Trion Grease Viper Series Instructions Manual
  1. Manuals
  2. Brands
  3. Trion Manuals
  4. Fan
  5. Grease Viper Series
  6. Instructions manual

Trion Grease Viper Series Instructions Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Grease Viper Series
READ AND SAVE THESE INSTRUCTIONS
Electrostatic Precipitators
Commercial & Industrial Applications
T R I O N
| w w w . t r i o n i a q . c o m
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Grease Viper Series and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Trion Grease Viper Series

  • Page 1 Grease Viper Series READ AND SAVE THESE INSTRUCTIONS Electrostatic Precipitators Commercial & Industrial Applications T R I O N | w w w . t r i o n i a q . c o m ®...

  • Page 2: Table Of Contents

    I n s t a l l a t i o n , O p e r a t i o n , & S e r v i c e M a n u a l Electrostatic Precipitators for Commercial & Industrial Applications Grease Viper Custom Electronic Air Cleaner Table of Contents...

  • Page 3: Section I - Design

    TRION Tridex Detergent is specially formulated ® • Inlet Plenum Section with Grease Baffle Impinger for use with TRION® electronic air cleaners. Use Prefilters of other cleaners and detergents, not specifically • Electrostatic Precipitator (ESP) with Integral approved by TRION , can cause possible failures ®...

  • Page 4: Outdoor Installations

    Any additional access that may be such as cooking grease and petroleum based provided in the system, where there is access oils. TRION® strongly recommends a fire to high voltage, must be equipped with such suppression system be installed in the ductwork interlocks.

  • Page 5: For The Installing Contractor

    The length of the wash water supply line between the Grease Viper cabinet and the heated building should Adjoining Ductwork (not supplied by TRION be kept to a minimum. Preferably the line would go ® The ductwork located on the air entering side of the...

  • Page 6: Position Air Cleaner Cabinet

    I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l are shipped inside the cabinet. On large units, the cabinet, then re-install the ionizing-collecting cells and cells may be shipped in separate containers.

  • Page 7: Mount Control Panel

    Unless otherwise specified, the water wash supply 9. Check Out for System Start-up should be hot (140°F recommended - WATER When the installation has been completed, assure HEATER NOT SUPPLIED BY TRION ) at the volume that the equipment is ready for start-up by checking ®...

  • Page 8: General Description

    Install cells into 1. Inspect the inside of the adjoining ductwork and the cabinet in accordance with the directional arrows TRION cabinet to be sure it is clean and free of ® w w w. t r i o n i a q . c o m...
  • Page 9 Allen head set facing the access side of the cabinet. screw located in the valve adjustment knob. When 3. Confirm that the drain lines from the TRION cabinet the correct adjustment has been made, remove the ®...

  • Page 10: Wash Control And Detergent System Settings

    I n s t a l l a t i o n , O p e r a t i o n , & S e r v i c e M a n u a l Adjusting Clock Temporary Override Press and hold CLOCK and then press DAY key, HOUR Condition 1: When timer’s output status is ON, press key, MIN key respectively to adjust clock of timer to...

  • Page 11: Routine Maintenance

    ® is formulated specifically for electronic air cleaners. If approved should be checked for securement and substitutes are used, they must be approved by TRION tightened or reworked as required. ® w w w. t r i o n i a q . c o m...

  • Page 12: Troubleshooting

    I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l At the start of the cleaning process, electrical switches Ionizing-Collecting Cell(s) - Every 6 Months Handle cells with care to avoid damage to the that could be accidentally activated shall be locked...
  • Page 13 I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l 1. Disconnect both high voltage leads from their The electronic air cleaner is the unit within the system respective terminals on the power supply and that has the highest efficiency collection rating and is...

  • Page 14: Troubleshooting Reference Chart

    I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l • If the short is in the collector section, look •...

  • Page 15: Spare Parts

    Goods, Seller warrants that installation. For specific recommendations, consult that Goods are free from defects in material and the TRION factory or nearest representative. workmanship, except for services which are warranted ®...
  • Page 16 TRION ® 101 McNeill Rd. | Sanford, NC 27330 P: 800.884.0002 | F: 800.458.2379 | www.trioniaq.com | customerservice@trioniaq.com Form No. 266206-001 Rev. 09/17 © TRION 2017. All Rights Reserved.

Table of Contents