Page 2
Important This appliance must be installed in accordance with: Manufacturers installation instructions Current AS/NZS 3500, AS/NZS 5601.1 and G12/AS1 For use with Natural Gas or Universal LPG as indicated on the appliance. Not suitable as a spa or swimming pool heater. Not suitable for commercial or solar applications.
Table of Contents Limited Warranty ....................3 Installation Guide ....................5 Before Installation ....................5 Appliance Location ....................5 General Safety Information ................. 6 Connections and Fittings ..................6 Commissioning ....................7 Operation Guide ....................8 About your Califont Water Heater ............... 8 Warning about Hot Water ..................
6. Challenge Yachts reserve the right to transfer functional components from defective appliances if they are suitable 7. Challenge Yachts reserve the right to have the installed product returned to a designated service centre for repair Challenger Water Heater Operating Instructions...
Page 5
5) Where it is found that there is no fault with the appliance and the issue is related to the installation or is due to the failure of gas supply 6) Subject to any statutory provisions to the contrary, Challenge Yachts does not accept: a.
Installation Guide Before Installation Check for damage: Unpack the appliance and check for damage. DO NOT install any damaged items Check components and gas type: Check all components have been supplied and that you have the correct gas type Reach these instructions: Get an overview of the steps required ...
General Safety Information Securing the Challenger Califont Water Heater The wall or structure on which the units are mounted MUST BE capable of supporting the weight of the appliance and associated pipe work. Ensure that suitable fixing screws or bolts are used to secure the unit to the wall, in accordance with AS/NZS 5601 section 6.
Commissioning AS/NZS 5601.1, clauses 2.6.8 and 6.11.2 states that every part of a gas installation shall be commissioned prior to initial use. It is the installer’s responsibility to ensure all current AS/NZS 5601 requirements are met. The appliance must be tested after installation. Ensure that the building occupants do not have access to hot water outlets during this procedure.
Operation Guide About Your Califont Water Heater Before using or operating your water heater ensure your installer talks to you about the use and care of this appliance, and that you understand these instructions. Principles of operation The burner lights automatically when the hot water tap is opened, and goes out when the tap is closed.
Safety and Important Messages This appliance is not intended for use by persons (including children), with reduced physical sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
General Information Frost protection If the Califont Water Heater is not going to be used for a period of time, turn off the water and gas supplies. If the Califont Water Heater is subject to frost or freezing ensure that the water is drained when not in use.
Trouble Shooting Fault Causes Remedies Open cold water tap Lack of water flow, or And/or turn on gas Lack of gas supply, or supply And/or replace Insufficient power batteries. Unsuccessful Flat batteries Replace the batteries ignition Gas pipe is full of air Turn tap off and on.
Proof of Purchase Record your details of purchase below: Retailer: ___________________________________________________ Retailer Address: ____________________________________________ Date of Purchase: ___________________________________________ Invoice Number: ____________________________________________ Installer Details Record your details of installer below: Company Name: ____________________________________________ Installer Name: _____________________________________________ Address: __________________________________________________ Phone: ____________________________________________________ Certificate of compliance number for installation: ___________________ Signed: ___________________________________________________ Dated: ____________________________________________________ Challenger Water Heater Operating Instructions...