Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for SimpliPhi Outback AccESS
- Page 1 Power. On Your Terms. SimpliPhi Outback AccESS INSTALLATION INSTALLATION MANUAL MANUAL Optimized Energy Storage & Management for Residential & Commercial Applications Utilizing Efficient, Safe, Non-Toxic, Energy Dense Lithium Ferrous Phosphate (LFP) Chemistry...
- Page 2 AccESS. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
-
Page 3: Table Of Contents
5.3 – Operating Parameters Per Warranty ................18 6.0 – SimpliPhi Technical Support ..................25 Appendix A – OutBack Radian GS8048 Modes of Operation ..........26 SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 3 |... -
Page 4: Important Safety Information
Putting the AccESS unit in Standby mode will not reduce this risk. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com... - Page 5 Cover or restrain long hair and loose clothing when working with any electrical or mechanical device. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 5 |...
- Page 6 SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
-
Page 7: Limitations Of Use
IEEE 1547.1 to the standards listed in both UL 1741 and IEEE 1547. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com... -
Page 8: Product Description
Max Output Charging Current 115 ADC 115 ADC CEC Weighted Efficiency 92.5% 92.5% OutBack GS Load Center GSLC175-PV-120/240 GSLC175-AC-120/240 SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 8 | REV11119... - Page 9 Automatic Generator Start Two-wire automatic generator start safety relay must be used System Display & Controller MATE3s MATE3s SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 9 | REV11119...
-
Page 10: Inside The Access Nema-3R Rated Cabinet
OutBack Radian GS Load Center (Model GSLC175-PV-120/240 in a DC Coupled configuration / Model GSLC175-AC-120/240 in an AC Coupled configuration) SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 10 |... -
Page 11: Pre-Installation
Do not mix PHI 3.8 Batteries from different installations, clients or job sites. This will void the Warranty. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 11 |... -
Page 12: Installation Tools And Materials
NEMA-3R use. Please see Figure 3.0 below for physical AccESS dimensions, as this may impact the site location. Rain hood(s) optional Figure 3.0 – AccESS Unit Dimensions SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 12 | REV11119... -
Page 13: Clearance Requirements
AHJ, which may exceed the requirements shown. Figure 4.0 – AccESS Unit Clearances SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 13 |... -
Page 14: Knock Out Locations
Secure the AccESS to the concrete with concrete anchors, such as threaded rods, masonry bolts, or carriage bolts, minimum ½” diameter. See Figure 6.0 below for details. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com... - Page 15 Figure 6.0 – AccESS Unit Knockouts (Bottom) SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 15 | REV11119...
-
Page 16: Installation & Wiring
(positive to positive), and each negative busbar parallels one set of two batteries (negative to negative). Figure 8.0 – Interconnecting Busbars Parallel the Batteries in Sets of Two SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 16 |... -
Page 17: Communications And Network Preparation
For AC Coupled wiring information please refer to the OutBack AC Coupling Application Note http://www.outbackpower.com/downloads/documents/appnotes/acc_freq_app_note.pdf SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 17 | REV11119... -
Page 18: Programming
The parameters shown in Table 3.0 below must be applied based on desired Warranty/cycle life. The AccESS comes pre-programmed for 80% depth of discharge. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com... - Page 19 When performing rapid deep charge/discharge cycles the battery should be allowed to "rest" 15 minutes in between. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 19 |...
- Page 20 When PHI battery quantities change, the capacity & charge/discharge current settings must be reassessed. Failure to do so will void the Warranty. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
- Page 21 Figure 16.0 and Table 5.0 below depict the typical voltage levels (VDC) for the PHI 3.8 Battery at various states of charge. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
- Page 22 OutBack’s AC Coupling Application Note when wiring the Grid Tie Inverter Output, AC In (Grid), AC Out and Generator connections. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
- Page 23 Procedure for Programming the MATE3s and Radian Inverter 1. Download the MATE3s and Radian AC Coupling firmware from the OutBack Power website. SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com...
- Page 24 Absorb Voltage = 54.4V / Time = 1.0 • Float Voltage = 54V / Time = 0.0 • Re-Float Voltage = 48V SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 24 | REV11119...
-
Page 25: Simpliphi Technical Support
6.0 – SimpliPhi Technical Support For technical support related to your AccESS, please contact us as follows: 805.640.6700 techsupport@simpliphipower.com SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 25 | REV11119... -
Page 26: Appendix A - Outback Radian Gs8048 Modes Of Operation
Appendix A – OutBack Radian GS8048A Modes of Operation Grid Tied SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 26 | REV11119... - Page 27 Mini Grid SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 27 | REV11119...
- Page 28 SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 28 | REV11119...
- Page 29 Backup SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 29 | REV11119...
- Page 30 Support SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | (805) 640-6700 | info@simpliphipower.com | SimpliPhiPower.com | 30 | REV11119...
Need help?
Do you have a question about the Outback AccESS and is the answer not in the manual?
Questions and answers