled product indoors, in confined
VAPOR, EXHAUST OR FUMES.
areas, near flammable materials, liquids or
vapors, near any gas powered products or Air must be flowing from output air hose
near exhaust, fumes, fire or smoke. before igniting propane burner. Air must
always be flowing from output air hose when
DANGER - CARBON MONOXIDE HAZARD.
propane heater is on.
Operating this item in an enclosed space
can kill you. Never use heater indoors or in If air flow stops or suddenly decreases,
an enclosed space such as camper, boat, turn propane burner off until proper air flow
tent, RV, car or home. This appliance can resumes.
produce carbon monoxide which has no odor
Do Not Use System Indoors. Operating this
and can kill you. Use only outdoors in well
item in an enclosed space can kill you. Never
ventilated area. Do not operate heater near
use this appliance indoors or in an enclosed
any gas powered products including vehicles,
space such as a camper, tent, car, boat or
generators, gas engines, RVs or near other
home. This appliance can produce carbon
propane fueled products or any product that
monoxide which has no odor and can kill you.
produces fumes exhaust or smoke. Exhaust
Use only outdoors in well ventilated area at
or fumes from any gas powered product can
least 15 ft (5M) clear from flammable materials,
kill you.
and completely clear of flammable liquids or
DANGER - This system consumes air. Do NOT vapors when igniting & operating.
obstruct the flow of combustion or ventilation
Air hoses must be completely and tightly
of air.
secured to collars on X-40 Vent.
Propane cylinder must be in a vertical position
Inspect the X-40 internal heating tubes and
and safely positioned and anchored to firm
flanged ends before each use.
flat ground when heating. Do not connect to
remote gas supply.
Do not place any items on or near heater. Keep
children and pets clear when operating. Do not
This heater gets very hot but no flame is
leave system unattended when operating. Allow
visible. Keep combustible materials at least 15
heater to cool before handling, transporting and
ft (5 M) from heater.
storing.
Heater and output air hose gets hot during
This system uses a high performance heater.
use. Allow system to cool completely before
When heater is turned all the way up, you may
handling, repositioning, storing or transport.
notice hot spots on heater housing or flames
FOR YOUR SAFETY, if you smell gas, DO NOT near top of system. If flames exit exhaust holes
attempt to light heater and extinguish any at top of heater, turn down propane valve.
open flame. Disconnect X-40 from fuel source. Housing color may darken with use but will
Always attach and detach regulator to propane usually return after system has cooled. Note:
tank outdoors away from flames, other ignition Discoloration is not covered by warranty.
sources & only when heater is cool.
Do not obstruct or restrict the flow of air for
FOR YOUR SAFETY do not store or use combustion.
gasoline or other flammable liquids or
NEVER OPERATE HEATER WHILE SLEEPING.
flammable vapors in the vicinity of this or any
other appliance.
Other Zodi products for all your outdoor adventures!!
ZODI X-40 SHOWER ZODI I HUT
Enjoy hot showers anywhere Enjoy privacy anywhere with
with the Zodi Outfitter Series this self supporting hut.
Portable HOT Shower! Almost 4 feet wide per side!
800-589-2849
Adjust propane valve to adjust heat output. If
too hot, turn down gas valve. If not hot enough,
turn propane valve up or recycle air by placing
both air hoses inside tent. Changes take about 1
minute. DO NOT PLACE X-40 HEATER IN TENT.
For best performance, shield system from wind
and use full propane tanks stored at room
temperature. High altitude, cold or low propane
will result in decreased performance. For best
performance, keep air hoses as straight as
possible. In cold areas, recycle air by placing
free end of both air hoses inside tent. Keep
heater outside in well ventilated area.
Turn off gas valve on propane tank and
disconnect regulator from propane tank
between uses. Remove propane cylinder
from system before and during transport and
storage. Do not store propane indoors.
The fan and air hoses are limited life items
and will require replacement with extended
use. Fans and air hoses are not covered under
warranty. For best performance, always use fully
charged 12 Volt batteries and full propane tanks.
Replacement fans and air hoses can be found
at your nearest camping retailer or at www.zodi.
com.
Improper use can result in injury or death. Zodi
Outback Gear is not responsible for improper
use.
Zodi Hot Tap X-40 Vent Tent Heater
Max Rating: <40,000 btu/hr
Gas Type: Propane
Model: 5148
Patent Pending
Parts: www.zodi.com
Zodi
PO Box 4687
Park City, UT 84060
Assembled and Made in USA
Designed in Park City, UT USA
ZODI HOT TAP HP ZODI SHOWER POLE
Portable hot shower are easy Enjoy hands free showering.
wth the Zodi Hot Tap HP. Easy Adjustable height. Works with
to use & great for all seasons! all Zodi showers and Huts.
www.zodi.com
RETAIN THESE INSTRUCTIONS FOR
FUTURE REFERENCE
Instruction Manual
5148 - X-40 Hot Vent Tent Heater with Push Button Ignition
Read Directions Before Operating
Follow Directions at all Times

FOR YOUR SAFETY

If you smell gas:
1. Do not attempt to light the appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
FOR YOUR SAFETY
Do not store or use gasoline or other liquids with flammable
vapors in the vicinity of this or any other appliance.
800-589-2849
Model # 5148
pat. pend
DANGER CARBON MONOXIDE HAZARD
Operating this item in an enclosed space can kill you.
Never use this appliance indoors or in an enclosed space
such as a camper, tent, car or home.
DANGER CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which
has no odor and can kill you. Use only outdoors in well
ventilated area clear of any fuel powered products.
www.zodi.com