Summary of Contents for ORBITEC Star-Tek Alliance S3
Page 1
USER MANUAL Star-Tek Alliance Electric Treatment Table Model S3 - with Side Bar Lift Controller USA version – July 2019 revision IT IS YOUR RESPONSIBILITY TO READ THIS USER MANUAL. It only takes a few minutes and it will make you a better caregiver! IMPORTANT SAFETY ISSUES! WARNINGS, CAUTIONS...
Introduction Congratulations on your decision to purchase this Star-Tek Alliance (STA) Model S3 Medical Treatment Table! We appreciate your business! Our Product Development Team strives to provide the very best value and performance with every product. This electric Model S3 with Side Bar lift controllers was developed to maximize stability, patient &...
Important General Warnings 1. ONLY use this table indoors, on a dry, flat, level floor. 2. ALWAYS plug table directly into grounded (3 prong) power wall outlet. DO NOT use extension cords or power junction boxes. 3. ALWAYS check for obstructions above and below the table top before raising or lowering.
General Safety & Use Information 1. The table top can be lifted without power by two people if an object or person is caught in the lifting mechanism. Lift from the center of each side if possible, for best results. 2.
Load Distribution & Weight Lift Capacity All therapists who will operate the table must know this information. Load Distribution per Individual Section Mid Section Head Section Foot Section Max Load Max Load Max Load 495-lbs 80-lbs 80-lbs TABLE CENTER FOOT SECTION HEAD SECTION TILT TILT...
General Product Overview Head Section Tilt Control Lever Side Bar Lift Controllers not shown above Foot Section Tilt Control Lever Side Bar Lift Controller...
Head & Foot Section Tilt Operation Caution: Both Head Section & Foot Section are supported by twin Gas Spring mechanisms. Pressing a Control Lever unlocks the Gas Springs. They are VERY POWERFUL pushing upward. Position your hands as shown in the diagrams below to HOLD the table top BEFORE you press a Tilt Control Lever.
Side Bar Lift Control Operation The Side Bar Lift Control is designed to be foot operated: A – Ascending the table up requires the bar to be pressed down. B – Descending the table down requires the bar to be lifted by your toe. EMERGENCY SAFETY FEATURE The table top can be lifted without power by two people if an object or person is caught in the lifting mechanism.
Castor Lift / Drop STA tables use a design that enables all four castors to be raised or lowered with one mechanism. Use the Castor Foot Bar located at the head end of the table Castor Drop = Table Lift Step down on the Castor Foot Bar to lift the table on to the castors.
Leveling Foot Adjustment Proper adjustment = maximum table rigidity, stability, and patient comfort. Initial Table Set-up: Each corner post is supported by an adjustable Leveling Foot. These are installed at the factory in the full-up position. The diagram to the right shows the castors dropped (table lifted) and a 2cm (3/4inch) height.
Table Relocation to a new Facility: If there is a need to move your STA table to a new facility. STA strongly recommends that you request a professional move from our trained moving experts. They will eliminate all your worry, prevent damage, and set-up the table in your new location ready to use.
General Service Information Star-Tek Alliance Treatment Tables are delivered by our trained professional movers. They place the table in your desired location. They adjust the leveling feet and test the operation of the gas springs and motorized up and down functions. •...
Troubleshooting The Motor Control Box has a green LED light to indicate if it is receiving power. When a Side Bar (lift control) is lifted or lowered, green and yellow LED lights indicate proper operation. If you encounter a problem with the table, some suggestions are provided below to remedy the situation.
Product Regulatory Compliance Manufacturing & Quality Management ANSI/AAMI/ISO 13485 Medical Devices, Quality Management Systems, Requirements for Regulatory Purposes Safety IEC 60601-1:2005+AMD1:2012 CSV: Medical electrical equipment – Part1: General requirements for Basic Safety and Essential Performance of Medical Tables, Beds or Couches IEC 60601-1-2:2007, Section 6.1 and 6.2: Medical electrical equipment –...
Manufacturer’s Standard Warranty Star-Tek Alliance warrants that the following parts shall be free from manufacturing defects in materials and workmanship within the periods listed below: 1-Year Warranty • Upholstery • Castors & Lift System • Head Section & Foot Section Adjust Mechanisms including Gas Springs •...