Sony Ericsson P900 Working Instruction, Mechanical
Hide thumbs
Also See for P900:
- User manual (193 pages) ,
- White paper (128 pages) ,
- Troubleshooting manual (21 pages)
Table of Contents
Advertisement
Quick Links
Working Instructions, Mechanical
Applicable for P900 and 908
1
2
3
4
5
6
7
3/000 21-1/FEA 209 544/85 A
Sony Ericsson Mobile Communications AB
Disassembly Front / Frame ............................................................................................2
Reassembly Front / Frame .............................................................................................6
Replacement of Mechanical Parts Front ......................................................................9
3.1
Loudspeaker, Holder Receiver, Cushion Receiver............................................9
3.2
Bezel replacement ...........................................................................................10
3.3
Front ................................................................................................................11
Replacement of Mechanical Parts Frame ...................................................................12
4.1
Jog dial ............................................................................................................12
4.2
Vibrator ...........................................................................................................13
4.3
Backspeaker, Holder- and cushion-loudspeaker..............................................14
4.4
Panel Camera assembly ...................................................................................15
4.5
Phone jack and cap jack ..................................................................................16
4.6
Microphone......................................................................................................17
4.7
Antenna ...........................................................................................................18
4.8
Stylus holder, spring and side switch ..............................................................19
4.9
MS cap.............................................................................................................21
4.10
Camera grommet .............................................................................................21
4.11
Water Label .....................................................................................................22
4.12
Frame...............................................................................................................23
Replacement of Other Mechanical Parts ....................................................................23
5.1
Battery cover ...................................................................................................23
5.2
Bezel front replacement, Flip assembly ..........................................................24
5.3
Camera module................................................................................................24
5.4
LCD .................................................................................................................25
5.5
Isolation Tape ..................................................................................................25
Label...............................................................................................................................26
Revision History ............................................................................................................26
Working Instructions, Mechanical
Approved according to 000 21-LXE 107 42/1
1(26)
Advertisement
Table of Contents
Related Manuals for Sony Ericsson P900
Summary of Contents for Sony Ericsson P900
-
Page 1: Table Of Contents
Working Instructions, Mechanical Working Instructions, Mechanical Applicable for P900 and 908 Disassembly Front / Frame ....................2 Reassembly Front / Frame .....................6 Replacement of Mechanical Parts Front ..............9 Loudspeaker, Holder Receiver, Cushion Receiver..........9 Bezel replacement ...................10 Front ........................11 Replacement of Mechanical Parts Frame ..............12 Jog dial ......................12... -
Page 2: Disassembly Front / Frame
Fig. 1.1 Take out the battery. Check that the SIM-card is removed Fig 1.2 Take out the stylus in the direction of the arrow Fig. 1.3 3/000 21-1/FEA 209 544/85 A 2(26) Sony Ericsson Mobile Communications AB... - Page 3 The rubber plugs is To remove the upper two not to be reused. screws, first you have to remove the rubber plugs, use a dentist hook. Fig 1.8 3/000 21-1/FEA 209 544/85 A 3(26) Sony Ericsson Mobile Communications AB...
- Page 4 Fig 1.12 shows Fig.1.12 Remove the two screws at Be careful not to damage the arrows, and remove the flex film connected to the shielding can. the display. Fig.1.13 3/000 21-1/FEA 209 544/85 A 4(26) Sony Ericsson Mobile Communications AB...
- Page 5 Remove the Camera The Camera grommet can grommet with a pair of follow the PCB when tweezers. lifting it up , then this operation will be unnecessary. Fig 1.17 3/000 21-1/FEA 209 544/85 A 5(26) Sony Ericsson Mobile Communications AB...
-
Page 6: Reassembly Front / Frame
PCB with your fingers. Fig Fig. 2.2.2 The LCD shall be turned to the other side of the PCB after the contact has been mounted Fig 2.2.1 Fig 2.2.3 3/000 21-1/FEA 209 544/85 A 6(26) Sony Ericsson Mobile Communications AB... - Page 7 Take the front and place it over the frame. Start at the upper end as the Fig 2.6 shows. Fig. 2.6 Press along the sides until it fits properly. Fig 2.7 3/000 21-1/FEA 209 544/85 A 7(26) Sony Ericsson Mobile Communications AB...
- Page 8 Fig. 2.10 Mount the flip bezel. Press it down until it “Clicks” Fig. 2.11 Put the stylus in place Fig 2.12 Mount the battery and battery cover Fig 2.13 3/000 21-1/FEA 209 544/85 A 8(26) Sony Ericsson Mobile Communications AB...
-
Page 9: Replacement Of Mechanical Parts Front
Remove the cushion. The cushion is not to be reused if once taken away. Fig 3.1.3 Mount the cushion, make sure it is correct oriented see Fig 3.1.4 Fig 3.1.4 3/000 21-1/FEA 209 544/85 A 9(26) Sony Ericsson Mobile Communications AB... -
Page 10: Bezel Replacement
If it is hard to loose you can Be careful not to damage use the stylus in the notch on the stylus and bezel the bezel Fig 3.3.2 3/000 21-1/FEA 209 544/85 A 10(26) Sony Ericsson Mobile Communications AB... -
Page 11: Front
Remove all components in the front and reassemble them in a new front according to 3 Replacements of Mechanical Parts Front • Mount the phone as described in 2 Reassembly Front / Frame. 3/000 21-1/FEA 209 544/85 A 11(26) Sony Ericsson Mobile Communications AB... -
Page 12: Replacement Of Mechanical Parts Frame
(3). Mount the camera grommet as in 4.10 Fig 4.1.4 • Mount the phone as described in 2 Reassembly Front / Frame, step 1-8. 3/000 21-1/FEA 209 544/85 A 12(26) Sony Ericsson Mobile Communications AB... -
Page 13: Vibrator
Fig. 4.2.2 • Mount the phone as described in 2 Reassembly Front / Frame. 3/000 21-1/FEA 209 544/85 A 13(26) Sony Ericsson Mobile Communications AB... -
Page 14: Backspeaker, Holder- And Cushion-Loudspeaker
Fig 4.3.3 Mount the new cushion Fig 4.3.4 Mount the loudspeaker Note the direction of the contacts. Do not touch the contact surfaces. Fig 4.3.5 3/000 21-1/FEA 209 544/85 A 14(26) Sony Ericsson Mobile Communications AB... -
Page 15: Panel Camera Assembly
Fig 4.4.1 Mount the Panel camera Make sure the adhesive is assembly onto the lower clean and fresh before cabinet. mounting. Mount the battery and battery cover. Fig 4.4.8 3/000 21-1/FEA 209 544/85 A 15(26) Sony Ericsson Mobile Communications AB... -
Page 16: Phone Jack And Cap Jack
Mount a new phone jack, press I down and outwards Fig 4.5. 3 Put the cap jack in its place. Fig. 4.5.4 • Mount the phone as described in 2 Reassembly Front/Frame. 3/000 21-1/FEA 209 544/85 A 16(26) Sony Ericsson Mobile Communications AB... -
Page 17: Microphone
Use a pair of tweezers. Fig. 4.6.3 • Mount the phone as described in 2 Reassembly Front / Frame. 3/000 21-1/FEA 209 544/85 A 17(26) Sony Ericsson Mobile Communications AB... -
Page 18: Antenna
Place the CP-support back in the frame cavity and fasten it with two new screws. Torque 7 Ncm +/-2. Fig 4.7.4 Mount the phone as described in 2 Reassembly Front / Frame 3/000 21-1/FEA 209 544/85 A 18(26) Sony Ericsson Mobile Communications AB... -
Page 19: Stylus Holder, Spring And Side Switch
You may need to gently bend the frame outwards a little. Fig 4.8.3 Remove the side switch with a pair of tweezers it is fasten by an adhesive. Fig. 4.8.4 3/000 21-1/FEA 209 544/85 A 19(26) Sony Ericsson Mobile Communications AB... - Page 20 Before reassembly check the stylus spring force. The stylus shall not easily fall out. Fig 4.8.9 • Mount the phone as described in 2 Reassembly Front / Frame 3/000 21-1/FEA 209 544/85 A 20(26) Sony Ericsson Mobile Communications AB...
-
Page 21: Ms Cap
Instruction • Disassemble the phone as described in 1 Disassembly Front / Frame Figure Instruction Note Remove the camera grommet with a blunt pair of tweezers Fig 4.10.1 3/000 21-1/FEA 209 544/85 A 21(26) Sony Ericsson Mobile Communications AB... -
Page 22: Water Label
Fig 4.11.1 operation. Mount a new water label. Fig 4.11.2 • Mount the phone as described in 2 Reassembly Front / Frame 3/000 21-1/FEA 209 544/85 A 22(26) Sony Ericsson Mobile Communications AB... -
Page 23: Frame
Remove the battery cover by pressing on the triangle mark on the battery cover and move the battery cover in the arrow direction. Fig. 5.1.1 Mount the battery cover Fig. 5.1.2 3/000 21-1/FEA 209 544/85 A 23(26) Sony Ericsson Mobile Communications AB... -
Page 24: Bezel Front Replacement, Flip Assembly
The long contact surface shall be pointing upwards in the arrow direction. Fig 5.3.3 • Mount the phone as described in 2 Reassembly Front / Frame 3/000 21-1/FEA 209 544/85 A 24(26) Sony Ericsson Mobile Communications AB... -
Page 25: Lcd
Use a Pair of tweezers Fig. 5.5.1 Mount the isolation Tape on the PCB Fig. 5.5.2 • Mount the phone as described in 2 Reassembly Front / Frame 3/000 21-1/FEA 209 544/85 A 25(26) Sony Ericsson Mobile Communications AB... -
Page 26: Label
Fig. 6.1 7 Revision History Rev. Date Changes / Comments 2003-10-14 First release 3/000 21-1/FEA 209 544/85 A 26(26) Sony Ericsson Mobile Communications AB...