Page 1
INSTRUCTION MANUAL FOR INSTALLATION, MAINTENANCE AND USE VEGETABLES WASHER “Mod. LWD-2” “Mod. LWD-3” “Mod. LWD-4” - GB -...
Page 2
Codice LWD… MANUALE D’ISTRUZIONE Storia delle revisioni Data di Punto Natura della Type of correction Verbesserungsart Type de correction Firma Visto Revis. revisione correzione Prima emissione First issue Erste Ausgabe Première émission 25/06/2004 Tutti Budel Elim.schemi el. Cadorin 29/11/2012 Tutti Agg.ATT.valvola scarico MOD.LIBRETTO PER Cadorin...
1: GENERAL REMINDERS AND NOTES 1.1. General reminders − Read the warnings container in this manual carefully as they provide important information concerning safety during the installation, use and maintenance of the appliance. − Keep these instructions carefully! − Only personnel trained for its specific use should use the equipment. −...
Page 5
Warning! : When cleaning the appliance never use direct jets of water to prevent infiltration of the liquid and damage to components. Warning! : The appliance must be disconnected from the power supply during cleaning, maintenance and replacement of internal components. Warning! : If the power cable is damaged, it must be replaced by the manufacturer or by its technical assistance service or by a similarly...
1.3. Construction Main structure in steel with 4 adjustable height feet. Vat in stainless steel. Main switch with voltage control light. Automatic charge of the water into the basin, controlled by means of level probe and solenoid valve. Water flow control knob. Timer to ad just the washing time The supplied removable walls permit to subdivide the washing basin into several sections and to wash different types and quantities of vegetable at the same time.
2: POSITIONING, INSTALLATION AND MAINTENANCE 2.1. Positioning − Remove all the packaging and check that the appliance is in perfect conditions. In case of visible damage, do not connect the appliance and notify the sales point immediately. − Remove the PVC protection from the panels. −...
2.2.1. Connection to waterworks − Water inlet pressure must be between 50 and 500 kPa, otherwise install a pressure regulator on the line before the appliance. − Install a cut-off valve for each supply on the line before the appliance. −...
3: USE 3.1. Warnings and hints for user − This manual contains all the instructions required for a proper and safe use of our appliances. Keep the manual in a safe place for future consultation! − This appliance is for catering use, hence they must be used only by trained kitchen staff.
3.2. Instructions for use − Before starting the appliance for the first time wash the interior of the vat thoroughly. Warning! The supplied removable walls permit to subdivide the washing basin into several sections and to wash different types and quantities of vegetable at the same time.
Warning: tank water loading does not start if drain cock is open (indicated by indicator Turn the tap (8) clockwise up to stop. The indicator (4) goes off and the H2O load is started in the tank 3.2.2. Washing Introduce the product you wish to treat in the tank. Set the desired time ( from 0 to 5 minutes ) by turning the knob of the timer (6).
3.2.3. Washing with separators If you want to split the washing tank into several compartments, for washing different types of vegetables, you must use the separators supplied with the appliance. Warning: : When inserting the separators, pay attention to the guide pins on the top of the tank (front and rear), and to the centering pin of the separator entering the corresponding hole (wider than the others) of the false bottom.
Page 14
3.2.4. Tank discharging Turn the exhaust lever (8) counterclockwise to the limit switch Once the water has been let out of the tank, you can collect the vegetables. For a subsequent washing cycle, proceed by following the above described instructions. 3.2.5.
Warning: The bottom wash does not start if the drain cock is closed (indicated by indicator 5) Turn the tap (8) counterclockwise up to stop. The indicator (5) goes off and the bottom washing is started. 4: CLEANING 4.1. Cleaning and care of the appliance −...
4.1.1. Daily cleaning Warning! : When cleaning the appliance never use direct jets of water to prevent infiltration of the liquid and damage to components. Warning! : The appliance must be disconnected from the power supply during cleaning − Clean the vat with water and a detergent, rinse thoroughly and dry well with a soft cloth.
4.2. Special procedures in case of prolonged inactivity − If the appliance is to stand idle for any length of time (e.g. holidays or seasonal closing) it must be cleaned thoroughly, leaving not traces of food or dirt. − For added care after cleaning, the external surfaces can be protected by applying a proprietary metal polish.
5: FIGURES AND DETAILS 5.1. Size of appliance and position of connections E = POWER CABLE ENTRANCE 400V 3N+T B = COLD WATER INLET 3/4" S = OUTLET ø40 (WITH FLOOR DRAIN TRAP 300x300 mm) Instruction manual for installation, maintenance and use LWD-GB-02 18 di 20 Pagina...
5.2. Controls LEGEND: Main switch Indicator light closed drain Indicator Tension ON Regulator for whirlpool intensity Selector switch automatic charge and bottom Washing timer cleaning Indicator light open drain Tank discharging Instruction manual for installation, maintenance and use LWD-GB-02 19 di 20 Pagina Vegetables Washer...
DISPOSAL EQUIPMENT Directives 2002/95/EC, Directive 2002/96/EC and 2003/108CE The symbol on the rating plate indicates that the product at the end of its useful life, must be collected separately from other waste. For the recycling of this equipment at the end of life, contact the supplier of the equipment itself Instruction manual for installation, maintenance and use LWD-GB-02 20 di 20...