Do you have a question about the Ibiza 6L1 and is the answer not in the manual?
Questions and answers
Subscribe to Our Youtube Channel
Summary of Contents for Seat Ibiza 6L1
Page 1
Seat Ibiza 6L1 door lock – replacement guide VIDEO TUTORIAL Important! This replacement procedure can be used for: SEAT CORDOBA (6L2) 1.4 16V, SEAT IBIZA III (6L1) 1.4 16V The steps may slightly vary depending on the car design. 1–39 WWW.AUTODOC.CO.UK...
Page 2
REPLACEMENT: DOOR LOCK – SEAT IBIZA 6L1. LIST OF THE TOOLS YOU'LL NEED: Torque wrench Painter's tape Drive socket # 10 Flat Screwdriver Torx bit T20 Phillips screwdriver XZN socket bit # 8 Clip removal tool Ratchet wrench Plastic trim tool 2–39...
Page 3
The replacement procedure is identical for the locks on the left and right rear doors. Please note: all work on the car – Seat Ibiza 6L1 – should be done with the engine switched off. CARRY OUT REPLACEMENT IN THE FOLLOWING ORDER: Open the car door.
Page 4
Detach the door armrest panel. Use a plastic trim tool. Remove the door armrest screws. Use a Phillips screwdriver. 4–39 WWW.AUTODOC.CO.UK...
Page 5
Unscrew the door card fasteners. Use a Phillips screwdriver. Detach the door card. Use a plastic trim tool. 5–39 WWW.AUTODOC.CO.UK...
Page 6
AUTODOC recommends: Replacement: door lock – Seat Ibiza 6L1. Do not use excessive force when removing the part as this may damage it. Remove the covers from the window raiser fasteners. 6–39 WWW.AUTODOC.CO.UK...
Page 7
Switch on the ignition. Lower the window glass. Replacement: door lock – Seat Ibiza 6L1. Tip: Continue lowering the window glass until its fasteners become visible. 7–39 WWW.AUTODOC.CO.UK...
Page 8
Switch off the ignition. Detach the power window connector from the door card. 8–39 WWW.AUTODOC.CO.UK...
Page 9
Detach the door lock actuator cable. Unscrew the window glass fasteners. Use a drive socket #10. Use a ratchet wrench. Replacement: door lock – Seat Ibiza 6L1. Tip from AUTODOC experts: To avoid injury, hold the glass when unscrewing the fasteners.
Page 10
Raise the window glass all the way up and secure it on the door frame with masking tape. AUTODOC recommends: To avoid injury, hold the glass when raising it. 10–39 WWW.AUTODOC.CO.UK...
Page 11
Remove the cover from the exterior door handle fastener. Use a plastic trim tool. Unscrew the fastener of the exterior door handle. Use Torx T20. Use a ratchet wrench. 11–39 WWW.AUTODOC.CO.UK...
Page 12
Remove the cover from the exterior door handle fastener. Use a plastic trim tool. Remove the handle-to-lock cable. Use a flat screwdriver. 12–39 WWW.AUTODOC.CO.UK...
Page 13
Unscrew the door lock fasteners. Use XZN #8. Use a ratchet wrench. Detach the mirror adjuster connector from the door. 13–39 WWW.AUTODOC.CO.UK...
Page 14
Detach the wiring harness from the protective cover of the door. Use a clip removal tool. Detach the speaker connector. 14–39 WWW.AUTODOC.CO.UK...
Page 15
Detach the wiring harness from the protective cover of the door. Use a clip removal tool. Detach the mirror adjuster connector from the control unit. 15–39 WWW.AUTODOC.CO.UK...
Page 16
Detach the wiring harness from the protective cover of the door. Use a clip removal tool. Unscrew the fasteners of the protective cover of the door. Use a drive socket #10. Use a ratchet wrench. 16–39 WWW.AUTODOC.CO.UK...
Page 17
Remove the protective cover of the door. Replacement: door lock – Seat Ibiza 6L1. AUTODOC recommends: Do not apply excessive force when removing the part. Otherwise you may damage it. Detach the door lock connector. Use a flat screwdriver. 17–39...
Page 18
Remove the door lock. Use a flat screwdriver. AUTODOC recommends: Replacement: door lock – Seat Ibiza 6L1. Do not use excessive force when removing the part as this may damage it. 18–39 WWW.AUTODOC.CO.UK...
Page 19
Remove the handle-to-lock cable. Use a clip removal tool. Install the handle-to-lock cable. 19–39 WWW.AUTODOC.CO.UK...
Page 20
Install the new lock. Replacement: door lock – Seat Ibiza 6L1. AUTODOC recommends: When installing, do not use excessive force to avoid damage to the part. Attach the door lock connector. 20–39 WWW.AUTODOC.CO.UK...
Page 21
Install the protective cover of the door. AUTODOC recommends: Replacement: door lock – Seat Ibiza 6L1. To avoid damaging the part during installation, do not use excessive force. Screw in the fasteners of the protective cover of the door. Use a drive socket #10. Use a ratchet wrench.
Page 22
Tighten the door lock fasteners. Use XZN #8. Use a torque wrench. Tighten it to 24 nm torque. Install the handle-to-lock cable. Use a flat screwdriver. Replacement: door lock – Seat Ibiza 6L1. Tip from AUTODOC: Check if the door lock is working properly.
Page 23
Install the cover on the exterior door handle fastener. Screw in the exterior door handle fastener. Use Torx T20. Use a ratchet wrench. 23–39 WWW.AUTODOC.CO.UK...
Page 24
Install the cover on the exterior door handle fastener. Tighten the fasteners of the protective cover of the door. Use a drive socket #10. Use a torque wrench. Tighten it to 16 nm torque. 24–39 WWW.AUTODOC.CO.UK...
Page 25
Attach the wiring harness to the protective cover of the door. Attach the speaker connector. 25–39 WWW.AUTODOC.CO.UK...
Page 26
Attach the wiring harness to the protective cover of the door. Attach the mirror adjuster connector to the door. 26–39 WWW.AUTODOC.CO.UK...
Page 27
Attach the wiring harness to the protective cover of the door. Remove the masking tape. 27–39 WWW.AUTODOC.CO.UK...
Page 28
Lower the window glass and install it to its mounting seat in the window raiser mechanism. AUTODOC recommends: To avoid injury, hold the glass when lowering it. Screw in the window glass fasteners. Use a drive socket #10. Use a ratchet wrench.
Page 29
Replacement: door lock – Seat Ibiza 6L1. Tip from AUTODOC experts: To avoid injury, hold the glass when screwing in the fasteners. Do not apply too much force when tightening the fasteners. Overtightening may damage the glass. Tighten the window glass fasteners. Use a drive socket #10. Use a torque wrench. Tighten it to 11 nm torque.
Page 30
Install the covers on the window raiser fasteners. Attach the mirror adjuster connector to the control unit. 30–39 WWW.AUTODOC.CO.UK...
Page 31
Attach the power window connector to the door card. Attach the door lock actuator cable. 31–39 WWW.AUTODOC.CO.UK...
Page 32
Reinstall the door card. AUTODOC recommends: Replacement: door lock – Seat Ibiza 6L1. Do not use excessive force during installation. This may damage the part. Screw in the door armrest fasteners. Use a Phillips screwdriver. 32–39 WWW.AUTODOC.CO.UK...
Page 33
Reinstall the door armrest panel. Make sure you hear a click indicating that it is locked in place. Screw in the door card fasteners. Use a Phillips screwdriver. 33–39 WWW.AUTODOC.CO.UK...
Page 34
Close the car door. 34–39 WWW.AUTODOC.CO.UK...
Page 35
DID YOU FIND THESE INSTRUCTIONS HELPFUL? BECOME A MEMBER OF AUTODOC CLUB! 35–39 WWW.AUTODOC.CO.UK...
Page 36
AUTODOC — TOP QUALITY AND AFFORDABLE CAR PARTS ONLINE AUTODOC MOBILE APP: GREAT DEALS AND CONVENIENT SHOPPING A GREAT SELECTION OF SPARE PARTS FOR YOUR CAR 36–39 WWW.AUTODOC.CO.UK...
Page 37
BUY SPARE PARTS FOR SEAT DOOR LOCK: A WIDE SELECTION 37–39 WWW.AUTODOC.CO.UK...
Page 38
CHOOSE CAR PARTS FOR SEAT IBIZA 6L1 DOOR LOCK FOR SEAT: BUY NOW 38–39 WWW.AUTODOC.CO.UK...
Page 39
DOOR LOCK FOR SEAT IBIZA 6L1: THE BEST DEALS & OFFERS Disclaimer: The document contains only general recommendations that may be useful for you when you perform repair or replacement work. AutoDoc shall not be liable for any loss, injury, damage of property occurring in the repair or replacement process due to incorrect use or misinterpretation of the provided information.
Need help?
Do you have a question about the Ibiza 6L1 and is the answer not in the manual?
Questions and answers