Century Hearth FW270029 Manual

This manual describes the installation and operation of the Model FW270029 non-catalytic wood heater.
This heater meets US Environmental Protection Agency's emission limits for wood heaters. Under specific
conditions this heater has been shown to deliver heat at rates ranging from 10,370 to 29,301 BTU per hour.
Model No. FW270029
This unit has been listed by Warnock
Hersey Limited to meet or exceed
ULC S-627 Canada and UL 1482 U.S.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
2ft(635mm) HIGHER THAN
3FT(1M) MIN NEAREST POINT OF
ROOF WITHIN 10ft(3M)
FROM ROOF
PENETRATION
MINIMUM OVERALL
G
HEIGHT FROM FLOOR
15FT(5M)
Unit must be placed on a noncombustible floor protection equivalent to 3/8" millboard.
Floor protector must have min. R value of .893
Consult your local building authorities for further information.
HANDLE
Twist spring handle on in a counter
clockwise motion. Spring handle will
"thread" down to desired location.
Desired Burn Setting
Low
Med / Low
Med / High
High
**Performance may vary depending on actual home operating conditions
MADE IN CANADA BY CFM Corporation, 2695 Meadowvale Boulevard, Mississauga, ON L5N 8A3 800-668-5323
NOTE: Retain this sheet for future reference
6" Flue Required
Figure A: Clearance from combustible constructions
A minimum clearance of 18" (457mm) to the chimney connector
may be required by the authority having jurisdiction.
From Heater From Chimney Connector
A Sidewall..........17-1/2" (444 mm) D Sidewall.................28"
B Backwall...............13" (330 mm) E Backwall................15-1/2" (394 mm)
C Corner...................11" (279 mm) F Corner....................22"
G Ceiling....................54-1/2" (1384 mm)
BACK WALL
B
E
8"(203mm)
A
D
*16
**18
C
8"(203mm)
8"(203mm)
Figure "A"
*16"(406mm) U.S.A.
**18"(457mm) Canada
CAUTION: Do not open fire-door to a point where it
would be in contact with the combustible sidewall.
BE SURE TO INSTALL TWO
FULL BRICKS (S16040) IN
BAFFLE AS SHOWN
OPTIONAL FAN
An optional heat exchange blower is available for
2 FULL BRICKS
this wood burning appliance. To order please see
the local dealer where you purchased your appliance.
BAFFLE ASSEMBLY
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
Inlet Air Control Settings
Inlet Air Setting **Approx. BTU Output
Closed Fully 10,370
¼ Open 12,420
¾ Open 15,676
Fully Open 29,301
Part No S19567 Rev06
10
(711 mm)
(559 mm)
16
BACK WALL
C
13
F
13
F
Disposition Des Briques
Diseño De Colocación De Los Ladrillos
ITEM NO.
PARTS LIST
NO.
LEYENDA
DESCRIPTION
NO.
1 DOOR ASSEMBLY
1 DOOR - NO GLASS
2&3 GLASS AND GASKET
3 1/8" GLASS GASKET
4 5/8" DOOR GASKET
5 LARGE SPRING HANDLE
6 SMALL SPRING HANDLE
7 GLASS CLIP
8 GLASS CLIP
9 NUT
10 INLAY
11 HINGE PIN
12 PUSH NUT
13 FIREBRICK LT 9"x4-7/16"x1-1/4"
14 FIREBRICK LT 7-1/4"x4-7/16"x1-1/4"
FIREBRICK LT 4-1/2"x4-7/16"x1-1/4"
15
16 FIREBRICK LT - ANGLED
17 FIREBRICK LT 4-7/16"x2-3/4"x1-1/4"
18 ASH DRAWER ASSEMBLY
19 FIREBRICK FOR ASH DRAWER
www.cfmcorp.com
1 1 5
2
11
12
16
14 14 14 14
13
17
13 13 13
19
13
13 15
Brick Pattern
LISTE DES PIÉCES
DESCRIPTION
PORTE MONTÉE
PORTE - SANS LA VITRE
VITRE DE JOINT D'ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po EMPAQUETADURA DE 1/8" PARA EL VIDRO
JOINT DE LA PORTE 5/8po
GRANDE POIGNÉE À RESSORT POMO DE RESORTE, GRANDE
PETITE POIGNÉE À RESSORT
FERRURE POUR LA VITRE PRESILLA PARA EL VIDRIO
FERRURE POUR LA VITRE PRESILLA PARA EL VIDRIO
ÉCROU TORNILLO
GARNITURE DE LA PORTE INCRUSTACION
GOUPILLE DE CHARNIÈRE PASADOR DE BISAGRA
ÉCROU À RESSORT UNIDAD DEL DEFLECTOR
BRIQUE 9"x4-7/16"x1-1/4" LADRILLO REFRACTARIO LT 9"x4-7/16"x1-1/4"
BRIQUE 7-1/4"x4-7/16"x1-1/4" LADRILLO REFRACTARIO LT 7-1/4"x4-7/16"x1-1/4"
BRIQUE 4-1/2"x4-7/16"x1-1/4" LADRILLO REFRACTARIO LT 4-1/2"x4-7/16"x1-1/4"
BRIQUE - COUPLÉE EN ANGLE LADRILLO REFRACTARIO LT - ANGULADO
BRIQUE 4-7/16"x2-3/4"x1-1/4"
L'ASSEMBLEE DE TROIR DE CENDRE
BRIQUE POUR LE CENDRIER LADRILLO PARA DEPÓSITO DE CENIZAS
4
3 8
7
9
6
18
PART NO.
QTY
LISTA DE PIEZAS
QTÉE NO.de PC
DESCRIPCIÓN
CANT. ART NO.
UNIDAD DE PUERTA 1 S31103
UNIDAD DE PUERTA SIN VIDRIO 1 S41075
VIDRIO Y EMPAQUETADURA 1 S31128
4.0' S15001
EMPAQUETADURA DE 5/8" PARA LA PUERTA 4.6' S15011
1 S11007
POMO DE RESORTE, PEQUEÑO 1 S11008
1 S37021
2
S37020
7 S11018
1 S13144
2 S11005
2 S11090
12 S16040
4 S16043
1 S16046
2 S16042
LADRILLO REFRACTARIO LT 4-7/16"x2-3/4"x1-1/4" 1 S16224
ASAMBLEA DE CAJON DE CENIZA 1 S31298
1 S16214