DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE CONTENTS Page Page 1 Safety Precautions 12.9. Disassembly of RAM / Digital P.C.B. Module 1.1. GENERAL GUIDELINES 12.10. Disassembly of DV Jack P.C.B. 1.2. Caution for AC Mains Lead (For GC only) 12.11. Disassembly of VTR Mechanism Unit 1.3.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 1 Safety Precautions 1.1. GENERAL GUIDELINES 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 1.3. Before Repair and Adjustment Disconnect AC power, discharge Power Supply Capacitors C11101, C11104, C11105 and C11106 through a 10Ω, 1W resistor to ground. DO NOT SHORT-CIRCUIT DIRECTLY (with a screwdriver blade, for instance), as this may destroy solid state devices.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 2 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor “chip”...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 4 Handling the Lead free Solder 4.1. General description about Lead Free Solder (PbF) The lead free solder has been used in the mounting process of all electrical components on the printed circuit boards used for this equipment in considering the globally environmental conservation.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 7 Accessories Note : Refer to Replacement Parts List (Section 22) for the part number. Remote control (For GC/GCS) Remote control (For Remote control (For AC Cord (For GN) AC Cord (For GC/GCS/EE)
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 9 Operation Instructions 9.1. (DVD) Taking out the Disc from RAM-Drive Unit when the Disc cannot be ejected by OPEN/CLOSE button 9.1.1. (DVD) Forcible Disc Eject 9.1.1.1. (DVD) When the power can be turned off.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 9.2. (VHS) Removing Cassette Tape manually When the cassette tape could not be uninstalled from an electrical malfunction, there are 2 ways to remove a cassette tape. 9.2.1. (VHS) Removal by compulsory unloading.
Page 37
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 3. Rotate the Main Cam Gear counter-clockwise until just before the unloading will be completed as shown below. . 4. Rotate the Capstan Motor clockwise to remove the slack tape as shown below.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 10 Service Mode 10.1. (DVD) Self-Diagnosis and Special Mode Setting 10.1.1. (DVD) Self-Diagnosis Functions Self-Diagnosis Function provides information for errors to service personnel by “Self-Diagnosis Display” when any error has occurred. U**, H** and F** are stored in memory and held.
Page 39
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Error Code Diagnosis contents Description Monitor Display Automatic FL display UNSUP- Unsupported disc error *An unsupported format disc was played, “This disc PORT although the drive starts normally. incompatible.” *The data format is not supported, although the media type is supported.
Page 40
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Item FL display Key operation Mode name Description Front Key Child lock/unlock Set or release “Child Lock”. Press [ENTER] and [RETURN] by remote controller simultaneously until [X-HOLD] is displayed. NTSC/PAL system select To switch PAL/NTSC altemately.
Page 41
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 10.1.3. (DVD) Service Modes at a glance Service mode setting: While the power is off, press [STOP], [VHS to DVD COPYING] and [OPEN / CLOSE] simultaneously for five seconds (OPERATION SELECT should be set to DVD).
Page 42
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Item FL display Key operation Mode name Description (Remote controller key) I/P Switch Switch Interlace and Progressive in EE mode. Initial mode is Interlace Press [1] [4] in I/P Switch mode. *Initial setting is “Interlace”.
Page 43
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Item FL display Key operation Mode name Description (Remote controller key) RAM Drive Last Error RAM Drive error code display. 1. Error Number is displayed for 5 Press [4] [2] in service mode.
Page 44
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Item FL display Key operation Mode name Description (Remote controller key) AV2(Y/C)/AV1(V) Set input to AV2 (Y/C) and set output to AV1 Press [8] [0] in service mode. I/OSetting (V) for I/O checking...
Page 45
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Item FL display Key operation Mode name Description (Remote controller key) Initialize Service Last Drive Error, Error history and Error Press [9] [9] in service mode. Codes stored on the unit are initialized to factory setting.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 10.2. (VHS) Self-Diagnosis and Special Mode Setting 10.2.1. (VHS) SPECIAL MODES SETTING 10.2.2. (VHS) SERVICE MODES...
Page 47
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 10.2.3. (VHS) SELF-DIAGNOSIS FUNCTIONS This model has a self-diagnosis. If the VHS section detects trouble during installation or during use, the power is automaticallyturned off or become power-save mode and it is memorized into the EEPROM (IC37501) as error code of two-digit number.
Page 48
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE in succession) 10.2.3.1.3. CLEAR FOR THE SELF-DIAGNOSIS HISTORY 1. Press STOP and EJECT buttons simultaneously over 5 seconds during turning on Service Information Display mode. 10.2.3.1.4. INDICATION OF THE SELF-DIAGNOSIS HISTORY The self-diagnosis histories can be indicated on the FIP with Service Mode number 3 to 5.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 12 Assembling and Disassembling 12.1. Caution “ATTENTION SERVICER” Some chassis components may be have sharp edges. Be careful when disassembling and servicing. 1. This section describes procedures for checking the operation of the major printed circuit boards and replacing the main components.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 12.2. Disassembly Flow Chart The following chart is the procedure for disassembling the casing and inside parts for internal inspection when carrying out the servicing. To assemble the unit, reverse the steps shown in the chart below.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 12.4. Caution with inserting cassette tape when disassembling the unit Note1: For description of the disassembling procedure, see the section 12.5. Note2: Video Cassette might not enter when a strong lighting is applied to VHS Mechanism when Video Cassette is inserted. Please...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 12.5. Disassembly of Top Panel 12.6. Disassembly of Nicam Decoder P.C.B. Step 1 : Remove 4 Screws (A) and 3 Screws (B). Step 2 : Slide Top Panel rearward and open the both ends at ·...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 12.7. Disassembly of Front Panel Note: · Follow the (step 1) - (step 2) of item 12.5. When attaching Front Panel, in order to hook Cassette Door Opener Lever to Cassette Door, push up cassette Step 1 : Remove 1 screw (A).
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 13 Measurements and Adjustments 13.1. Service Positions Note: For description of the disassembling procedure, see the section 12. 13.1.1. Checking and Repairing of RAM / Digital P.C.B. Module...
Page 62
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 13.1.2. Checking and Repairing of Panel, Front Jack and Digital I/F P.C.B.
Page 63
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 13.1.3. Checking and Repairing of Main P.C.B.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 13.2. Caution for Replacing Parts 13.2.1. Notice for replacing parts of VHS Mechanism 13.2.1.1. Regarding change of parts of VHS mechanism...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 13.3. Standard Inspection Specifications after Making Repairs After making repairs, we recommend performing the following inspection, to check normal operation. Procedure Item to Check Turn on the power, and confirm items pointed out.
Page 70
Perform auto recording and playback for one minute using the RAM No abnormality should be seen in the picture, sound or operation. disc. *Panasonic DVD-RAM disc should be used when recording and playback. If a problem is caused by a VCD, DVD-R, DVD-Video, Audio-CD, or No abnormality should be seen in the picture, sound or operation.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 14 Miscellaneous INITIAL/LOGO ABBREVIATIONS ERROR TORQUE CONTROL ERROR TORQUE CONTROL 14.1. Abbreviations REFERENCE ENCSEL ENCODER SELECT ETMCLK EXTERNAL M CLOCK (81MHz/40.5MHz) 14.1.1. DVD ETSCLK EXTERNAL S CLOCK (54MHz) FBAL FOCUS BALANCE INITIAL/LOGO ABBREVIATIONS...
Page 72
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS READ ENABLE VBLANK V BLANKING RFENV RF ENVELOPE COLLECTOR POWER SUPPLY RF PHASE DIFFERENCE OUTPUT VOLTAGE (CD-ROM) REGISTER SELECT VCDCONT VIDEO CD CONTROL (TRACKING RSEL RF POLARITY SELECT BALANCE)
Page 73
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 14.1.2. VHS 4.43 NTSC L 443NT [L] BILINGUAL BILINGUAL L A. COMP AUDIO COMPONENT SIGNAL BIL [L] BILINGUAL H BIL. [H] A. COMPO AUDIO COMPONENT SIGNAL BILINGUAL L AUDIO DUBBING PAUSE L BIL/M1 [L] A.
Page 74
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE CYL GND CYLINDER GND FULL. E. 12V FULL ERASE 12V DELAIED FM RECORDING H D.F.M. REC [H] GND [A] GND (ANALOG) DELAIED FM RECORDING L D. FM REC [L] GND [TU] GND (TUNER) D.
Page 75
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE POWER OFF H LINE IN [R] LINE INPUT (R) P-OFF [H] POWER OFF L LINE OUT [L] LINE OUTPUT (L) P-OFF [L] LINE OUT [R] LINE OUTPUT (R) P. FAIL POWER FAILURE DETECT...
Page 76
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE RF OUT RF OUTPUT SYSCON 5V SYSTEM CONTROL 5V RF Y RF LUMINANCE SIGNAL SYSTEM SYSTEM SW RF. Y. IN RF LUMINANCE SIGNAL INPUT T-PHOTO TAKE-UP PHOTO TRANSISTOR RF. Y. OUT RF LUMINANCE SIGNAL OUTPUT T-RL.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 15 Voltage Measurement and Waveform Chart Note: · Indicated voltage values are the standard values for the unit measured by the DC electronic circuit tester (high-impedance) with the chassis taken as standard. Therefore, there may exist some errors in the voltage values, depending on the internal impedance of the DC circuit tester.
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 17 Block Diagram 17.1. Analog Audio Block Diagram DVD AUDIO SIGNAL AUDIO MAIN SIGNAL PATH IN REC MODE AUDIO MAIN SIGNAL PATH IN PLAYBACK MODE IC4501 IC3001 AN3656NFBPBV FROM C1AB00002084 (AUDIO PROCESSOR) Q4001, D.REC...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 17.3. Analog Video Block Diagram :DVD VIDEO EE SIGNAL :REC SIGNAL :PB SIGNAL JK3902 REAR A/V OUT JACK IC3701 C1AB00002490 (VIDEO I/O PROCESSOR) CPN V OUT VIDEO C-SW C2 OUT CPN Y OUT...
Page 90
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE :DVD VIDEO EE SIGNAL :REC SIGNAL :PB SIGNAL IC3001 C1AB00002084 (AUDIO/VIDEO SIGNAL PROCESSOR) 2MHz SQUELCH -6dB -4dB Q3004 SYSTEM CONTROL SECTION CLEAR OSD V IN SQUELCH V-AMP SYNC IC6001- VIDEO FEED BACK NTSC/PAL...
Page 92
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE IC4801 C0CBCDC00027 (REG.+9V) D +3.8V P37101 P9001 48,50 IC45001 X SW +12.5V P31902 P6004 X SW +12.3V V IN V OUT C0DBAHD00013 IC3701- (REG.AU +5V) DIGITAL P.C.B. ON/OFF AU +5V P37101 P9001 V IN...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 18 Notes of Schematic Diagram (All schematic diagrams may be modified at any time with the development of new technology) Note : S1531 Safety TAB switch S1532 MODE switch S7701 V2D switch S7702...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 19 Schematic Diagram 19.1. DIGITAL IF CIRCUIT SCHEMATIC DIAGRAM - 1 : - B SIGNAL LINE Q11601 DIGITAL IF (POWER) CIRCUIT B1DHED000008 : +B SIGNAL LINE 12V REGULATOR D11401 T11101 L11401 MECHA_12R5V G4DYA0000038...
Page 98
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 2 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE DIGITAL IF (DVD_IF) CIRCUIT : +B SIGNAL LINE : DVD RECORDING VIDEO SIGNAL LINE...
Page 99
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 3 : -B SIGNAL LINE DIGITAL IF (DVD_IF) CIRCUIT : +B SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE P:Digital IF (Power): Schematic Diagram 1 IF:Digital IF (DVD_IF): Schematic Diagram 2-5...
Page 100
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 4 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE DIGITAL IF (DVD_IF) CIRCUIT : +B SIGNAL LINE : DVD RECORDING VIDEO SIGNAL LINE...
Page 101
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE AE AF AH AI AK AL AM AN AO AP AQ DIGITAL IF (DVD_IF) SCHEMATIC DIAGRAM - 5 (2/4) : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 19.2. MAIN CIRCUIT SCHEMATIC DIAGRAM - 6 V:MAIN (VIDEO): Schematic Diagram 14-47 A:MAIN (VHS AUDIO): Schematic Diagram 18 DIGITAL IF (DVD_IF) MAIN (SYSCON/SERVO/TIMER) CIRCUIT CIRCUIT (P31905) ON : +B SIGNAL LINE S:MAIN (SYSCON/SERVO/TIMER): Schematic Diagram 6-9...
Page 103
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 7 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE MAIN (SYSCON/SERVO/TIMER) CIRCUIT : +B SIGNAL LINE : DVD RECORDING VIDEO SIGNAL LINE...
Page 104
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 8 : -B SIGNAL LINE : MAIN VIDEO SIGNAL LINE MAIN (SYSCON/SERVO/TIMER) CIRCUIT : +B SIGNAL LINE : MAIN AUDIO SIGNAL LINE MAIN (SYSCON/ SERVO/TIMER) (1/4) IC6002 R7511 8.2K PFAIL...
Page 105
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 9 MAIN (SYSCON/SERVO/TIMER) CIRCUIT : +B SIGNAL LINE AK AL AN AO AP AQ AR AS AT AU AX AY MAIN (SYSCON/ W732 W728 W729 W758 W721 SERVO/TIMER) (2/4) W725...
Page 106
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 10 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE : MAIN VIDEO SIGNAL LINE : VCR PLAYBACK VIDEO SIGNAL LINE : VCR PLAYBACK AUDIO SIGNAL LINE...
Page 107
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 11 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE : MAIN VIDEO SIGNAL LINE : VCR PLAYBACK VIDEO SIGNAL LINE : VCR PLAYBACK AUDIO SIGNAL LINE...
Page 108
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 12 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE : MAIN VIDEO SIGNAL LINE : VCR PLAYBACK VIDEO SIGNAL LINE : VCR PLAYBACK AUDIO SIGNAL LINE...
Page 109
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 13 : -B SIGNAL LINE : DVD PLAYBACK VIDEO SIGNAL LINE : DVD PLAYBACK AUDIO SIGNAL LINE : MAIN VIDEO SIGNAL LINE : VCR PLAYBACK VIDEO SIGNAL LINE : VCR PLAYBACK AUDIO SIGNAL LINE...
Page 111
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 15 MAIN (VIDEO) CIRCUIT : +B SIGNAL LINE TO AUDIO TO FULL CONTROL HEAD ERASE HEAD CYLINDER UNIT W779 C2099 680P W764 K4081 0 R2099 6.8K LOCATION MAP V:MAIN (VIDEO): Schematic Diagram 14-47...
Page 114
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE SCHEMATIC DIAGRAM - 18 : -B SIGNAL LINE : VCR PLAYBACK AUDIO SIGNAL LINE : TV TUNER AUDIO SIGNAL LINE MAIN (VHS AUDIO) CIRCUIT : +B SIGNAL LINE : VCR RECORDING AUDIO SIGNAL LINE...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 19.4. FRONT JACK CIRCUIT SCHEMATIC DIAGRAM - 20 : MAIN VIDEO SIGNAL LINE FRONT JACK CIRCUIT : MAIN AUDIO SIGNAL LINE R7802 8.2K R7805 3.9K R7802 R7806 2.7K R7804 3.9K 3.9K R7803 2.7K...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 19.5. NICAM DECODER CIRCUIT SCHEMATIC DIAGRAM - 21 : -B SIGNAL LINE : TV TUNER AUDIO SIGNAL LINE NICAM DECODER CIRCUIT : +B SIGNAL LINE : NICAM AUDIO SIGNAL LINE C7335 K7302 0...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 19.6. DV JACK CIRCUIT SCHEMATIC DIAGRAM - 22 DV JACK CIRCUIT : +B SIGNAL LINE P66802 K1MY20BA0049 DAT1 DAT0 DAT3 DAT2 D3R3V DIGITAL (BE) CIRCUIT D3R3V (P53501) TL66801 TPA+ TPA- TPB+ TPB- TL66802...
Page 119
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE IC11201 IC11301 SWITCHING IC SWITCHING IC IC-DETAIL BLOCK DIAGRAM IC-DETAIL BLOCK DIAGRAM DRAIN UVLO UVLO UVLO UVLO START-UP DRAIN START-UP LATCH RELEASE/ LATCH RELEASE/ CIRCUIT CIRCUIT OVER VOLTAGE OVER VOLTAGE PROTECTOR/ PROTECTOR/ OVER HEATING...
Page 120
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE IC2501 IC7501 LOADING/CYLINDER MOTOR DRIVE MICRO PROCESSOR IC-DETAIL BLOCK DIAGRAM IC-DETAIL BLOCK DIAGRAM OUT 1 F IN CONTROL PRE-DRIVE LOGIC OUT 2 R IN Port P0 Port P1 Port P2 Port P3 Port P4...
Page 121
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE IC3701 IC6001 VIDEO/AUDIO PROCESSOR MICRO PROCESSOR IC-DETAIL BLOCK DIAGRAM IC-DETAIL BLOCK DIAGRAM C-SW C75 OUT DVD C IN 6.7M C75 SAG S1/S2 BIAS Clock Generating Circuit Instruction Register V-SW DVD Y IN Y/C MIX 6.7M...
Page 122
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE IC3002 IC45001 IC37001 IC31501 IC31503 JC +5V SWITCHING REG. X SW+6V SWITCHING REG. FAN MOTOR DRIVE ANA +5V SWITCHING REG. ANA +3.3V SWITCHING REG. IC-DETAIL BLOCK DIAGRAM IC-DETAIL BLOCK DIAGRAM IC-DETAIL BLOCK DIAGRAM...
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE 22 Replacement Parts List Notes: · Important safety notice: Components identified by mark have special characteristics important for safety. Furthermore, special parts which have purposes of fire-retardent (resistors), high-quality sound (capacitors), low noise (resistors), etc are used.
Page 132
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks VML3934 MAIN LEVER 2 IC11201 C0DACZH00026 IC VOLTAGE REGULATOR VML3933 PINCH CHARGE ARM 2 IC11301 C0DACZH00026 IC VOLTAGE REGULATOR...
Page 133
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks QR11802 UNR521300L DIGITAL TRANSISTOR PK7301 K1MM07B00002 7P CONNECTER PK7302 K1MM06B00002 6P CONNECTER DIODES PP4801 K1KA10B00196 10P CONNECTOR...
Page 134
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks LB3107 J0JCC0000103 BEED CORE LB3108 J0JCC0000103 BEED CORE F11101 K5D202BK0005 FUSE LB3110 J0JCC0000103 BEED CORE LB3111 J0JCC0000103...
Page 135
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks W742 ERJ6GEY0R00V CHIP JUMPER W743 ERJ6GEY0R00V CHIP JUMPER RPG7878-1 PACKING CASE [M]EE W744 ERJ3GEY0R00V CHIP JUMPER RPG7879-1...
Page 136
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R3704 D0GB221JA041 220 1/16W R4803 ERJ3GEYJ681V 680 1/16W R3705 D0GB105JA007 1M 1/16W R4804 ERJ3GEYJ681V 680 1/16W R3706...
Page 137
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R6801 D0GB104JA007 100K 1/16W R7586 D0GB392JA007 3.9K 1/16W R6802 ERJ3GEY0R00V 0 1/16W R7590 D0GB472JA041 4.7K 1/16W R6803...
Page 138
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R11707 ERJ6GEYG821V 820 1/10W C2504 F1H1E223A002 0.022 25V R11708 ERJ6GEYG101V 100 1/10W C2505 F1H1E223A002 0.022 25V R11709 ERJ6GEYG242V 2.4K 1/10W...
Page 139
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C3714 ECA1CAK100XB 10 16V C4538 F1H1H103A220 0.01 50V C3716 F1H0J1050010 1 6.3V C4541 F1H1H101A230 100P 50V C3717 F1H0J1050010 1 6.3V...
Page 140
DMR-ES35VGN / DMR-ES35VGC / DMR-ES35VGCS / DMR-ES35VEE Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C7302 ERJ3GEY0R00V 0 1/16W C7558 F1H0J1050010 1 6.3V C7303 F2A0J101A013 100P 6.3V C7559 F1H1H101A230 100P 50V C7305 F2A0J101A013 100P 6.3V...