Huvema BL 50 AIR Manual
  1. Manuals
  2. Brands
  3. Huvema Manuals
  4. Air Compressor
  5. BL 50 AIR
  6. Manual

Huvema BL 50 AIR Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
A
I
R
C O
M
P
R
E
S
S
O
R
BL 50 AIR

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the BL 50 AIR and is the answer not in the manual?

Questions and answers

Related Manuals for Huvema BL 50 AIR

Summary of Contents for Huvema BL 50 AIR

  • Page 1 BL 50 AIR...

  • Page 2: Table Of Contents

    able of conTenTs General safety rules for all machines Additional safety rules Specification Machine parts Getting started Assembly Installing the wheels Installing the Oil and Oil Breather Installing the Air Filter Operation Before operating your new air compressor Initial Start-Up Procedure General Overview Installation and Location Connecting to Power Source...

  • Page 3: General Safety Rules For All Machines

    1. G eneral safeTy rules for all machines N.B.: Read the instructions carefully in order to avoid any problems. As with all machinery there are certain hazards involved with operation and use of this machine. Using the machine with respect and caution will considerably lessen the possibility op personal injury. However, if normal safety precautions are overlooked or ignored, personal injury to the operator may occur.

  • Page 4: Additional Safety Rules

    2. a ddiTional safeTy rules Always keep in mind that: • the machine must be switched off and disconnected from the power supply during maintenance and repairs, • clamped workpieces may only be measured when the machine is switched off. Never lean over the machine, mind loose clothing, ties, jewellery etc.

  • Page 5: Assembly

    6. a ssembly Note: Before performing any assembly or maintenance make compressor be turned off and unplugged from the power supply. 6.1 i nsTallinG The wheels Locate the wheels, hex bolts, washers, and wheel nuts. Insert hex bolt through wheel rim and wheel bracket in place located on the bottom rear of the air compressor.

  • Page 6: Operation

    7. o peraTion 7.1 b efore operaTinG your new air compressor Please check the following points carefully: Check that all nuts and bolts are secure. Make sure oil has been properly added to compressor. (See installing the Oil and Oil Breather section) 7.2 i niTial TarT...

  • Page 7: Adjusting The Air Pressure

    Your Air Compressor is equipped with an air pressure requlator. This regulator adjust the air pressure. To increase Air Pressure, turn Air Regulator clockwise. To decrease air pressure, turn Air Regulator counterclockwise. 8. m ainTenance DAILY (or before each use) l.

  • Page 8: Troubleshooting

    9. T roubleshooTinG Trouble Possible cause Corrective action Compressor won’t start 1 Blowen fuse or Circuit breaker 1. Replace or Reset Fuse/ Circuit tripped. Breaker 2. Loose electrical connections 2. Check Wiring connections Low Pressure 1. Restricted Air Filter 1. Replace Air filter 2.

  • Page 9: Parts List A

    10.2 p arTs lisT Description Q'TY NO. Description Q'TY Bolt Spring Washer Wheel Plain Washer Spring Washer Capacitor Bearing Drain Valve Oil Seal Tank Stator Stopper Bolt Bolt Spring Washer Plain Washer Cylinder Head Foot Support Elbow Plain Washer Pipe Spring Washer Cylinder Gasket Bolt...

  • Page 10: Explosion Drawing B

    10.3 e xplosion drawinG CHANGES AND T YPING ERRORS RESER VED...

  • Page 11: Parts List B

    10.4 p arTs lisT Description Q’TY Description Q’TY Cover Capacitor Bolt Stator Elbow Gasket Bolt Screw Spring Washer Gasket Plain Washer Ground Connection Cylinder Head Rear Support Air Filter Cylinder Head Gasket Circlip Valve Plate Spring Washer Valve Bolt Aluminum Quick Coupler Valve Plat Gasket Water Filter...
  • Page 12 All rights reserved. No part of this booklet may be reproduced in any form, by print, photoprint, microfilm or any other means without written permission from the publisher. © Huberts bv, Kennedylaan 14, Veghel, the Netherlands. Internet: www.huvema.nl CHANGES AND T YPING ERRORS RESER VED...
  • Page 13 Industrie & Handelsonderneming Huberts bv, Kennedylaan 14, 5466 AA Veghel, the Netherlands, in the capacity of importer, is to be held responsible for declaring that the Huvema machine: Aircompressor BL 50 air which this declaration relates to, is conform the following norms:...

Table of Contents