Page 1
DuroZone DuroZone ® MODEL RED-4 ZONE CONTROL SYSTEM PART# 35234 DuroZone ® is a division of ® Corporation RED4 InstrManual-7-1-10.indd 1 7/9/2010 5:34:36 PM...
Page 2
RED4 - Zoning Panel FEATuRES • Panel controls four zones. • Zone4 damper can be used as a fresh air damper. A timer on panel sets the minutes of fresh air per hour. • Capable of two-stage heating and two- stage cooling for gas/electric systems and three-stage heating and two-stage cooling for heat pump systems.
INSTALLATION INSTRuCTIONS if Dip switch #4 is set to HP. The RED4 is a 4-zone panel that can control gas/ electric, hydronic, electric and both conventional and dual fuel heat pumps with multi-stage heating and cooling. Low cost heat/cool thermostats can be used in all zones.
Page 4
Selecting use of Zone4 Damper 24VAC Power Dip switch #9 selects whether Damper4 is being used as 24VAC is connected to the panel at the terminals marked Zone4 damper or as a fresh air damper. When it is used as 24VAC.
Page 5
ODT Limit Potentiometer Fan LED A low cost Outdoor Air Sensor can be used to monitor the Fan LED will be lit continuously when the panel the outdoor temperature and if the outdoor temperature is is in continuous indoor fan operation. the Fan LED greater than the ODt Limit, multi stage heating is inhibited will blink when the system is in Purge mode.
Wiring Instructions Heat/Cool Thermostat All wiring should be done in accordance with local and national codes. Use color-coded, multi-conductor thermostat wire. THESE PANELS ARE DESIGNED FOR uSE WITH 24VAC CONTROLS AND SHOuLD NOT BE uSED WITH OTHER VOLTAGES. uSE CAuTION TO AVOID ELECTRIC SHOCK OR A heat pump thermostat can be used in Zone1 to provide DAMAGE TO EQuIPMENT.
Page 7
Wiring diagram for a spring return damper that is normally open with no power (spring open). HEAT PUMP 24VAC RED4 Panel FIRST STAGE SECOND STAGE W2/E REVERSING VALVE • COOLING Wiring an HVAC System W1/B DEFROST the panel can be used with a wide variety of HVAC systems. Some of the more common configurations follow: AIR HANDLER ELECTRIC...
Need help?
Do you have a question about the DuroZone RED-4 and is the answer not in the manual?
Questions and answers