Advertisement
Quick Links
Freddy TOS Tramp Oil Separator Users Manual
Section 1 – Introduction
In order that you get the best from your new Freddy TOS, the following instructions have
been prepared. Please read them carefully. Safety is of paramount importance.
Therefore, if you are unsure about anything please contact our service or parts
department:
Section 2 – General Operating Instructions
1. Electric Units:
Check electric cord for wear and grounding. Plug the unit into a 110/1/60 outlet.
2. Air Operated Units:
The unit requires a minimum of 15 psi at 0.5 SCFM air flow to operate. Ensure
the left hand bowl on the control unit is 3/4 full with pneumatic lubricant. The
lubricator is set at the factory. If you need to adjust the lubricator, turn the
tapered screw counter-clockwise on the lubricator to increase the rate. If you
need to decrease the rate turn the screw clockwise.
23 Walpole Park South, Walpole, Massachusetts 02081, • Phone: 1-800-343-3381
www.sanborntechnologies.com
Sanborn Technologies
23 Walpole Park South
Walpole, MA 02081-2558
Telephone: 1-800-343-3381
Fax: 1-508-660-9151
info@sanborntechnologies.com
www.sanborntechnologies.com
• E-mail: info@sanborntechnologies.com
Page 1, Rev. 7
Advertisement
Summary of Contents for Sanborn Freddy TOS
-
Page 1: Section 1 - Introduction
Freddy TOS Tramp Oil Separator Users Manual Section 1 – Introduction In order that you get the best from your new Freddy TOS, the following instructions have been prepared. Please read them carefully. Safety is of paramount importance. Therefore, if you are unsure about anything please contact our service or parts... -
Page 2: Pre Filters
Affix the magnetic holder to the side of the tank and rotate the floating-head so that it sits level on the tank. Additional skimmer styles are available for specific applications. The Freddy TOS is now ready for operation. 23 Walpole Park South, Walpole, Massachusetts 02081, • Phone: 1-800-343-3381 • E-mail: info@sanborntechnologies.com... - Page 3 Start the pump and recheck the correct height of the suction pipe. Maintenance Instructions: Since there are only a few moving parts in the Freddy TOS, maintenance consists of cleaning or changing the prefilters cartridges as necessary, periodic flushing of the sediment which may accumulate in the bottom of the unit, , and (rarely) cleaning the filter media if it becomes clogged with sediment.
- Page 4 A drain line at the bottom of the system allows for the removal of residual coolant or wash water in the media tank. Exceeding the rated flow to the Freddy TOS may affect the quantity of tramp oil the unit can effectively remove.
- Page 5 Page 5, Rev. 7 23 Walpole Park South, Walpole, Massachusetts 02081, • Phone: 1-800-343-3381 • E-mail: info@sanborntechnologies.com www.sanborntechnologies.com...