Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for FOAM-iT MU-AC-15N
- Page 1 15 Gallon Electric Fog/Mist Unit User Manual MU-AC-15N MU-AC-15N-PSGN130 READ ALL INSTRUCTIONS BEFORE USING, OR SERVICING, THIS EQUIPMENT. KEEP THIS MANUAL IN A LOCATION THAT IS READILY AVAILABLE TO USERS AND SERVICE TECHNICIANS. English (Original Instructions)
-
Page 2: Table Of Contents
............Model: MU-AC-15N, MU-AC-15N-PSGN130... -
Page 3: Safety
Always place the unit (air compressor) in an area away from the misting direction. DO NOT touch the air compressor, electrical or extension cords if your hands or feet are wet. Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 3 of 14... - Page 4 For best results use a dedicated circuit. PROTECT THE ENVIRONMENT Please dispose of packaging materials, old machine components, and hazardous fluids in an environmentally safe way according to local waste disposal regulations Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 4 of 14 •...
-
Page 5: Product Overview
* Dilution rates and flow rates given are based on chemical with viscosity of water and factory air pressure settings. ** Area covered and run time may vary based on humidity, air flow, and product used. Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 5 of 14 •... -
Page 6: Product Components
Product components Before you begin get to know the MU-AC-15N and MU-AC-15N-PSGN130 components that you will need to use, adjust or assemble. Back plate assembly • Inside view 1 . Hinged back plate 2 . Quick-change pump 3 . Air regulator 4 . - Page 7 18 . Tank 12 . Bulkhead 1/4 in. tube 19 . Air supply line 13 . Suction line valve 20 . 25 ft. coiled tubing 14 . MGA-RAC-N130 wand 15 . Drain plug Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 7 of 14 •...
-
Page 8: Assembly
4 . Fasten the screws into the bracket. 5 . Attach the ¼ in. blue air hose from that back of the unit to the air compressor using the quick connect fittings. Quick connect fitting Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 8 of 14 •... -
Page 9: Operation
Then squeeze the trigger handle to begin misting. Note: Both discharge valves should be completely open while misting. On model MU-AC-15N: Point the discharge wand in a safe direction and press the red and blue discharge trigger buttons at the same time to begin misting. Note: Both discharge buttons should be completely open while misting. - Page 10 13 . Depressurize and drain the air compressor tank by opening the ball valve on the compressor tank. Open Close PSG12 trigger (model MU-AC-15-PSGN130) RAC-GUN-.5 red and blue buttons (MU-AC-15N) Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 10 of 14 •...
-
Page 11: Troubleshooting
Check the chemical suction line and strainer for debris or damage. Clean or replace as needed. To prevent damage to the unit, the strainer (STR38-IL) must always be used. Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 11 of 14 •... - Page 12 Compressor worn or with metallic clangs. • Stop the compressor and contact the dealer. broken piston ring Compressor worn or • Stop the compressor and contact the dealer. broken cylinder ring Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 12 of 14 •...
-
Page 13: Parts
P56, P56K, P56V H14B-F CT25 AG100 CV14QF-S AP25 H14BU AC120V-1HP-CAT H38B-F STR38-IL TANK-15NC-CATBRKT CST5SS CST5SS-L HBSSEL1438 HHPB3414 DP-A PVCV34FM PFN-N130 QF1214 DFP7 QFSOV14 PSG12 TANK-15N-C PSG-N130 QF1814SS BVB14 PFN-N130 RAC-GUN-.5 RAC-GUN-N130-BRKT MGA-RAC-N130 Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 13 of 14 •... - Page 14 RAC-GUN-N130-BRKT SS bracket for PFN-N130 on rac-gun STR38-IL In line strainer-3/8 barb-epdm gasket-20 mesh SS TANK-15N-C 15 Gallon concentrate tank natural in color TANK-15NC-CATBRKT SS bracket for cat air compressor on tank-15nc Non-marking wheel for portable units Model: MU-AC-15N, MU-AC-15N-PSGN130 V20200501 Page 14 of 14 •...