Page 1
Kenwood. Disclaimer While every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Kenwood reserves...
Market code TX-RX unit number X57-701X-XX TK-3170 B51-8738-00 E,X2 J72-0964-19 X57-7012-72 TK-3170 SUPPLEMENT B51-8740-00 J72-0964-19 X57-7012-XX TK-3170 SUPPLEMENT II B51-8765-00 This service manual E,E3,E4,E6 J79-0084-09 SYSTEM SET-UP Merchandise received Frequency range (MHz) RF power Type TX/RX 440~470 TK-3170 E,E4 Choose the type of transceiver...
Les articles non mentionnes dans le Parts No. ne sont pas fournis. Y : AAFES (Europe) X : Australia M : Other Areas Teile ohne Parts No. werden nicht geliefert. TK-3170 (Y50-5862-XX) TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No.
Page 5
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation CK73HB1A104K CHIP C 0.10UF C136 CK73HB1H561K CHIP C 560PF CC73HCH1H010C CHIP C 1.0PF C137 CK73HB1H471K CHIP C...
Page 6
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C525 CS77AA1A2R2M CHIP TNTL 2.2UF 10WV E,E4 C610-613 CK73HB1H471K CHIP C 470PF E3,E6 C525 CS77AA1E010M CHIP TNTL 1.0UF...
Page 7
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C704 CK73HB1C103K CHIP C 0.010UF C769 CK73HB1H471K CHIP C 470PF C705 CC73HCH1H220J CHIP C 22PF C771...
Page 8
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation L511 L40-1275-57 SMALL FIXED INDUCTOR (12.0NH) E,E4 CP22-24 RK74HB1J102J CHIP-COM 1.0K 1/16W L511 L40-1575-57 SMALL FIXED INDUCTOR (15.0NH)
Page 9
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation RK73GB2A000J CHIP R 1/10W R164 RK73HB1J184J CHIP R 180K 1/16W RK73HB1J184J CHIP R 180K 1/16W R165...
Page 10
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R247 RK73HB1J184J CHIP R 180K 1/16W R607 RK73HB1J220J CHIP R 1/16W R248 RK73GB2A000J CHIP R 1/10W...
Page 11
TK-3170 PARTS LIST TX-RX UNIT (X57-7012-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R734 RK73HB1J563J CHIP R 1/16W IC13 AQUA-L MOS-IC R735 RK73HB1J104J CHIP R 100K 1/16W IC14 TC7W53FK(F)
TK-3170 EXPLODED VIEW 701x2 RF UNT TX-RX unit (D/4) SHIELDING PLATE TX-RX unit (A/4) TX-RX unit (B/4) TX-RX unit (C/4) : N09-2438-05 : N14-0805-04 : N14-0833-04 D M2.6 x 10 : N30-2610-48 M3 x 6 BLK : N30-3006-43 M2 x 3...
TK-3170 PACKING 48 Item carton case (H52-2067-02) 53 Hook (J29-0701-15) 6 Cap (B09-0686-03) 46 Packing fixture (H12-4210-02) 51 Holder (J19-5483-23) 17 Instruction manual (B62-1812-10) Parts with the exploded numbers larger than 700 are not supplied.
TK-3170 ADJUSTMENT • LCD display in panel test mode Controls Selector Selector – Volume Volume N : Narrow Channel No. W : Wide 5k Signaling No. S : Wide 4k (E type only) ■ Frequency and Signaling The set has been adjusted for the frequencies shown in the following table.
Page 15
TK-3170 ADJUSTMENT ■ 3 or 5 reference level adjustments frequency Panel Tuning Mode ■ Preparations for tuning the transceiver Tuning E, E4 E3, E6 Before attempting to tune the transceiver, connect the point RX (MHz) TX (MHz) RX (MHz) TX (MHz) unit to a suitable power supply.
Page 16
TK-3170 ADJUSTMENT ■ Flow chart Note : Wide 4k is E and E4 typse only Frequency 5 reference level High power adjustments 3 reference level Low power adjustments 3 reference level DQT balance Narrow adjustments [Side2] [Side2] [Side2] Max deviation Narrow...
Page 17
Refer to page 22 for details. nut, use a recommendation tool. KENWOOD part No. : W05-1123-00 Note : When using the battery jig, you must measure the voltage at the terminals of the battery jig. Otherwise, a slight...
Page 18
TK-3170 ADJUSTMENT Common Section Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. Setting 1) BATT terminal voltage : 7.5V 2) SSG standard modulation [Wide] MOD : 1kHz, DEV : 3kHz [Narrow] MOD : 1kHz, DEV : 1.5kHz ±...
Page 19
TK-3170 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 6. DQT balance 1) Adj item : [BAL_ _] Panel Panel Selector Make the demodu- adjust Adjust : [✳✳✳.] knob lation waves into These 2 peaks to...
Page 20
TK-3170 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment ± 40Hz 12. DQT 1) Adj item : [DQT_ _] Power meter Panel Panel Selector 0.35kHz deviation Adjust : [✳✳✳.] knob adjust Deviation meter filter Deviation...
Page 21
TK-3170 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 16. BATT 1) Adj item : [BATT_] Power meter Panel Panel After pressing the BATT terminal voltage : 5.9V detection Adjust : [✳✳✳] PTT switch, confirm...
Page 22
TK-3170 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 4. Low RSSI 1) Adj item : [LRSSI] Panel Panel Selector After input signal adjust Adjust : [✳✳✳.] knob from SSG, press [B] • Narrow SSG output : –118dBm (0.28µV) AF VTVM SP/MIC key.
Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex Kwai Fong, N.T., Hong Kong KENWOOD House, Dwight Road, Watford, Herts., 1 Ang Mo Kio Street 63, Singapore 569110 WD18 9EB United Kingdom...