Table of Contents
Advertisement
Quick Links
Manufactured in England by:
LANDY VENT UK LTD, FOSTER HOUSE, 2 REDDITCH ROAD, STUDLEY, B80 7AX
TESTED TO: EN13240
CAUTION: HOT WHILE IN OPERATION. DO NOT TOUCH, KEEP CHILDREN, CLOTHING AND FURNITURE
AWAY. CONTACT MAY CAUSE SKIN BURNS - SEE NAME PLATE AND INSTRUCTIONS
THIS STOVE MUST BE INSTALLED IN CONJUNCTION WITH THE REQUIREMENTS OF BSEN 15287-
1:2007 – DESIGN INSTALLATION AND COMMISSIONING OF CHIMNEYS.
WARNING NOTE:
Properly installed, operated and maintained this stove will not emit fumes into the dwelling.
Occasional fumes from de-ashing and re-fuelling may occur. However, persistent fume emission is
potentially dangerous and must not be tolerated. If fume emission does persist, then the following
immediate action should be taken:-
a) Open doors and windows to ventilate the room and then leave the premises.
b) Let the fire go out.
c) Check for flue or chimney blockage and clean if required.
d) Do not attempt to relight the fire until the cause of the fume emission has been identified
and corrected. If necessary seek expert advice.
The most common cause of fumes emission is flueway or chimney blockage. For your own safety
these must be kept clean at all times.
A CO detector must be fitted in the same room as this appliance to conform to UK requirements of
installation.
"The Clean Air Act 1993 and Smoke Control Areas"Under the Clean Air Act local authorities may declare the
whole or part of the district of the authority to be a smoke control area. It is an offence to emit smoke from a
chimney of a building, from a furnace or from any fixed boiler if located in a designated smoke control area.
It is also an offence to acquire an "unauthorised fuel" for use within a smoke control area unless it is used in
an "exempt" appliance ("exempted" from the controls which generally apply in the smoke control area). The
Secretary of State for Environment, Food and Rural Affairs has powers under the Act to authorise smokeless
fuels or exempt appliances for use in smoke control areas in England. In Scotland and Wales this power rests
E580 Defra instructions manual | current as of May 2015
All information supplied by Ecco Stove
Ecco Stove | Foster House
| 2 Redditch Road,
Studley,
B80 7AX, United Kingdom
T |
+44 (0)1527 857 814
Patent pending USA, Canada, Europe & Russia | UK Patent nos: 2467433 & 2498883
ECCO STOVE MODEL E580 Installation instructions
TM
is a trade mark of Landy Vent UK Limited
E | sales@eccostove.com
W | www.eccostove.com
1|
P a g e
DATE 04/03/14
copyright©EccoStove2015
Advertisement
Table of Contents
Related Manuals for ECCO STOVE E580
Summary of Contents for ECCO STOVE E580
- Page 1 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
- Page 2 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
- Page 3 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
- Page 4 – not all chimneys are suitable. The Ecco Stove E580 is tested for use with wood logs – you must check with your local area authority to ensure it is permissible to burn wood logs in the area where the stove is to be installed.
- Page 5 Radiant heat is omitted from the outer surfaces and initial heat from the glass door panel. 4. FLUE OUTLET (150 DIAMETER) Your Ecco Stove E580 is delivered with a top flue outlet only. If the installation demands, a 45° bend may be taken from the top of the stove and back into the chimneys flue.
-
Page 6: Ash Grate
Load the stove with care. 8. ASH GRATE The cast iron grate within your Ecco Stove E580 is highly durable but will be damaged if ash is allowed to build up in the grate bars. Ash build up will also impair the stoves primary combustion as the air flow will be choked. - Page 7 Rope seals are not covered by the manufacturer’s warranty. 10. FINISHES The Ecco Stove E580 is produced from a self coloured material and as such, variations in colour and texture of the material will be evident, but adding to the uniqueness of the product, unless ordered as pre factory painted.
-
Page 8: Air Controls
OUTSIDE AIR Outside air is an extra option. When fitted the Ecco Stove E580 draws its combustion air predominately from outside via the flexible 1 metre long air tube provided. Outside air reduces drafts into the room in which the appliance stands but doesn’t obviate the need... -
Page 9: Closing Down
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com... -
Page 10: Initial Firing
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com... - Page 11 UNDER FIRING WARNING When re lighting; re fuelling or re firing the Ecco Stove, it must be fired up to 160°C or above in order that each new wood load turns into proper combustion – if allowed to “tick over”...
-
Page 12: Operation With Door Left Open
P a g e The stove may be run as such for as long as needed. Your Ecco Stove E580 is not designed to stay in for long periods or overnight. d) REFUELLING ON A LOW FIRE BED If there is insufficient burning material in the fire bed to light a new fuel charge, excessive smoke emission can occur. - Page 13 16. RE FUELLING After 2 or so hours burning your Ecco Stove will need re fuelling. You may either add 2 o 3 logs on a full 3kg charge – subject to how you intend to run the stove and the heat output you are looking for.
-
Page 14: Cleaning And Maintenance
UP DEPOSITS, TO ENSURE BLOCKAGE DOESN’T OCCUR. 19. CLEANING AND MAINTENANCE The Ecco Stove E580 under top flue way must be cleaned at least twice in a burning season. Access must be left in the stoves pipe within 200mm of the stoves top and brushed forward into the stove under top flue way from there. -
Page 15: Paint Finishes
– which will leave bits of lint on the stoves surface. 21. ASSEMBLY Your Ecco Stove E580 is delivered in 7 main structural parts being base section; grate section; 2 x sides; one back section; lower top; upper top and one baffle block. Nine further secondary parts one door and frame including glass;... -
Page 16: Appliance Assembly
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com... - Page 17 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
- Page 18 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
- Page 19 Air Supply – 9 sq centimetres required within the UK (Refer To ADJ2010) Outside the UK to those countries of local area requirements. d) Extractor Fans: No extractor fans are to be fitted into the same room as the Ecco Stove. e) Flue Draught: Minimum cold flue 0.04inches water gauge f) Flue gas mass flow: 6 g) Flue gas temperature: Average 230°C at nominal output.
-
Page 20: Health And Safety
Top 125mm 24. GENERAL AND HEALTH AND SAFETY a) Safe Operation: The outside surface temperature of your Ecco Stove should not be fired to over 200°Centigrade so must not be touched or burning will occur. In the event of overheating (over 200°C) close the fire door and ash pit door and do not refuel until the body has cooled adequately. -
Page 21: Parts List
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com... -
Page 22: Parts Drawing
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com... - Page 23 In the event of a chimney fire, the fire door and ash pan must be tightly closed and the local fire brigade alerted immediately. e) The Ecco Stove when used slowly releasing heat may be left after its last firing for many hours with the stove pipes damper (if fitted) closed to slowly release heat into the house on a falling heat.
- Page 24 The Product = The Ecco Stove E580. 1. Please read your user instructions to ensure that you get the best from your Ecco Stove E580. Operating it properly is essential for this type of appliance to get the correct results. Always ask for help if you are unsure 2.
-
Page 25: Specifications
Paint finishes will change colour with use. This warranty does not cover such changes. 8. Fuels The warranty only applies to the use of wood logs on your Ecco Stove E580. Coals or processed petro chemical fuels void the warranty as their use may produce blockage in flueways. - Page 26 All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...
-
Page 27: Installation Details
All information supplied by Ecco Stove is a trade mark of Landy Vent UK Limited copyright©EccoStove2015 Ecco Stove | Foster House | 2 Redditch Road, Studley, B80 7AX, United Kingdom +44 (0)1527 857 814 E | sales@eccostove.com W | www.eccostove.com...