Subscribe to Our Youtube Channel
Summary of Contents for BENDIXKing AeroPower
- Page 1 AeroPower USB Charging Port Installation Instructions AeroPower USB Charging Port Installation Instructions Document Number Last Revised Sheet 7 January 2019 1 of 13 600840-000055...
- Page 2 Rev. 1.0 Last Revised: January 7, 2019 AeroPower USB Charging Port This document is applicable to the BendixKing AeroPower USB Charging Port. Honeywell International Inc., 9201-B San Mateo Blvd NE, Albuquerque, NM 87113 USA. Visit us on the web at www.bendixking.com.
-
Page 3: Table Of Contents
Technical Assistance ........................11 Appendix A ..........................12 List of Figures Figure 1: Mounting location ......................8 Figure 2: Installing AeroPower USB Charging Port ..............9 Figure 3: Harness ........................10 Figure 4: Back of AeroPower ....................10 List of Tables Table 1: TSO compliance ......................6 Table 2: TSO deviations ...................... - Page 4 600840-000055 AeroPower USB Charging Port Installation Instructions Rev. 1.0 Last Revised: January 7, 2019 Record of Revision Revision Change Description Revision Date Inserted By Number Initial Release 1/7/19 VJMJ Page 4 of 13...
- Page 5 600840-000055 AeroPower USB Charging Port Installation Instructions Rev. 1.0 Last Revised: January 7, 2019 Related Documentation Document Number Title 600845-000029 AeroPower USB Charging Port Maintenance Manual Acceptable Methods, Techniques, and Practices - Aircraft FAA AC 43.13-1B Inspection and Repair Acceptable Methods, Techniques, and Practices - Aircraft FAA AC 43.13-2B...
-
Page 6: About Aeropower Usb Charging Port
Last Revised: January 7, 2019 1. About AeroPower USB Charging Port 1.1. Overview AeroPower USB Charging Port is a dual 2.1 amp USB charging hub used to power and charge electronic devices in the cockpit. 1.2. TSO compliance AeroPower USB Charging Port is compliant with the following Technical Standard Order:... -
Page 7: Required Tools
Connector Terminals Table 5: Supplied hardware 1.8. Unpacking/inspection requirements When unpacking AeroPower, visually inspect for any damage to the unit or missing components. If damage or missing parts are present, contact BendixKing. 1.9. Limitations for installation This article meets the minimum performance and quality control standards required by a technical standard order (TSO). -
Page 8: Mounting Aeropower Usb Charging Port
Figure 1. Then, cut the notch in the top of the hole. Figure 1: Mounting location 4. Place the AeroPower unit behind the panel and align the front of the unit with the hole. Place the panel cover over the front of the unit and secure with screws. -
Page 9: Wiring Aeropower Usb Charging Port
AC 43.13-2B. Wire length and routing will vary by installation. The installer must also supply a circuit protective device for use with AeroPower USB Charging Port. Use a 2A breaker for 28V aircraft and a 4A breaker for 14V aircraft. -
Page 10: Figure 3: Harness
Measure the voltage across the two wires using a multimeter. The voltage reading should be equal to your aircraft power. d. Disconnect aircraft power. 3. Connect the power receptacle into the header on the back of AeroPower USB Charging Port. Figure 4: Back of AeroPower... -
Page 11: Troubleshooting
600840-000055 AeroPower USB Charging Port Installation Instructions Rev. 1.0 Last Revised: January 7, 2019 4. Connect aircraft power and ensure that the breaker is pushed in. 5. Verify the voltage output of AeroPower before connecting any devices. 4. Troubleshooting Problem Troubleshooting Steps ... - Page 12 600840-000055 AeroPower USB Charging Port Installation Instructions Rev. 1.0 Last Revised: January 7, 2019 Appendix A Nomenclature: AeroPower USB Charging Port Part number: 89000031-001 Manufacturer Part number: 153510-000131 TSO number: TSO-C71 Manufacturer: Appareo Systems Address: 1830 NDSU Research Circle North, Fargo, ND 58102, USA...
-
Page 13: Table 7: Do-160G Tests Performed
600840-000055 AeroPower USB Charging Port Installation Instructions Rev. 1.0 Last Revised: January 7, 2019 Equipment tested to Category U. Sine-on-Random for 8.8.2 Category U Curve G. Equipment identified as Category X, no test Explosive Atmosphere performed. Equipment identified as Category X, no test Waterproofness 10.0...
Need help?
Do you have a question about the AeroPower and is the answer not in the manual?
Questions and answers