Summary of Contents for Pilot Air TRADEMASTER Series
Page 1
FAX :(02) 9648 3362 FAX :(07) 3279 1762 FAX :(02) 9648 3362 FAX: (08) 8347 4660 FAX :(08) 9277 4040 INSTRUCTION AND PARTS LIST MODEL: TRADEMASTER ____________________________________________________________________________________________________ PILOT AIR COMPRESSORS: THE FIVE “S” ADVANTAGE SUPERIOR PRODUCT, SPECIALISTS, SERIES, SUPPORT, SERVICE www.pilotair.com.au...
USER GUIDE Congratulations on the purchase of a PILOT air compressor. This unit has been designed to provide reliable and trouble fee usage in servicing your compressed air requirements. Please take a moment to familiarise yourself with the information contained in the following sections of this guide before attempting to operate this unit.
Page 3
The air receiver is equipped with a safety valve to release pressure in the event of a pressure switch cut-out failure. To prevent damage to the unit, do not attempt to modify, bypass or remove the pressure switch or safety valve in anyway. The motor features a manual overload protection (where fitted).
MAINTENANCE INSTRUCTIONS • Check that fuses or circuit breakers correspond to motor rating. In case of 415-Volt units, check rotation as indicated by arrow attached to unit. On 240-Volt units, avoid using extension leads as they could cause voltage drop and power loss to motor. If extension is to be used, please follow the table below.
Page 5
NOTE: DO NOT BOLT COMPRESSOR DIRECTLY ONTO FLOOR. THIS MAY CAUSE CRACKS IN THE AIR RECEIVER. PLACE COMPRESSOR ON THE RUBBER VIBRATION PADS PROVIDED. IF THE COMPRESSOR MUST BE BOLTED, ENSURE RUBBER VIBRATION PADS ARE IN PLACE AND FASTEN, LEAVING A GAP BETWEEN BOLT HEAD OR NUT AND COMPRESSOR FOOT TO AVOID ANY METAL TO METAL CONTACT.
Page 6
THREE YEAR PUMP WARRANTY INFORMATION Models covered the three year pump warranty are listed below: • TRADEMASTER SERIES UNITS • CLASSIC K SERIES UNITS • PETROL INDUSTRIAL SERIES UNITS • THREE PHASE INDUSTRIAL SERIES UNITS Details are as outlined below: •...
Parts repaired or replaced without charge under warranty are warranted only during the balance of the new warranty period. All defective parts under the warranty become the property of PILOT AIR COMPRESSORS PTY LTD. This warranty however, shall not apply to the following parts or conditions: •...