Storage - ECAR GOLF 627 Series Operation Manual

MAINTENANCE
C = Check C A = CheckAdjust R = Replace S = Service C L = CleanandLubricate L = Lubricate
20 rounds
125
20 hours
rounds
20 hours
125 hours
Pre-
Remarks
160kms(
600 miles
Operation
Every
1000kms (
)
Month
Every 6
Charge
Clean Battery tops,for
tightness of hold-down screws
and terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure tread
depth tire surface for damage
Check bode and chassis,for damage
Check tightness of all bolts,nuts and
screw
Check reverse buzzer
Check electrolyte level
C h e c k f o r l o o s e o r b r o k e n
connectionsw
C l e a n L u b e P e d a l
control area
Check all wire insulation for crack
and/or worn spots
Check shock absorbers for oil
leaks and damaged springs
Perform a discharge test
protectant
Check shoe lining thickness
and rear axle beating play
C h e c k s t e e r i n g k n u c k l e
bushing freeplay/Adjust wheel
alighment
Check wheel not tightness
front wheel bearing play
Check gear box oil level and
leakage
Check operation and adjust pedal
stop if necessary
Replace gear box oil
C h e c k f o r g r e a s e
leakage;adjust gear box if
Items without a page number reference should be serviced by approved
agent or qualified technician.
This manual doesn't contain these procedures. They are contained in the
Service Manual
2 6
500 rounds
250 rounds 1000
250 hours 500 hours rounds
1200 miles 2500 miles 1000 hours
4000kms( 5000 miles
1000kms(
Page
Every2
Every 8000kms
Years)
Years) (Every 4

STORAGE

Perform the following preparations
when leaving your golf car unused
for a long time:
NOTE:
Turn the main switch key "OFF",
remove the key, and put it in a safe
place.
CHASSIS PREPARATION
1. Verify the air pressure of the
tire is 25psi ( 3 kgf/cm3);
2. Clean the outside of the car with
anti- rust oil;
3. Cover the car and store it in a
dry and well-ventilated place.
BATTERY PREPARATION
1. . Recharge the batteries and
check the fluid levels at least
once a month.
2. Disconnect cables in case of
long storage
C A U T IO N
Cleaning products are forbidden
to put into battery cells
3. Clean the top of the batteries
with baking soda and water so as
to avoid erosion.
2 7