Hot dipped galvanised steel construction • Low entry height rubber lined floor Options • Integrated ePanel EID system • Trailer system pictured here • Reducer panel for small lambs www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Control Dashboard - See page 10 Serial number Rings for lifting or tie down Magic Eyes on Eye Rail Weigh Crate Exit Leg Centre Leg Entry Leg Notes www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Right in front with left gate behind Rings for lifting or tie down Air supply inlet Air filter section AC Power supply Entry Leg Centre Leg Exit Leg Notes www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Freephone 0800 837 274 • If you encounter problems during operation please check through the Te Pari Racewell Trouble Shooting Guide on pages 18-21 of this manual before calling for service . The compressor We recommend a 12cfm belt driven compressor, if the compressor is too small the Racewell will run slowly and may not operate properly .
- Alternates the left hand draft gate between open and closed between open and closed Button D - Alternates the right hand draft gate between open and closed between open and closed www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Left hand button - Exit gate button The left hand exit gate button operates the exit gate . It works in the same fashion as the entry gate www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Wool, dust and the like covering any of the eyes can affect their operation. Make sure that the lenses of the eyes are clear at all times. Eye position notes www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Te Pari Racewell Trailer System Guidelines Before using please check that all drawbar, lift and axle retaining pins are fitted and are secure before towing any Te Pari Racewell trailer . Please be aware of the LTSA (Land Transport Safety Authority) requirements, shown below, regarding agricultural trailers .
Page 11
Te Pari YouTube Channel at: the Te Pari YouTube Channel at: https://www .youtube .com/ https://www .youtube .com/ watch?v=E1ySRHESruk watch?v=E1ySRHESruk www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Tow bar cross member to Upper cross frame to the end the left and right frames the left and right frames of the left and right frames www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 13
The front joint for the tow bar to the left and right frames is fixed with 1x single M16 x 120 mm bolt, washers and nut . www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Racewell DR3 AUTO DRAFTER Setting up a Te Pari T20 or T20E for the DR3 General notes on navigation. The up and down arrows scroll up or down through a page’s items, pressing and holding the up or down arrow jumps up or down through the setup pages.
Page 15
S e l e c t w h a t I D m o d e s a r e e n a b l e d Done. Remember to return to favourites on setup page 1 and save your settings for easy recall later. www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
You still arrow to the entry you wish to change but then you key in the data using the keypad Once keyed in press the ENTER key to accept your entry and move on . www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 17
Arrow down to DRAFTING Press the ENTER and arrow to the tick ENTER Press the to set it Arrow to DRAFTING RANGES and press on the Keypad www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 18
The other entries should already contain the correct values, if not, Arrow to them and set them as follows: WEIGHT RECORDING: set to Auto RESOLUTION: set to AUTO ZERO TRACK: On Net set to Press the back arrow to return to the Weighing Screen Setup www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 19
ESCAPE key together This displays the Specialised Setup screen Press the blue soft key below DAMPING on the screen Arrow to START WEIGHING: and press the ENTER www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 20
When the entries are set, press the escape key to return to the main screen . To start automatic drafting Select auto on the Racewell Drafter to start operation . www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Scale setup notes Warranty reply card Te Pari Racewell DR3 Auto Drafter Sheep Handling System Please complete all details on the reverse and post to Te Pari Products office: Te Pari Products Ltd New Zealand Head Office: PO Box 25, 9 Endeavour Crescent Oamaru, 9444 New Zealand .
The Seller shall not be responsible for any loss or damage to the Goods, or caused by the Goods, or any part thereof however arising. Warranty reply card Te Pari Racewell DR3 Auto Drafter Sheep Handling System Model Serial No...
Date Serviced: Serviced By: Serviced By: Next Service Due: Next Service Due: Date Serviced: Date Serviced: Serviced By: Serviced By: Next Service Due: Next Service Due: Service notes www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Racewell DR3 AUTO DRAFTER Racewell DR3 Sheep handler trouble shooting guide Please check this trouble shooting guide before ringing service, often something quite simple will be the problem . Service freephone 0800 837 274 A service charge will be made for call outs if the fault is not covered by your warranty .
Page 25
Possible causes Possible solutions Dirty eyes Clean eyes Faulty “Y” or Comms cable Check the “Y” and Communications cables and the cables pins for damage, replace if required www.tepari.com Freephone 0800 837 274 Te Pari Racewell DR3 Auto Drafter Manual 1115-1...
Page 26
Rest of world: +64 3 433 0077 Email: NZ: sales .nz@tepari .com Rest of World: admin@tepari .com Racewell HD6 6 WAY DRAFTING HANDLER “Thank you for your purchase, enjoy your new Te Pari Racewell DR3 Auto Drafter ” from the Te Pari team.