Panasonic TK-AB50 Operating Instructions Manual

Panasonic TK-AB50 Operating Instructions Manual

Alkaline ionizer

Advertisement

Operating Instructions
Thank you very much for purchasing our Alkaline Ionizer.
感謝您選購Panasonic電解水機。
 P lease read these instructions carefully before using this product, and save this
manual for future use.
 P lease carefully read the "Safety Precautions" (P.EN4 ~ EN7) of this Manual
before use.
 B e absolutely sure to check that the purchase date has been entered on the
warranty.
 P lease keep in mind that the manufacturer of the product will not be responsible
for any product malfunctioning or accidents resulting from the improper
installation or operation of the product.
 請 在使用本產品之前仔細閱讀本說明書,並妥善保管本說明書以備日後使用。
 請 在使用之前仔細閱讀「安全注意事項」(TC4~TC7頁) 。
 保 證書上的「購買日期」請務必填寫。
 因 安裝錯誤或不正確使用,而造成產品故障或發生事故時,本公司恕不負責。
Use properly to economize on electricity
版-ZGS0TKAB500EXZ-取扱説明書(W).indb 1
Attached Installation Instructions
使用說明書
Alkaline Ionizer
Model No.
正確使用,節省用電
另附安裝說明書
For Household Use
電解水機
家庭用
TK-AB50
We use NSF42 certified
activated carbon.
我們使用 NSF42 認證的活性碳.
COMPONENT / 成分
Activated carbon (APG-05TGA
60/200) manufactured by
Kuraray Co.,Ltd. used in this
product is Tested and Certified
by NSF International against
NSF/ANSI Standard 42 for
material requirements only.
(Check Date (2017.2.1))
本產品使用的活性碳由 Kuraray
Co.,Ltd. 製造的(APG-05TGA
60/200) 物料需求由 NSF 國際通
過 NSF/ANSI Standard 42 檢測
和認證。
(檢查日期 (2017年2月1日) )
2018/9/26 15:41:48

Advertisement

Table of Contents
loading

Summary of Contents for Panasonic TK-AB50

  • Page 1 Attached Installation Instructions 使用說明書 另附安裝說明書 Alkaline Ionizer For Household Use 電解水機 家庭用 TK-AB50 Model No. Thank you very much for purchasing our Alkaline Ionizer. We use NSF42 certified 感謝您選購Panasonic電解水機。 activated carbon. 我們使用 NSF42 認證的活性碳.  P lease read these instructions carefully before using this product, and save this manual for future use.
  • Page 2 Use Concealing Alkaline Ionizer 13 substances specified by JIS standards Free residual chlorine, turbidity, total trihalomethane, chloroform, bromodichloromethane, dibromochloromethane, bromoform, tetrachloroethylene, trichloroethylene, 1,1,1-trichloroethane, CAT (pesticide), 2-MIB (mold smell), soluble lead Japan Water Purifier Association voluntary class 4 substances Iron (particulate form), Aluminum (neutral), Geosmin (mold smell), Phenols 01_TK-AB50-ZEX_ZMA_EN.indd 2018/08/31 14:47:14...
  • Page 3: Table Of Contents

    Contents Safety Precautions ........................EN4 Operating Precautions ......................EN8 Names of the Parts and Steps to Take Before Operation ............EN9 Steps to Take Before Operation ....................EN10 Check the setup and accessories of the concealing alkaline ionizer ...... EN11 Installation 1 Check after installation....................EN12 Installation 2 Measure and adjust the pH level of water...............EN12 Installation 3...
  • Page 4: Safety Precautions

    Safety Precautions Please make sure to follow these instructions In order to prevent accidents or injuries to the user, other people, and damage to property, please follow the instructions below.  The following charts indicate the degree of damage caused by wrong operation. WARNING CAUTION Indicates serious injury...
  • Page 5 ( Doing so can lead to a smoking, a → P lease contact a dealer or subordinate fire and/or electric shocks.) <Examples of abnormality and fault> service station of Panasonic for inspection or maintenance. • Abnormal sound during operation • Abnormal heat or deformation of  Do not use water sources other than...
  • Page 6 Do not reuse old hoses.   Please contact a dealer or subordinate service station of Panasonic for the installation and removal of the Alkaline Ionizer. (Incomplete installation may lead to a fire, electric shock, accident or water leakage.) Alkaline ion water not applicable for drinking and its usage  Do not drink the following kinds of water:...
  • Page 7 Power plug  When unplugging the power plug from a power outlet, the plug should be held in hand. (To avoid electric shocks or fire hazards due to poor insulation) pH test liquid  Do not bring the pH test liquid near a naked flame. (Doing so may cause it to ignite, causing a fire.)  Do not drink the pH test liquid or the water containing the test liquid or put in your eyes.
  • Page 8: Operating Precautions

     Due to the quality of tap water in the or subordinate service station of Panasonic for handling. residential area, the pH level of the water  Do not let the movable part or door of a may not be adjusted to the specified level.
  • Page 9: Names Of The Parts And Steps To Take Before Operation

    Names of the Parts and Steps to Take Before Operation  Accessory marked in is in the deep place behind the rear panel of the sink, thus it may be invisible. Overall figure Faucet Main spout Outlet pipe (not included) Special faucet for Alkaline Ionizer Control panel...
  • Page 10: Steps To Take Before Operation

    Steps to Take Before Operation Installation 1 Check the setup and accessories of the P.EN11 concealing alkaline ionizer Installation 2 Check after installation P.EN12 The air in the main unit is not completely exhausted, please drain the purified water for 5 minutes.
  • Page 11: Installation 1 Check The Setup And Accessories Of The Concealing Alkaline Ionizer

    Check the setup and accessories of the concealing Installation 1 Alkaline Ionizer In case of any deficiency, please notify your dealer or subordinate service station of Panasonic.  The main unit shall be installed under the sink and connected with the special faucet for Alkaline ...
  • Page 12: Installation 3 Measure And Adjust The Ph Level Of Water

    Check after installation Installation 2 To exhaust the air in the main unit, the purified water shall be drained for 5 minutes. To use the concealing Alkaline Ionizer (P.EN16) ❶ Press Purified ❷ Press Water Stop/Flow The blue water signal indicator will flash for about 20 ~ 30 seconds and ...
  • Page 13 Measure and adjust the pH level of water Installation 3 Procedure for measurement What to have ready: pH test kit (supplied accessory) Put 2 drops of pH test liquid in to the test tube. The pH cannot be determined accurately any amount ...
  • Page 14 Measure and adjust the pH level of water Installation 3 (continued) When is adjustment necessary? When the measurement results are beyond the range of “pH level standardˮ , adjustment shall be made. After the completion of adjustment, the pH level shall be measured again. When the pH level of the alkaline ion water No adjustment required strong or weak acidic water is within the range...
  • Page 15: Selectable Water Quality Mode

    Selectable Water Quality Mode Drinking water “alkaline ion water (weak) ~ (strong)ˮ and “purified waterˮ Water quality Water outlet Water Mode name Drinking Water quality pH standard Stop/Flow selector buttons position ○ Alkaline ion Adjusting pH Between 9 ~ 10 High water (strong) Daily drinking...
  • Page 16: Use Of Concealing Alkaline Ionizer

    Use of Concealing Alkaline Ionizer Preparation Outlet water ❶ ❶ Choose water quality. Press Water Stop/Flow ❷ Store the previously used water quality.  Before using, confirm the water To change water quality, see below.  signal indicator. After the water signal indicator is in blue and ...
  • Page 17 How to turn off water Water signal Main spout ❶ Press again to turn off water Water indicator Stop/Flow Alkaline ion water, purified water running. (blue, red) and weak acidic water will flow out. The water run through will not stop right ...
  • Page 18: Maintenance

    Maintenance Daily repair and maintenance Main spout Outlet pipe The main unit and the special faucet for Alkaline Ionizer Electroplating part Dip a soft cloth in water and wring it out to wipe the Alkaline Ionizer. For dirt at the main spout or drain outlet, remove ...
  • Page 19: Replacing The Cartridge

    Replacing the Cartridge Replacement cartridge Model: TK-AS45C1 When the service life of the cartridge is to be expired or the purified (P.EN31) water ability is reduced, please replace the cartridge with a new one. Filter replacement standard There are 4 kinds of change standards. If one of the following conditions is met, please replace the cartridge. The flow of purified water The total run through When there is smell or...
  • Page 20 Replacing the Cartridge (continued) Replacing method D o not unplug the power plug when replacing the cartridge.  (If the power plug is unplugged, the service life of the cartridge cannot be reset.) D o not replace the cartridge with the condition of main unit flat. ...
  • Page 21 If the outflow has not been recovered after replacing the cartridge, it may be caused by the blocking of the gasket attached with strainer of the water stop valve. Please contact a dealer or subordinate service station of Panasonic. If the cartridge is replaced before the filter replacement light (red) is flashing or on, please follow up step 6: press until the warning sound “PI-”...
  • Page 22: Automatic Electrode Cleaning

    Automatic Electrode Cleaning The inside of the main unit will be cleaned automatically under the following conditions. It will be cleaned automatically after each using. Once the alkaline ion water or When the total run through water weak acidic water has been volume of alkaline ion water or After using weak acidic water used for 10 times...
  • Page 23: Q&A

    Q&A Question Answer What should I do when Remove the cartridge from the main unit, put it inside a plastic bag, remove  I’m not going to use the the air from the bag and close it, and then store the bag in the refrigerator. Disconnect the power plug.
  • Page 24 When the electrolyzer is powered-on, the electrode plate will be consumed. When all the water quality indicator lights are light up, and there are 5 warning sounds of “PI-”, it means the service life of electrolyzer has been reached. Please contact a dealer or subordinate service station of Panasonic. EN24 01_TK-AB50-ZEX_ZMA_EN.indd...
  • Page 25: Troubleshooting

    In case of suspected fault, please check the following conditions before sending the Alkaline Ionizer for inspection. In addition, if there is any abnormal condition, do not dismantle the Alkaline Ionizer by yourself. Please contact a dealer or subordinate service station of Panasonic for handling. Pages for...
  • Page 26 None of the display light Hasthepowerplugbeenunplugged?  in the control panel is on. → P leaseplugthepowerplug. Machinefault  → P leaseunplugthepowerplugandcontactadealeror — subordinateservicestationofPanasonic. TheservicelifeoftheAlkalineIonizer’selectrolyzerhasbeen All the water quality  indicator lights suddenly reached.(About850hours) flash or light up, and (Awarningsoundof“PI-”willbemadeforfivetimes.) the button cannot be → I ftheelectrolysistimeisover850hours,theelectrodeplate...
  • Page 27 Cause and method of disposal reference The water flow is reduced, Is the water pressure too low?  or the water cannot flow → I tisnotafault.Pleasecontactadealerorsubordinate — out. servicestationofPanasonic. Isthewaterstopvalvetootight?  →Pleaseopenthewaterstopvalve. EN17 Isthefilterreplacementlight(red)on?  → P leasereplacethecartridge. EN19 ~ EN21 Hasthecartridgebeeninstalled? ...
  • Page 28  This phenomenon is also easy to happen when the water pressure is relatively high. At this time, please contact a dealer or subordinate service station of Panasonic.) Compared with the early use period, the amount of drip has increased.
  • Page 29: Optional Accessories

     happen due to the phenomenon of heating, etc. P lease contact a dealer or subordinate service station of Panasonic as soon as possible.  W hen the power cord is damaged, it is required to be replaced by a dealer or subordinate service ...
  • Page 30: Specifications

    Specifications Rating 220-240 V ~ , 50 Hz, 0.5 A Power consumption Approx. 45 W (approx. 1 W during standby) Main unit ABS resin, platinum group metal, titanium Materials Faucet Polyethylene, stainless steel, POM resin Connecting pipe Polyethylene, brass Non-woven fabric, granular activated carbon, ceramic, Filter material powdered activated carbon, hollow fiber membrane 2.2 liters/minute...
  • Page 31 The above values are given for cartridge TK-AS45C1.  All figures given are for a water temperature of 20 °C.  This product cannot convert hard water into soft water.  Note 1: The water which can be used as alkaline ion water and acidic water is equivalent to about 92 % of the filtration flow volume.
  • Page 32 All the water quality indicator  or subordinate service applicable? lights light up and the warning station of Panasonic to sound beeps for five times. handle the issue. Some other trouble or failure  has occurred. 愛心檢查 請對長年累月使用的鹼性離子整水器進行檢查...

Table of Contents