Table of Contents
Advertisement
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Summary of Contents for Lewmar Mamba Series
- Page 1 Mamba Autopilot Drive Installation Guide Mamba Einbauanleitung für den Autopilot-Antrieb Guía de Instalación del Actuador para Piloto Automático Mamba Guide d’installation de l’unite d’entrainement de Pilote Automatique Mamba Installationsguide för Mamba Autopilot...
-
Page 2: Table Of Contents
Dimensions de l’unité .......8 Garantie limitée Lewmar ......19 Caractéristiques techniques de l’unité... -
Page 3: Introduction
Så vitt vi vet var informationen i denna manual korrekt när den Välkommen till Lewmars installationsguide för Mamba Autopilot. gick i tryck. LEWMAR kan emellertid inte ta ansvar för eventuella Produkten är tänkt för skötseln av båtens styrmekanism som del av felaktigheter eller bristfälligheter som den kan innehålla. -
Page 4: Safety Notices
Warnung: Da die einwandfreie Funktion der Schiffssteuerung lebenswichtig Stets von sämtlichen beweglichen Teilen der Steueranlage für die Sicherheit ist, wird von Lewmar DRINGEND EMPFOHLEN, fernbleiben. Bewegliche Teile während des Normalbetriebs vor dass dieses Produkt von einem qualifizierten Fachmann für Zugriff schützen. -
Page 5: Emc Recommended Guidelines
EMC RECOMMENDED GUIDELINES All Lewmar equipment and accessories are designed to conform to imposed by any location, always ensure the maximum separation the appropriate Electromagnetic Compatibility (EMC) standards. possible between different items of electrical equipment. Correct installation is required to ensure that performance is not For optimum EMC performance, it is recommended that wherever compromised. - Page 6 OTHER INFORMATION • More than 7ft (2m) from the path of a radar beam. A radar beam (Applies to all drives) can normally be assumed to spread 20° above and below the radiating element. • The equipment is supplied from a separate battery from that Protected for use in engine compartments used for engine start.
-
Page 7: Preparation
PREPARATION Drive orientation: • Mamba drives can be installed in any attitude directly onto the Structural strength: mounting flange on the bevel head or reduction gearbox. • The Mamba drive mounts directly to the steering system’s bevel General position: head or reduction gearbox, via an interface plate. •... -
Page 8: Identifying The Mamba Autopilot Drive
IDENTIFYING THE MAMBA DRIVE — FIGURE 1 A. Motor Gearbox and Clutch Assembly B. Motor Cable C. Clutch Cable D. Mounting Face TEILE-IDENTIFIKATION DES MAMBA- ANTRIEBS — ABBILDUNG 1 A. Motorgetriebe und -Kupplung B. Motorkabel C. Kupplungskabel D. Montagefläche IDENTIFICACIÓN DEL ACTUADOR MAMBA —... -
Page 9: Drive Dimensions
DRIVE DIMENSIONS — FIGURE 2 A. 2 Holes Helicoiled M10 (Thru' hole optional) SN155/255 - 256mm SN355 - 277mm ABMESSUNGEN DES ANTRIEBS — ABBILDUNG 2 A. 2 m10-gewindebohrungen (durchgangsloch wahlweise) DIMENSIONES DEL ACTUADOR — FIGURA 2 A. 2 orificios dotados de helicoils de M10 (opcionalmente orificios pasantes) DIMENSIONS DE L’UNITÉ... -
Page 10: Drive Specifications
DRIVE SPECIFICATION Part Description H.P . Volts Maximum Output No Load Maximum Rudder Average Circuit Weight Guide to Number Torque Speed Torque Current Breaker Boat Size Consumption ft lbs ft lbs Motor Clutch 89300051 Mamba 1/8hp 12v Std 1.5A 17.6 Up to 11.6m (38') -
Page 11: Technische Daten Des Antriebs
TECHNISCHE DATEN DES ANTRIEBS Teile-nummer Bezeichnung Volt Max. Leerlauf- Max. Ruder- Mittl. Strom- Circuit Gewicht Geeignet für Dreh-moment drehzahl drehmoment aufnahme Breaker Schiffs-größe ft lbs ft lbs Motor Clutch 89300051 Mamba 1/8hp 12v Std 1,5A 17,6 11,6m (38') 89300052 Mamba 1/8hp 24v Compact 17,6 89300053 Mamba 1/4hp 12v Std... -
Page 12: Especificaciones Del Actuador
ESPECIFICACIONES DEL ACTUADOR Referencia Descripción C.V. Voltios Par Máximo Velocidad Par Máximo Consumo Fusible Peso Guía de (H.P .) motor del Motor Sin Carga del Timón Medio Tamaños de /embr. Embarcación libras/pie libras pie Motor Embr. 89300051 Mamba 1/8hp 12v Estandard 1,5A 17,6 Hasta... -
Page 13: Caractéristiques Techniques De L'unité
CARACTÉRISTIQUES TECHNIQUES DE L’UNITÉ Numéro de Description Volts Couple de sortie max. Vitesse Couple max. Consommation Circuit Poids Guide pièce hors- sur mèche moyenne Breaker de taille de charge bateau tr/min ft lbs ft lbs Motor Clutch 89300051 Mamba 1/8hp 12v Std 1,5A 17,6 Jusqu’à... -
Page 14: Drivsystemets Specifikationer
CARACTÉRISTIQUES TECHNIQUES DE L’UNITÉ Artikel Beskrivning Volt Maximalt utgående Tomgångs- Max. rodervridmoment Genomsnittlig Circuit Vikt Guide betr. nummer vridmoment hastighet strömförbrukning Breaker båtstorlek varv/min ft lbs ft lbs Motor Clutch 89300051 Mamba 1/8hp 12v Std 1,5A 17,6 Upp till 11,6m (38’) 89300052 Mamba 1/8hp 24v Compact... -
Page 15: Installation
INSTALLATION • Before installation a smear of grease onto the drive output shaft, is recommended. Parts supplied: Note: Make sure you have obtained these additional parts before • Mamba drive you start installation. • suitable securing bolts with washers and lock-nuts MOUNTING THE DRIVE AND CONNECTING THE Further Requirements: STEERING SYSTEM... -
Page 16: Mounting The Drive And Connecting The Steering System
• The gearbox onto which the drive is to be attached must be fitted with the drive interface plate (see Figure 3). If there is no AN EXAMPLE OF HOW THE interface plate already included in the steering system, the MAMBA DRIVE CAN BE INSTALLED INTO THE gearbox can be returned to our factory for adaptation at the STEERING SYSTEM —... -
Page 18: Connecting To The Course Computer
CONNECTING TO THE COURSE COMPUTER Follow these steps to connect the drive to the course computer: WARNING: Electrical safety 1. Measure the total distance of cable run from the drive unit to the Make sure the power supply is switched off before you course computer: make any electrical connections. - Page 19 RECOMMENDED CABLE SIZES 4. Connect the cables to the course computer (See manufacturer’s 1/8 HP _ HP _ HP _ HP manual for full information) - CLUTCH terminals: brown core to +ve, blue core to -ve. Cable Run C.S.A. of Cable in mm in Meters - MOTOR terminals: at this stage you can connect either motor cable to either terminal.
-
Page 20: Post Installation Checks
POST INSTALLATION CHECKS MAINTENANCE Check the following points after installing the drive: Every 6 months 1. Is the drive secured to a substantial structure on the boat? • Check all connections and mountings are secure 2. Are the motor and clutch cables correctly routed and securely •... -
Page 21: Lewmar Limited Warranty
Garantie, falls die Gesetze dies zulassen, auf ein (1) Jahr beschränkt. of Sale. In the event of any conflict between the foregoing warranty and the following General Conditions of Sale on the one hand and Lewmar’s full General Terms and Conditions of Sale on the ABTRENNBARKEIT EINZELNER BESTIMMUNGEN other, Lewmar’s full General Terms and Conditions of Sale shall prevail. - Page 22 à la suite d’une utilisation normale au cours de cette période de trois ans sera Lewmar no será responsable de los gastos de transporte ni del trabajo de instalación réparée ou remplacée par LEWMAR, qui sera seul juge du bien-fondé de sa décision de réparer ou correspondiente a cualquier reclamación de garantía.
-
Page 23: Lewmar Begränsad Garanti
år från och med nyinköp av användaren. I vissa länder medges inte begränsningar på hur Toute vente est soumise aux Conditions Générales de Vente de LEWMAR qui peuvent être obtenues länge en antydd garanti varar, varför ovanstående kanske inte gäller för Er. - Page 24 HEAD OFFICE LEWMAR LTD, Southmoor Lane, Havant, Hampshire PO9 1JJ UK tel +44 (0)23 92 471841 fax +44 (0)23 92 485720 e-mail info@lewmar.com © Copyright 2003 Lewmar Ltd. All rights reserved.
Need help?
Do you have a question about the Mamba Series and is the answer not in the manual?
Questions and answers