Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for Prestige medical Pouch Sealer
- Page 1 Instructions for use Pouch Sealer...
- Page 2 UK Customer care line: 01254 844 116 E-mail: customerservice@prestigemedical.co.uk The Prestige Medical Customer Service Team is available to provide advice and assistance during normal office hours. To avoid delays when making contact, please have the unit’s Model and Serial Numbers at hand.
-
Page 3: Table Of Contents
Contents Section Page 1: INTRODUCTION ..........................4 FORWARD ............................5 PRESTIGE MEDICAL POUCH SEALER ................... 5 SPECIFICATION ..........................6 INSTRUMENTS ..........................7 2: INSTALLATION ..........................8 GENERAL CONDITIONS ......................8 WALL MOUNTING ........................9 3: OPERATION ..........................10 SETUP ............................. 10 SEALING ............................ -
Page 4: 1: Introduction
1: INTRODUCTION Thank you for choosing the Prestige Medical Pouch Sealer which is used to ensure loads are kept within a water tight and air tight seal for effective autoclaving and sterilization procedure. They are suitable for mainly dentists, beauticians, podiatrists and in certain medical or laboratory settings. -
Page 5: Forward
FORWARD The operator is liable for reading the operating manual and complying with its instructions. Prestige Medical is not liable for any damage to people or things or to the unit should the operator not comply with the operating conditions. -
Page 6: Specification
SPECIFICATION ITEM VALUE UNIT Packet tray Optional Electrical supply voltage and frequency Volt 230 – Hz 50/60 V-Hz Power Length of seal Width of seal Heating Pre-set Start-up Manual Net Weight Seal Duration Seconds Sealing Velocity m / minute Dimensions Width Height Depth... -
Page 7: Instruments
INSTRUMENTS LED OUTPUT INDICATION ACTION Steady green light Apparatus ready for use Use apparatus Green flashing light Heating underway Wait till heating ends Green light flashing ECO-mode (energy saving) Operate the lever to return with reduced the unit to normal frequency operation, otherwise switch the unit off. -
Page 8: 2: Installation
On soft or unstable surfaces or lose ground. If the pouch sealer is to be used continuously or if heavy instruments are to be packaged it is advisable to fit the optional packet tray. If the pouch sealer is to be installed onto a wall or cabinet please follow the instructions on the next page. -
Page 9: Wall Mounting
Check the fixings are secure before mounting the unit. It is advisable to use open hook expansion bolts to allow for easy installation. 3. Carefully lift the pouch sealer over the fixings to support its weight. Tighten the fixings until they are hand tight and the unit is secure. -
Page 10: 3: Operation
Press the ON/OFF switch to the ON position, the LED will then turn green and begin to flash. The heating element will now begin to heat up. Once the LED stops flashing after approximately 3 – 4 minutes the pouch sealer will emit a peep and the heating element will be at its required temperature;... - Page 11 If the lever is left in the down position for more than 10 seconds, the heating element will turn itself off automatically to protect the sealing bag and the components of the pouch sealer. After each sealing cycle the pouch sealer will check its temperature and if necessary it will activate the heater to keep the heating element at the required sealing temperature.
- Page 12 Once the sealing is finished check the seal, tugging lightly on the flaps of the packet. If the operator has left the pouch sealer on and does not use if for at least 30 minutes, it will go into ECO-mode; the sealing bar switches off to prevent damage and energy waste.
-
Page 13: 4: User Maintenance
Prestige Medical will accept no responsibility when procedures recommended by our service engineers are not heeded. In case of failures which cannot be solved please contact Prestige Medical or your local distriputor. www.prestigemedical.co.uk Page 13... -
Page 14: Disposal And Scrapping
DISPOSAL AND SCRAPPING Please dispose of its different parts in accordance with local laws and recycling guidelines. ATTENTION: Prestige Medical is not liable for any damages to systems used for the operation or disposal of the unit. www.prestigemedical.co.uk Page 14... -
Page 15: 5: Important Safety Instructions
Clean with abrasive or corrosive chemicals. Immerse the pouch sealer in water. Use the pouch sealer when sleepy or drowsy. Please use the pouch sealer as instructed in this operating manual. Do not use attachments not recommended by the manufacturer www.prestigemedical.co.uk Page 15 sales@prestigemedical.co.uk... - Page 16 United Cast Bar (UK) Limited, Spital Lane, Chesterfield, Derbyshire, S41 0EX, England Prestige Medical is a registered trademark Paper Please recycle Due to a continuous process of development, Prestige Medical reserves the right to amend the specification of products and services without notice. 5846A...
Need help?
Do you have a question about the Pouch Sealer and is the answer not in the manual?
Questions and answers