Summary of Contents for Wood master COMMERCIAL Series
- Page 1 WOODMASTER COMMERCIAL SERIES Retain this manual Cyclone Separator www.woodmaster.com / 800-932-3629 / Manual PN: 7994-405 Northwest Manufacturing, Inc / 600 Polk Ave SW / Red Lake Falls, MN 56750 Rev: 2.1...
-
Page 2: Table Of Contents
IMPORTANT! THIS MANUAL CONTAINS ALL THE NECESSARY INFORMA- TION FOR THE CORRECT AND SAFE OPERATION OF THE CY- CLONE SEPARATOR� IT MUST BE CAREFULLY READ BEFORE INSTALLATION, AND ALL MAINTENANCE AND REPAIR OPERATIONS� Commercial Series Cyclone Owners Manual April 2012... -
Page 3: General Information
• Be familiar with and observe all instructions included in the present manual in order to operate the Cyclone Separator safely • Respect the Laws relating to the prevention of accidents in the workplace April 2012 Commercial Series Cyclone Owners Manual... - Page 4 Cyclone Separator for purposes other than those specified; i. use of the Cyclone Separator without its safety devices or with them deactivated. Commercial Series Cyclone Owners Manual April 2012...
-
Page 5: Safety
• Read and follow these directions carefully. Retain this manual for as long as you own your Cyclone Separator. April 2012 Commercial Series Cyclone Owners Manual... - Page 6 Protective gloves must be used during all maintenance and cleaning operations. PROTECTIVE HELMET IS MANDATORY During every transport or handling operation PROTECTIVE MASK IS MANDATORY During maintenance and cleaning operation on the flues. EYE PROTECTION IS MANDATORY During every operation. Commercial Series Cyclone Owners Manual April 2012...
-
Page 7: Features
The solid parts, separated from the fumes by the cen- trifugal force and by the abrupt change in direction are accumulated in a bucket placed at the base of the cylinder outlets. April 2012 Commercial Series Cyclone Owners Manual... - Page 8 Manufacturer refers to the test combustible as established by table 8 of Law EN 303-5 included in part C “com- pressed wood” (pellets). Commercial Series Cyclone Owners Manual April 2012...
- Page 9 Cyclone Weight N° MTC500 1510 1260 1150 100x140 0.18 MTC1000 1600 1200 1100 112x160 MTC2000 2200 1900 1600 125x180 MTC4000 2600 2300 1000 2000 200x280 MTC8000 3300 3000 1400 1000 2500 280x400 1150 April 2012 Commercial Series Cyclone Owners Manual...
-
Page 10: Transport & Installation
Testing may be carried out only once the Cyclone Separator has been installed completely, that is, positioned and levelled out, and connected to the electrical panel, heat generator and chimney vent. Cyclone Separator installation must be completed by qualified personnel. Commercial Series Cyclone Owners Manual April 2012... -
Page 11: Operation
A speed that is too high results in: • the excessive transport of hot ashes in the Cyclone Separator • poor filtration due to the transport of average sized solid particles for the curren fluid flow effect April 2012 Commercial Series Cyclone Owners Manual... -
Page 12: Cleaning
Disconnect power to the fan before cleaning or servicing, and allow to cool. Refer to the manual for the fan for proper cleaning procedures. WARNING! BEFORE CLEANING THE SEPARTOR, ENSURE THAT THE POWER IS DISCONNECTED Commercial Series Cyclone Owners Manual April 2012... -
Page 13: Maintenance
Once the Cyclone Separator has been decommissioned, it is considered “waste” as defined by national and European laws and must be handed over to companies that have a Regional Authorization to collect waster. April 2012 Commercial Series Cyclone Owners Manual... -
Page 14: Notes
Notes Commercial Series Cyclone Owners Manual April 2012... -
Page 15: Warranty
System in an unsuitable location or continuing use of the System after onset of a malfunction or discovery of a defect. V. This Warranty only covers manufactures defects and will not cover damage caused by ash corrosion. April 2012 Commercial Series Cyclone Owners Manual... - Page 16 VII. Northwest Manufacturing, Inc. shall not be responsible for any consequential damages, direct or indirect caused by the products described in this Warranty. VIII. The Warranty for this System is also subject to the terms of the Warranty for the WoodMaster Commercial Series Boiler.
- Page 17 Northwest Manufacturing Inc. PLACE POSTAGE 600 Polk Ave. SW HERE Red Lake Falls, MN 56750 Northwest Manufacturing Inc. 600 Polk Ave. SW Red Lake Falls, MN 56750...
- Page 18 Would you like information on other products from Northwest Manufacturing, Inc.? I have read the owners manual and understand the proper usage of my Boiler. Customer’s Signature Printed Name Contractor’s Signature Printed Name Thank you for purchasing a WoodMaster Commercial Series Boiler.
-
Page 19: Notes
Notes April 2012 Commercial Series Cyclone Owners Manual... - Page 20 / 800-932-3629 / Manual PN: 7994-400 Northwest Manufacturing, Inc / 600 Polk Ave SW / Red Lake Falls, MN 56750 Commercial Series Cyclone Owners Manual...
Need help?
Do you have a question about the COMMERCIAL Series and is the answer not in the manual?
Questions and answers