Advertisement
Quick Links
8
Owner' sf Operator's Manual
Sauna heater installation, wiring,
operating instructions, troubleshooting,
maintenance and guarantee.
IMPORTANT! This manual must
be left with owner, manager, or
operator of Sauna after it is used by
electrician!
MODEL
HCT105-1
HCT120-1
HCT144-1
CONTROLS
F-2T
F-2
, . ,
... . ,
.
�
co�M ���
T
,
�
�
�
�
UL STD 875
us
CERTIFIED TO
c
,,....
CAN/CSA STD
3159549
E60335-2-53-05
MODEL
HCT105-3
HCT120-3
HCT144-3
CONTACTORS
FX404
FX503
o
1
81205_NC
Advertisement
Summary of Contents for Thermasol HCT105-1
- Page 1 Sauna heater installation, wiring, operating instructions, troubleshooting, maintenance and guarantee. IMPORTANT! This manual must be left with owner, manager, or operator of Sauna after it is used by electrician! MODEL MODEL HCT105-1 HCT105-3 HCT120-1 HCT120-3 HCT144-1 HCT144-3 CONTACTORS CONTROLS FX404...
- Page 2 81205_NC...
- Page 3 Fi g ure 3 . MODEL INPUT MIN. HEIGHT FLOOR AREA SAUNA ROOM MIN. SPACING FROM ADJACENT SURFACE (INCHES) MIN. MAX. MIN. MAX. SO.FT. SQ.FT. CU.FT. CU.FT. HCT105-1 10.0 5" HCT105-3 HCT120-1 12.5 6" HCT120-3 HCT144-1 15.0 1000 6" HCT144-3 Table 1. 81205_NC...
- Page 4 CONTROL CONT ACTOR breaker to load center contactor to heater MODEL DRAW SIZE 3.75" X 2.5" load center to contactor TO USE X 9.25" HCT105-1 10,000 240/1 41.7 #6 copper (4) #10 (4) #10 F-2T FX404 HCT120-1 12,600 240/1 52.7...
- Page 5 Power source: 208V, three phase power into contactor box SAUNA CONTROL F-2T CONTACTOR BOX G�� FX503 001---------------- ---- ------------�: ____ :::: :::: :: : :::::::::::::� --=- ---�-------� ---- ------ All Contactor Thermostat to Control wiring is #14 wire • • Tenninal Block :.:;...
- Page 6 81205_NC...
- Page 7 #8 copper Table 1. Overheating limiter Overheating limiter Sensor Sensor GND L 1 GND L 1 Figure 9. Electrical connections of 240 V 1-phase Figure 10. Electrical connections of 208 V 3-phase heaters (HCT105-1, HCT120-1, HCT144-1) heaters (HCT105-3, HCT120-3, HCT144-3) 81205_NC...
- Page 8 81205_NC...
-
Page 9: Overheating Limiter
warranty on parts is void if installer/electrician Ventilation fails follow necessary wiring information should be provided by lower vent close to heater, provided or fails to follow code for proper wire 4" from floor, and upper vent on opposite wall size, amperage, etc. -
Page 10: Maintenance Instructions
MAINTENANCE INSTRUCTIONS Use only clean water on Sauna stones. Do not use spa or pool water as it will destroy your heater. Clean water should always be used in Sauna buckets and water should be dumped out after every use. Scour buckets and dippers occasionally when film collects from usage. Use plastic bucket liner in bucket to prevent water leakage. - Page 11 Sauna stones, as chemicals are harmful to purchaser. the heater; the Sauna room must be heated for at SAUNA HEATER MODEL NUMBER DATE OF PURCHASE ORIG INAL OWNER ADDRESS PURCHASED FROM ELECTRICAL CONTRACTOR MUST SIGN HERE DA TE OF ELECTRICAL WIRING & HOOKUP THERMASOL 800-776-0711 81205_NC...
-
Page 12: Spare Parts
SPARE PARTS HEATERS SAUNA HCT105-1, HCT120-1, HCT144-1 HCT105-3, HCT120-3, HCT144-3 /,1/;4 5 Stone compartment �6 Stone holder Base plate Top part Casing side UR Casing FRONT/REAR Electrical casing Electrical casing R Electrical casing L Radiation shield HCT105-1 10 kW 1640 W/240 VI ZSS-110...
Need help?
Do you have a question about the HCT105-1 and is the answer not in the manual?
Questions and answers