Table of Contents
Advertisement
Quick Links
ADCP-90-516
Rev.B, April 2019
www.commscope.com
Content
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Revision History . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Trademark Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Related Publications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Admonishments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
General Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1
GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1.1
1.2
1.3
1.4
2
UNPACKING AND INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
3
INSTALLING THE STORAGE PANEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
3.1
3.2
3.3
4
INSTALLING STORAGE PANEL COMPONENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
4.1
4.2
4.3
5
USING THE STORAGE PANEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
5.1
5.2
5.3
5.4
6
CUSTOMER INFORMATION AND ASSISTANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
ADCP-90-516 Rev B
FL2000 Storage Panel
Fiber Storage Deck Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Fiber Storage Disk Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Fiber Storage Tray Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Horizontal Management Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Rack Mount Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
3.1.1
Standard (5-Inch Recess) Rack Mount Installation in a 19-Inch Rack . . . . . . . . . . . . . . . . . . . . . . . 7
3.1.2
Flush, 1-, 2- or 4-Inch Recess Mount in a 19-Inch Rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
3.1.3
19-Inch Maximum Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
3.1.4
23-Inch Rack Mount With Wide VCG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.1.5
23-Inch Centered Rack Mount With Extender Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
FL2000 Storage Panel ETSI Flush Mount Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Wall Mount Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Designation Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Key Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Fiber Hole Plugs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Using the Storage Deck Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Using the Storage Disk Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Using the Storage Tray Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Using the Horizontal Management Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Installation
Instructions
Page
Page 1
© 2019, CommScope, Inc.
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Summary of Contents for CommScope FL2000 Storage Panel
-
Page 1: Table Of Contents
FL2000 Storage Panel ETSI Flush Mount Kit ........ -
Page 2: Introduction
ADCP-90-516 • Rev B • April 2019 INTRODUCTION CommScope FL2000 Storage Panels provide fiber storage for small to medium-sized fiber networks and customer premises applications and are available in four versions. The storage panels are available in a variety of storage capacities. The method of storage in the panel determines the type of panel;... -
Page 3: General Safety Precautions
1 GENERAL The FL2000 storage panel is available in four styles each with a unique method of fiber storage and a wide range of capacity depending upon your needs. Cables may enter the storage panel from the left side only via the vertical cable guide, through the fanning strip, into the storage panel. -
Page 4: Fiber Storage Disk Panel
The storage disk assemblies easily slide out of the chassis from the front to provide convenient access for storing patch cords. Patch cords enter and exit each disk assembly from an opening on the edge of the assembly. Page 4 © 2019, CommScope, Inc. - Page 5 TURN/PULL REMOVABLE LATCH FRONT COVER Figure 2. Typical Storage Disk Panel Components (16-Disk Panel Shown) CHASSIS MOUNTING BRACKET VERTICAL CABLE GUIDE (VCG) 18901-A DESIGNATION CARD TURN/PULL LATCH Figure 3. Typical Storage Tray Panel Components Page 5 © 2019, CommScope, Inc.
-
Page 6: Fiber Storage Tray Panel
For example, 11.4 meters of slack cable may be stored in the panel for up to a quantity of 12-2mm patch cords. CHASSIS MOUNTING BRACKET VERTICAL CABLE GUIDE (VCG) STORAGE 18879-A SPOOLS Figure 4. Typical Horizontal Management Panel Page 6 © 2019, CommScope, Inc. -
Page 7: Unpacking And Inspection
1. Inspect the exterior of the shipping container for evidence of rough handling that may have damaged the contents of the container. 2. Unpack the FL2000 Storage Panel while carefully checking it for damage. 3. If damage is detected or if parts are missing, file a claim with the commercial carrier and then notify CommScope Customer Service. -
Page 8: Flush, 1-, 2- Or 4-Inch Recess Mount In A 19-Inch Rack
RECESS 17108-A Figure 5. FL2000 Storage Panel 5-Inch Recess Rack Mounting Option (Top View) 4. Align the left side mounting bracket holes to the corresponding holes in the rack and secure the panel to the rack using #12-24 screws (provided). -
Page 9: 19-Inch Maximum Mounting
#12-24 screws (provided). 6. Align the mounting holes in the right side of the panel with the corresponding holes in the rack, and secure the panel to the rack using # 12-24 screws (provided). Page 9 © 2019, CommScope, Inc. -
Page 10: 23-Inch Rack Mount With Wide Vcg
The FL2000 23-inch VCG Kit (not provided) is used to install the panel in a 23-inch rack with a wide VCG. Figure 8 shows the panel and kit components. EQUIPMENT EQUIPMENT RACK RACK 5 IN. 5 IN. RECESS RECESS 17108-A Figure 8. FL2000 23-Inch Rack Mount With Wide VCG (Top View) Page 10 © 2019, CommScope, Inc. -
Page 11: 23-Inch Centered Rack Mount With Extender Brackets
Use the following procedure to mount the panel on the rack: 1. Remove the front cover of the panel by opening the cover approximately two inches (5 cm) then lifting the cover from the hinges. Page 11 © 2019, CommScope, Inc. -
Page 12: Fl2000 Storage Panel Etsi Flush Mount Kit
6. Align the right side bracket with the corresponding holes in the rack and secure the panel. FL2000 Storage Panel ETSI Flush Mount Kit An ETSI Flush Mount Kit is available to install a storage panel in an ETSI rack with a flush mount (only) recess (the brackets can not be re-adjusted for a 1-, 2-, 4-, or 5-inch recess). -
Page 13: Wall Mount Installation
Figure 10. ETSI Flush Mount Kit Wall Mount Installation Storage panel can be attached directly to a wall; however, CommScope recommends that it be mounted on a 3/4-inch-thick plywood panel attached to the wall, in accordance with local fire code. If the wall surface is uneven, shim the plywood as required to ensure a flat mounting surface. -
Page 14: Installing Storage Panel Components
2. Remove the latch body from the latch cutout through the front of the cover. 3. Insert the key lock body through the cutout and thread the lock nut onto the key lock body. Page 14 © 2019, CommScope, Inc. -
Page 15: Fiber Hole Plugs
6. Complete a designation label for the stored patch cord and apply label to front edge of storage deck assembly. 7. Repeat procedure for each patch cord to be stored. Close front cover when complete. Page 15 © 2019, CommScope, Inc. -
Page 16: Using The Storage Disk Panel
Figure 13. The routing shown for a patch cord entering from the left side is not the same as the routing for a patch cord entering from the right side. Page 16 © 2019, CommScope, Inc. -
Page 17: Using The Storage Tray Panel
3. Each tray is hinged on the left. Pull outward on the extended tab located on the right hand corner of the tray assembly until tray swings open. 4. Swing storage tray assembly out of the chassis by pulling outward on the extended tab. Page 17 © 2019, CommScope, Inc. - Page 18 10. Apply numbered identification labels (provided) to each pigtail and mark cable designations on front of cable management trays. 11. Repeat procedure for each patch cord to be stored. Close front cover when complete. Page 18 © 2019, CommScope, Inc.
-
Page 19: Using The Horizontal Management Panel
4. Complete a designation label for the stored patch cord and apply label to front edge of management panel assembly. 5. Repeat procedure for each patch cord to be stored. 18878-A Figure 15. Horizontal Management Panel Cable Storage Page 19 © 2019, CommScope, Inc. -
Page 20: Customer Information And Assistance
ADCP-90-516 • Rev B • April 2019 6 CUSTOMER INFORMATION AND ASSISTANCE For technical assistance or to report a missing or damaged part, contact CommScope online at http://www.commscope.com/SupportCenter For information on product patents, refer to http://www.cs-pat.com For other information on CommScope products, use http:/www.commscope.com...
Need help?
Do you have a question about the FL2000 Storage Panel and is the answer not in the manual?
Questions and answers